What happens if your Hyundai Santa Fe fuel pump goes bad?

If your Hyundai Santa Fe’s fuel pump goes bad, no fuel (or not enough fuel depending on whether or not it’s out all the way) can enter the engine. Without gas your Santa Fe will not run at all. With that in mind, most of the symptoms of a bad fuel pump revolve around the vehicle stalling out or not running at all.

What are the symptoms of a bad fuel pump?

Also, the symptoms are almost exactly the same as bad/clogged fuel filter. Here are the most common symptoms of a bad fuel pump in your Hyundai Santa Fe: One of the most common signs that a fuel pump is going bad is a whining sound. The whining sound can indicate that the fuel pump is going out before there are any performance based issues.

Where does the fuel pump go in a car?

In modern fuel injected vehicles, the fuel pump sits right in the fuel tank and “pushes” the gasoline to the fuel rail (s). It is in the fuel tank because “pushing” fuel to the fuel rail is easier than “pulling” the fuel, which is what an inline pump would do.

What do you need to start a Hyundai Santa Fe?

At the most basic of levels your Hyundai Santa Fe needs three things to start: Air, fuel, and spark . If any of these things aren’t present, the engine won’t turn over at all.

What happens when the fuel pump goes bad on a Hyundai i30?

If your Hyundai i30’s fuel pump goes bad, no fuel (or not enough fuel depending on whether or not it’s out all the way) can enter the engine. Without gas your i30 will not run at all. With that in mind, most of the symptoms of a bad fuel pump revolve around the vehicle stalling out or not running at all.

Here are the most common symptoms of a bad fuel pump in your Hyundai i30: One of the most common signs that a fuel pump is going bad is a whining sound. The whining sound can indicate that the fuel pump is going out before there are any performance based issues. Keeping an open ear can save you from getting stuck somewhere with a bad fuel pump.

What makes a Go4 a good parking vehicle?

An ideal vehicle for parking management. Twin passenger with an optional right hand. Compact, nimble, and built tough with a 2.5 steel rollbar chassis. Excellent stability with two wheels up front and one wheel in the back. This compact and nimble unit allows operators to quickly and efficiently navigate congested traffic.

What kind of Fuse does a Hyundai Santa Fe have?

Hyundai Santa Fe (2004 – 2006) – fuse box diagram Year of production: 2004, 2005, 2006 Engine compartment Description Ampere rating [A] Protected components FUSIBLE LINK ALT 120 Generator B+ 50 Tail lamp relay, Fuse 11~17, Power connector IGN 50 Start relay, Ignition switch BLR 40 A/C Fuse, Blower relay ABS.1 30 ABS control module, …

At the most basic of levels your Hyundai Santa Fe needs three things to start: Air, fuel, and spark . If any of these things aren’t present, the engine won’t turn over at all.

What should I do if my Hyundai Santa Fe has a problem?

According to the dealer, the manufacturer suggested that they replace the fuel injectors, drain the oil, and place new oil in the engine. The dealer stated that was all they would do to the vehicle.

When is a fuel injector considered to be faulty?

Fuel injectors are deemed to be faulty if they do not operate as designed. Fuel injectors are considered to be clean if and when fuel delivery, atomization and distribution are within 1% of the design specification of that fuel injector. The injector cannot be recovered. We do not charge for the time spent on bad fuel injectors.

Why does my Hyundai Santa Fe Sport stall?

The contact owns a 2018 Hyundai Santa Fe sport. While driving with a half tank of fuel in the vehicle, it began to stall on the highway. The contact noticed fuel coming out of the exhaust and the vehicle ran completely out of fuel as she pulled over to the shoulder.

Why does my fuel pump not start when I turn the engine on?

What is happening is, when I turn the key to “on” the fuel pump primes itself, BUT when I try to turn the engine on, THE FUEL PUMP DOES NOT PUMP GAS. I did some research and found out that the PCM only tells the fuel pump to start pumping when it receives a signal from the crankshaft sensor.

Is the fuel pump on my Dodge talk still working?

Replaced Fuel Pump, STILL NO START!!!!!!! Not open for further replies. I replaced the fuel pump last weekend with a Walbro OEM replacement. Everything went jolly, no problems.

What to do if your fuel pump won’t start?

