What causes fuel injectors not to fire?
So, the most likely cause, is that the fuel injectors are probably not opening. The (PCM) uses the trigger signal from the crankshaft position sensor; and/or camshaft position sensor to pulse the injectors.
What happens when a fuel injector is not working?
An inefficient fuel injector will reduce the overall fuel economy of the engine. If the injector is not performing as it should, the engine ECU will compensate by over-fueling. This causes the engine to run “rich”, leading to more fuel being used than necessary.
What is the error code for a bad fuel injector?
For example, a fault with an injector in cylinder one would give a code of P0201. You may also see other error codes such as P0101, P0300, P0299. Visually inspect the engine bay – If you open up the hood and there is a strong smell of fuel then a leaky injector could be the culprit.
Can a broken injector cause an engine to misfire?
If you suspect that a broken injector is your problem, then the easiest way to diagnose it is to check the engine ECU for error codes. A broken injector will cause an engine to misfire and this will trigger an error code. Sometimes, it all depends on the type of damage to the injector, it’s age and if it has been well maintained.
Where is the fuel injector located in a diesel engine?
In modern common rail diesel engines, fuel pressures can be over 25,000 psi. Because the injector is seated in the top of the engine cylinder, it is constantly exposed to heat and pressure. This increases the chances of failure over time. Why Causes a Bad Fuel injector? A fuel injector will usually only fail in one of two ways.
What happens if the fuel injector is not working?
Fuel injectors are a vital part of a complex fuel management system. Furthermore, New technology has made fuel injectors more precise than ever in dispensing fuel. If the fuel injectors are not operating properly, then other parts of the engine will be affected as well.
Why does my Ford F150 have no injector pulse?
Turns out if the sensor goes bad and the computer thinks the throttle is wide open it shuts off the injectors. The injectors still receive power but wont pulse. It defaults to this so the engine doesn’t damage itself. The fuel pressure is good at around 45 psi I believe it was.
Why does my fuel injector make a sharp sound?
Fuel injectors make a sharp clicking sound, when they are functioning properly. So, the absence of this sound can indicate, a problem with an injector. In general, fuel injectors are hard wearing and with a little care, can often last; the life of the engine.
What does it mean when there is no injector pulse?
In case of that, there is no injector pulse or spark, this means that is your ECU has failed in operating in this case you have to get your ECU changed or visit an expert. You May Like: Low Fuel Light Comes on When Tank Is Full Causes and How to solve it Question: What controls the fuel injector pulse?