Is there an issue with my Volvo S60 T20 automatic?
Volvo S60 T20 automatic, 2002 with 115,000 miles covered. Service history unknown. I have an issue with the transmission, namely that I have an error message stating ‘Transmission service required’ with an accompanying orange engine service light.
What does it mean when your Volvo transmission says service required?
If you drive a Volvo, don’t be surprised if you get a warning message such as “transmission service required,” “transmission service urgent,” or a gear symbol with a “Service Required” message. Along with this error, you may also experience harsh shifting between gears or transmission stuck in ” Limp Mode .”
How can I tell if my Volvo transmission is bad?
Volvo first starts to manifest transmission problems by hesitating to engage or take too long to change gear. As the problem gets worse, you will notice a bang or hard shifting between gear. If you ignore the problem for too long, the car will go into Limp Mode and get stuck in one gear.
Can a transmission filter be changed on a Volvo?
Change transmission fluid and filter Even though Volvo may state transmission is sealed for life, you can extend the life of your transmission by doing a transmission filter and fluid change. Doing transmission service will often improve the shifting quality. Make sure to use the recommended Volvo transmission fluid.
Why is the Check Engine light on in my Volvo?
Has the check engine light turned on in your Volvo XC90, S60, V90, or V60 Cross Country? It can be alarming seeing an engine warning appear on your dashboard, especially if you’ve never seen it before. A wide array of issues can cause a check engine light to come on, some more serious than others.
What’s the fault code on a 1996 Volvo?
These instructions work on any 1996 and newer Volvo including XC90, S40, S60, XC60, S70, V50 etc. You will get a fault code such as P0300. Researching this code online will give you a far deeper insight into the problem.
How do you replace solenoids on a Volvo?
To replace/service the solenoids you need to hold the engine up with a beam across engine bay while you drop the subframe to access the solenoid cover-a tricky time consuming exercise but worth the effort. Well after exhaustive research in the forums, Sonnax.com (USA) etc.
Do you need anti skid service on a Volvo S60?
Chances are that many of you have received the common “Anti-Skid Service Required” message from your P2 Volvo, such as the Volvo S60 or Volvo XC90. If you haven’t, there’s a good chance that you may come across it in the future.
Why does my Volvo say transmission service required?
Service history unknown. I have an issue with the transmission, namely that I have an error message stating ‘Transmission service required’ with an accompanying orange engine service light. The transmission is fine for about 10 or fifteen miles then reverts to a ‘dash’ instead of the gear reading ‘D’rive, ‘4’fourth, ‘N’eutral etc.
What kind of codes does a Volvo have?
Turns out Volvo has two sets of codes: one of Engine System Service Required and on of Check Engine. I’ve found things in the former are problems related to the siren module, the crappy auto-dimming rear view mirror and the like.
How to reset the service light in Volvo S60?
1. Turn ignition key to position I 2. Ensure that the odometer is set to “T1” position 3. Press and hold trip odometer reset button and wait until odometer goes to zero. 4. Turn ignition key to run position II (not the start position) 5. Wait until service light begins blinking and the original mileage returns to the screen. 6.
How does the Transmission Control Module work in a Volvo?
The TCM transmission control module is on a digital communication network wit several other modules in the car. When the dashboard display goes to a dash, this is usually a sign of this. Without communication to and from the engine, ABS, instrument cluster, etc, the TCM and Central Electronic Module go into a limited function mode.
What is the fault code for a Volvo transmission?
Common fault codes are TCM-002A, TCM-002B, P0733, P0734. If your Volvo transmission hesitates to shift gears, it bangs into gear; the problem could be the B4 servo.
How to reset Volvo S60 time for regular service message?
If the trip meter reset button is not released within 5 seconds the indicator is not reset. However the indicator will stop flashing. The service reminder indicator (SRI) informs the driver that it is time for the car to be serviced. The text message is displayed for 120 s each time the ignition is switched on.
Where is the alarm system required on a Volvo S60?
When faced with the “Alarm System Service Required” message on the dashboard of a 2000+ Volvo S60, S80, or V70, the problem is almost always the siren module, a device located behind the front bumper cover on the on the passenger side of the vehicle, just behind the wheel well.
What to do if your transmission is bad?
If you remove the TCM and clean the terminals with electrical contact cleaner, and work the latch back and forth several times to scrape off the oxidation, function will be restored at least temporarily. Another possibility is a bad PNP switch on the trans.
Where is the gear selector on a 2006 S60R?
2006 S60R, auto transmission. No OBDII codes stored, info display reads ‘Gear Selector Service Required’. Tried a new GSM (Gear selector module, the circuit board that lives under the shift knob)- no change.
What does Volvo AWD disabled service required mean?
When wheel slippage is detected, the computer control unit redirects torque to the rear wheels to compensate for the loss of traction at the front. AWD Disabled Service Required message on the dashboard is the first thing you notice. In some cases, this message comes on in conjunction with DTSC or anti-skid system warnings.
How often should you change the transmission fluid in a Volvo?
Even if your Volvo owner’s manual states that the transmission fluid is sealed for life, our recommendation is to change the transmission fluid and filter every 60,000 miles. Volvos may develop hard shifting or slippage due to the Transmission Control Unit (TCU) software issues.
Do you need transmission fluid on a Volvo S60?
We had just finished up all of the engine work on our 2004 Volvo S60 2.5T content car when we decided it was time to start working on the drive-train. With 151K miles on the car, we thought it was a good idea to start with the transmission fluid. Clean transmission fluid is essential to the operation of your Volvo S60 transmission.
Do you need to reset service reminder on Volvo S60?
Please try again later. After changing oil and filters in your Volvo S60, V70, XC70, S80 or XC90 you can reset service reminder yourself. You don’t need diagnostic interface or expensive computer to do so. All you need to do is perform reset procedure and your Volvos maintenance reminder will be cleared.
Is it safe to drive a Volvo with an automatic transmission?
If you are experiencing problems with your Volvo transmission, take a minute to become familiar with these problems. Volvo makes some of the safest cars on the road, but on the other hand, Volvos are known to have problems with their automatic transmission.
How can I restore the transmission in my Volvo?
Unfortunately you need a special tool to operate the violet plastic sliding cal latched that retain the TCM in the box. If you remove the TCM and clean the terminals with electrical contact cleaner, and work the latch back and forth several times to scrape off the oxidation, function will be restored at least temporarily.
Why is my Volvo transmission not working properly?
This was a new feature aiming to increase fuel economy. While it barely improved your fuel economy, it caused excessive wear in the first gear clutches. Volvo’s fix to this problem was to update the software for the Transmission Control Module (TCM). The update disabled the neutral feature.
Can a low transmission fluid level cause a problem?
If your Volvo transmission fluid level is even slightly low, it can cause problems such as transmission slipping or engine revving up when you slow down, transmission banging into gear, etc. Here are instructions on how to check Volvo transmission fluid level.