Ugh…..I hate chasing down electrical problems. If jumping the fuel pump relay makes the pump run, and if the relay tests good. Then you need to determine why the ECM is not telling the relay to close. Start by testing continuity back to the ECM.

Why is the fuel pump relay not closing?

If jumping the fuel pump relay makes the pump run, and if the relay tests good. Then you need to determine why the ECM is not telling the relay to close. Start by testing continuity back to the ECM. Here is the electrical diagram for the 01 Tib Fuel Pump Relay

Can a weak fuel pump cause a car to not start?

A weak fuel pump may still pump fuel, but the vehicle may experience difficulty starting from the lack of pressure. A weakened fuel pump can cause the vehicle to take more cranks to start than normal, and in more serious cases may even cause the vehicle to require multiple turns of the key before it will start.

Why does my gas pump keep getting bad gas?

While any station can have a batch of bad gas, it may be more likely at some than at others. Contaminants or water in the fuel can clog the fuel filter which puts more stress on the fuel pump. In the same way, be careful of additives for the tank.

How can I tell if my fuel pump relay is faulty?

2. Engine does not start. Another symptom of a faulty fuel pump relay is an engine that does not start. If the fuel pump relay fails the fuel pump will be left without power. The engine may still crank when the key is turned, however it will not be able to start due to lack of fuel.

How to fix fuel Guage on a 2007 Hyundai Santa Fe?

Please try again later. Fixed error codes P2068, P0463 & P0464 on a 2007 Hyundai Santa Fe. The fuel gauge started working intermittent and replacing the sensors was recommended. Confirmed this with a OBD scan. PLEASE DO NOT ATTEMPT THIS REPAIR YOURSELF IF YOU ARE NOT HIGHLY MECHANICALLY INCLINED. HIRE A QUALIFIED MECHANIC FOR THIS REPAIR.

What kind of fuel does a Hyundai Santa Fe use?

Hyundai Santa Fe DM 2013-2018 Owner’s Manual / Introduction / Fuel requirements Your new vehicle is designed to use only unleaded fuel having a pump octane number ((R+M)/2) of 87 (Research Octane Number 91) or higher.

What are the problems with a 2008 Hyundai Santa Fe?

1 Fuel Level Sensor Failed 2008 Santa Fe Average Cost to Fix: $500 Average Mileage: 85,000 mi 2 Gas Gauge Not Functioning 2008 Santa Fe Average Cost to Fix: $300 Average Mileage: 80,000 mi 3 Paint Peeling 2008 Santa Fe

What kind of fuel economy does a Hyundai Santa Fe get?

Both 2WD and AWD models with a 3.3 L have a fuel economy of 19 mpg ‑US (12 L/100 km; 23 mpg ‑imp) city and 24 mpg ‑US (9.8 L/100 km; 29 mpg ‑imp) highway. The 2.2l diesel engine (not available in the US) with 186 hp (139 kW) has mixed cycle of 7.2l and a city cycle of 8.0l.

Are there any changes to the Hyundai Santa Fe?

For 2008, only minor changes were applied to the Santa Fe. A navigation system made by LG was offered and the Infinity sound system and the power glass sunroof were made standard on Limited models. The non-metallic white paint trim was dropped, leaving the pearl white as the only white color available on the Santa Fe.

Why does my car not start after filling up the gas tank?

If that doesnt work, get a fuel pressure test done. The results of the test will let you know more. It could be a vacuum leak. Every time you open the fill cap, the pressure is leaving the system and without a good vacuum it will take time for the fuel to move through the rail to the cylinders.

What is the problem with my Santa Fe?

A mechanic suspects a clogged gas tank filter. Problem is, it looks like the entire gas tank has to be removed to get to it, and it is not a sure bet that that fixes it. I have a 2002 Santa Fe (6 cyl) with only about 35,000 miles on it and this identical problem just started for me about six months ago. Maybe it is a fuel filter.

Why did my Hyundai Santa Fe run out of gas?

Gas filler door stuck, almost ran out of fuel hyundai gas… I almost ran my tank dry the other day when I had to drive home with very little fuel because the gas filler door on my 2007 Hyundai Santa Fe doesn’t open when you pull the lever! It was pouring rain and I couldn’t get it open quickly so I decided to risk it.

