What should the oil level be on a Honda Express?
The transmission oil level should be slightly below the opening. If you put a (clean) finger into the hole you should feel oil. If you cannot, you need to add more. If the bike has many miles on it or has come from a questionable source, it is best to drain the transmission and then fill it with fresh oil.
What are the dimensions of a Honda Express?
Essential sizes are 10mm, 12mm, and 14mm. Some containers for screws and parts is also a must. Stuff like WD40 and a good spray carb cleaner will make everything easier. Some paper and pencil for notes and such is also a good idea.
What kind of plug does a Honda Express use?
If so keep going, if not you either have a bad cable, bad coil or bad points. It would be a good idea to put in a new plug if the one you have is worn or the wrong type. The 1977 uses an NGK BP6HS. The 1978 and later uses an NGK BP5HS. The UK 1978 and later uses an NGK BPR4HS.
What kind of timing cover does a Honda Express use?
The 1977 uses an NGK BP6HS. The 1978 and later uses an NGK BP5HS. The UK 1978 and later uses an NGK BPR4HS. Pull the timing cover off (the round shiny metal cover on the right hand side of the motor with HONDA written on it). turn the flywheel until you can see the points (the two metal “Fingers” that open and close as the flywheel turns.
When did the Honda Express scooter come out?
The Honda Express or Honda NC50 is a scooter made by Honda between 1977 and 1983.
What was the difference between 1980 and 1981 Honda Express?
1980 Turn signals and a larger battery to match are added. 1981 Both models see a series of improvements, including an automatic choke unit, a more rugged kick starter to replace the wind up starter, and a solid state Capacitor discharge ignition in place of the contact breaker based system.
Why was the Honda Express made so simple?
It was also designed to be simple to operate, as many owners would be inexperienced with or intimidated by larger, more complex motorcycles. Honda accomplished this by using a fully automatic transmission and a small oil pump to self-mix the Express’s oil and fuel, thus eliminating the need for premixing.
When did the Honda Express 50m come out?
The nu50 and nu50m, or Honda urban express, replaced the express II model for 1982 and was only produced until 1983.