Why is the fuel door on my Santa Fe not opening?

Very disappointed. What do I have to replace to get this to STOP? The fuel door on the Santa Fe has an electrical actuator to open the door and a back up release cable inside the vehicle near the door. The two main causes for the fuel door to not open are either a faulty electrical actuator or a worn door tension spring.

What to do if your gas tank won’t fill?

Gas Tank Won’t Fill? Let me show you how to fix it! – YouTube Gas Tank Won’t Fill? Let me show you how to fix it! If playback doesn’t begin shortly, try restarting your device.

Why does my gas tank spit out while I’m filling?

After checking with a Hyundai dealership they said there is an issue with the neck of the gas tank being too small. Simply put that build up will cause it to overflow and spit back out. Hyundai fixed the problem by making a bigger neck to the gas tank. Which should have been a recall. Because the way to fix it is replace the neck and tank.

Why does my Hyundai Santa Fe not accelerate?

Here are the most common cause of acceleration with the RPM’s going up: 1. Transmission Fluid Low. If your Santa Fe is too low on transmission fluid, it’ll will no longer be able to transfer power to the rear wheels. The power goes to the torque converter, and that’s the end of the line. You should check the transmission fluid immediately.

How to fix a car where the gas pump keeps shutting off?

How to fix the issue where you go to pump gas at the gas station and the gas pump keeps clicking off even though you have an empty tank. I will show you what to look for and how to unclog your charcoal canister and vent tubes from your gas tank. Trick to clearing your evap system from debris or clogs..

How can I tell if my fuel pump is working?

The only way to truly tell is to place a fuel pressure gauge on both sides of the line and get a reading from both. If your car isn’t starting at all, and you hear the fuel pump prime that is usually a good indication that the pump is working to some capacity.

Where is the reset button on a fuel pump?

Push the button on the inertial switch; it should be clearly marked as the fuel pump reset, and may be in a contrasting color to the case. You may need to turn the ignition key to the on or accessory position to energize the module and reset the switch.

Where is the fuel pump shut off switch located?

You owner’s manual should give the exact location, but if it doesn’t try looking inside the center console, under the front seats, behind the glove compartment or behind the driver or passenger-side kick panels. These are the trim pieces just ahead of your front doors where your foot typically brushes.

What should fuel resistance be on Hyundai Sonata?

With the engine OFF for at least 40-secs and the key turned to the RUN position, back probe the fuel sender connector and measure the resistance between pins 1 and 3. Compare the readings to the resistance values below. 2011 and later Sonata Full 6-17Ω, ½ 70-75Ω, Warning light on 168-172Ω, Empty 198-202Ω

What should I do if my Hyundai fuel gauge is wrong?

If you encounter a Hyundai Fuel gauge readings wrong or erratic condition on the vehicles listed below or find any of the following trouble codes: P0461, P0462, P0463, B1562, perform the tests shown below. What causes erratic fuel gauge readings or wrong fuel gauge readings?

What to do if your fuel pump is not working?

Check out your vehicle’s service manual to find out where to check and the proper procedure for checking it. Test for source voltage, to determine whether or not the good charge that’s leaving the fuse is getting to the pump. If no power is making it to the fuel pump, then check the fuel pump relay circuit.

How to check fuel delivery in Hyundai Sonata?

Check fuel delivery in the Hyundai Sonata if the engine runs rough, stalls in traffic or doesn’t start at all. Relieve fuel system pressure. Take the back seat cushion out and remove the access panel underneath to disconnect the connector for the fuel pump module.

Which is the best Hyundai Sonata to buy?

The Sonata was named Kiplinger’s Personal Finance “Best in Class” in 2005 and 2007 and Consumers Digest “Best Buy” in 2006. Check fuel delivery in the Hyundai Sonata if the engine runs rough, stalls in traffic or doesn’t start at all. Relieve fuel system pressure.

Why is my Hyundai Santa Fe not starting?

Battery is Charged – If the battery is charged, then it would still be advisable to take a look at the battery cables and see if there is an issue with corrosion. Otherwise, it may be the starter that you need to look at. A bad alternator can cause your battery to lose enough charge to start your Santa Fe.

Where is the fuel cutoff switch on a Hyundai Santa Fe?

checkingthe crank sensor is a good idea but there is also a fuel cutoff switch under the hood that may have been tripped. its along one of the fenders ( i tink the drivers side. doesnt happen often byt its another thing to check. if its tripped it will click when pressed (theres a little button on top of it) 82 people found this helpful.

Why does my Santa Fe have a bad fuel pump?

If you get P0420 or P0430 trouble codes with a scanner, it very well may be the catalytic converter causing these symptoms. One of the best indicators of a clogged fuel pump is going to be that the your Santa Fe is difficult to start. This because there’s not enough fuel pressure to properly atomize the fuel as it enters the combustion chamber.

Where is the transfer pump on a 2007 Hyundai Santa Fe?

2007 Hyundai Santa Fe fuel pump and transfer pump removal and location. If playback doesn’t begin shortly, try restarting your device. Videos you watch may be added to the TV’s watch history and influence TV recommendations. To avoid this, cancel and sign in to YouTube on your computer.

Why is my Santa Fe hard to start?

The fuel system concerns regarding the 2007 Hyundai Santa Fe had to do with the fuel gauge not reading correctly, the check engine light coming on, the car being hard to start after filling the fuel tank, the pump shutting off while filling the tank, the gas cap cover sticking, and the fuel gauge not reading at all.

Which is the worst year for Hyundai Santa Fe?

Despite 2007 having the most problems, 2012 is rated as the worst Hyundai Santa Fe year due to the inception of problems, the severity of the issues, and the cost of the repairs necessary to fix the damage or problems with the Santa Fe. The most reported problem of the years is with the 2007 Santa Fe for the fuel gauge not reading correctly.

Why is the fuel pump in the fuel tank?

It is in the fuel tank because “pushing” fuel to the fuel rail is easier than “pulling” the fuel, which is what an inline pump would do. While being in the fuel tank makes the pump more reliable, it also makes it a lot more difficult to get to. The good news is that fuel pumps are inexpensive.

Are there any problems with the Hyundai Santa Fe?

See all problems of the 2007 Hyundai Santa Fe . There’s been issues with the fuel pump and pressure gauge. We’ve already had this problem repaired 4 times and still suspect there’s a leak somewhere. We can smell gas in the vehicle while/after pumping and after the car has been driven.

What does error code p0108 mean on Hyundai fuel pump?

Error code P0108 relates to the Gas Tank Pressure Sensor which senses a pressure problem in the fuel tank. It could be an internal short which causes the fuse to blow consistently. The way to go is to disconnect and reconnect the battery cables to erase memory and restart the car to see if the same code returns.

Though experiences vary per owner, some have had serious trouble with the 2019 Santa Fe. Some owners have problems with the vehicle’s tech/electrical systems interfering with the engine. Others say their engines “rattle,” shut off while idling, lose power and/or acceleration, and experience other problems.

What causes a Hyundai Santa Fe to not start?

The most common causes that hinders normal starting operation of your Santa Fe are dead key fob battery, dead 12v battery, corrosion on battery terminals, bad alternator, clogged fuel filter, broken starter, blown fuse, empty gas tank, immobilizer error or any fault in the electrical system. 1.

Where are the fuse panels on a Hyundai Santa Fe?

Here you will find fuse box diagrams of Hyundai Santa Fe 2004, 2005 and 2006, get information about the location of the fuse panels inside the car, and learn about the assignment of each fuse (fuse layout) and relay. Information from the owner’s manuals of 2004, 2005 and 2006 is used.

What to do if your Hyundai Santa Fe a / C is not working?

This way, you will know which services and Hyundai air conditioning parts to get to restore your A/C into the original working condition. Let’s proceed by taking a look at some of the most common Hyundai Santa Fe A/C problems: The A/C compressor is one of the most important components of any vehicle’s air conditioning system.

Where is the fuel pump relay located on a Hyundai?

Where on a Hyundai is the fuel pump relay located? The fuel pump relay can be found in the relay box of the instrument panel on the driver side. Why did a Hyundai suddenly stop while running and the fuel pump fail to deliver fuel? This could be due to a vapor lock which has developed which is blocking the freeflow of fuel.

Why does my Santa Fe y2006 not start?

Hello, my Santa Fe Y2006 has this same problem. New glow plugs, currently changed crankshaft position sensor, battery in good condition, starter spins perfectly but no starting when cold (in the morning). Possible to start only after spraying of starting fluid directly to air filter outlet.

What are the problems with the Hyundai Santa Fe compressor?

1 The compressor clutch stops moving 2 The compressor produces loud noises when it is running 3 The cabin temperature rises (you will feel that something’s not right)

How can I Fix my Hyundai Santa Fe?

The main fix is to replace one, or both, of the fuel sensors so that the gas reading can be accurate.

Here you will find fuse box diagrams of Hyundai Santa Fe 2007, 2008, 2009, 2010, 2011 and 2012, get information about the location of the fuse panels inside the car, and learn about the assignment of each fuse (fuse layout) and relay.

Why is my fuel gauge not working on my 2007 Hyundai Santa Fe?

Fuel sensor still not working. I own a 2007 Hyundai Santa Fe, and there is a problem with the 2007 to 2010 Santa Fe’s that need to be looked at. The fuel level sending units tend to go bad which causes the fuel gauge to read empty, and activates the check engine light.

What causes a 2007 Hyundai Santa Fe to stall?

The contact owns a 2007 Hyundai Santa Fe. The contact stated that the fuel tank gauge displayed inaccurate fuel level readings. As a result, the vehicle stalled due to lack of fuel. The vehicle was taken to an independent mechanic however, he was unable to repair the failure. The manufacturer was not notified.

The main fix is to replace one, or both, of the fuel sensors so that the gas reading can be accurate.

The most recently reported issues are listed below. Also please check out the statistics and reliability analysis of Hyundai Santa Fe based on all problems reported for the Santa Fe.

Why does my Santa Fe car not start?

This is the third occassion where my 2017 Santa Fe will not start. When I turn the keys in the ignition there is no sound at all, no electricity is being sent to start the engine. However, all my lights and radio funtions work just fine. After a while the it will work again.

Can a Hyundai Elantra run without a fuel pump?

Without gas your Elantra will not run at all. With that in mind, most of the symptoms of a bad fuel pump revolve around the vehicle stalling out or not running at all. In modern fuel injected vehicles, the fuel pump sits right in the fuel tank and “pushes” the gasoline to the fuel rail (s).

Also, the symptoms are almost exactly the same as bad/clogged fuel filter. Here are the most common symptoms of a bad fuel pump in your Hyundai Elantra: One of the most common signs that a fuel pump is going bad is a whining sound. The whining sound can indicate that the fuel pump is going out before there are any performance based issues.

Why does my fuel pump only run for a few seconds?

This sound is the electric fuel pump trying to prime the fuel system. It will only run for a few seconds and then shut off. If you are not sure you could hear it or if there is noise outside; you may have to try it several times. Turn the key on and wait then turn it off.

Why is the fuel pump relay not turning on?

The ECM controls the fuel pump relay and this relay will only energize when commanded on. Does the check engine light come on; if not, then the ECM is not turning on. Do all the other combination meter warning lights come on?

What should I do if there is no power in my fuel pump?

A test of the battery with a digital tester that provides current voltage, cold cranking amps, and state of health should be done first. The battery is the heart of the electrical system and if it stumbles or fails, it can affect all other systems.

How can you tell if your Santa Fe fuel filter is going out?

The only way that you are going to know that your Santa Fe’s fuel filter may be going out is that it is no longer letting enough fuel through to keep the engine running under a heavy load, or at high-speed. Typically, if you are heading up a hill (or accelerating) the engine may start to feel like it is just running out of steam.

How much does it cost to replace a Hyundai fuel pump?

Labor cost to replace them will work out to about $110. An aftermarket fuel pump module costs $299 which is not significantly cheaper. Where on a Hyundai is the fuel pump relay located? The fuel pump relay can be found in the relay box of the instrument panel on the driver side.

Why does my car’s fuel pump keep surging?

Irregular resistance inside the fuel pump motor may cause vehicle surging, and indicates a fuel pump in need of repair. Surging feels like the gas pedal has been used. However, it occurs at a random, consistent speed. If this happens often, it may be because of problems within the fuel pump.

Navigation