How much does it cost to replace a clutch on a Honda Civic Si?
The Best in Auto Repair The average cost for a Honda Civic clutch replacement is between $1,244 and $1,496. Labor costs are estimated between $644 and $813 while parts are priced between $600 and $683. This range is based on the number and age of Honda Civic’s on the road.
Are there engine swaps in a Honda Civic?
Honda engine swaps are nothing new to the world of import performance. In fact without many of these popular Honda engine swaps, it’s hard to imagine what sport compact tuning and small displacement engine performance would be today. Whether you drive a Civic, Integra, Del Sol, or CRX,…
Can a Honda Integra be swapped with a Honda Civic?
Mounts – Because the H series engine was never intended to fit in a Civic or Integra chassis, you won’t be able to combine factory OEM Honda mounts to complete your Honda swap. The cutting edge technology that drives the new i-VTEC mechanism in the K series engines first burst on the scene in the Honda Civic EP3 Si.
What kind of engine does a Honda B16 have?
The Honda B16 has appeared in six different forms over the years. The Honda B-series was replaced by the K-series in Civic, Integra, and CR-V applications.
What kind of transmission does a Honda Civic have?
The Honda B-series was replaced by the K-series in Civic, Integra, and CR-V applications. The first VTEC engine . Transmission: S1/J1/YS1 (4.4 final drive, cable clutch, optional LSD for YS1), Y1 (4.266 final drive, cable clutch, optional LSD)
How long does Civic Si clutch last?
A clutch can last 5,000 to 350,000 miles.
How do you change a clutch on a Honda Civic?
- Step 1 – Raise and secure the car.
- Step 2 – Remove the axle nut.
- Step 3 – Loosen the lower balljoints.
- Step 4 – Remove the axle.
- Step 5 – Remove the shift linkage.
- Step 6 – Begin removing the transmission components.
- Step 7 – Lower the transmission.
- Step 8 – Remove the clutch and flywheel.
How long does it take to change a clutch in a Honda Civic?
Civic can be swapped out in about 2 1/2 hours. it took my and a buddy about 8 hours to do mine. it was the first time i did a clutch on a rear wheel drive.
Can a clutch last 200k miles?
Most clutches are designed to last approximately 60,000 miles before they need to be replaced. Some may need replacing at 30,000 and some others can keep going well over 100,000 miles, but this is fairly uncommon.
How long do Honda clutches last?
The clutch should be good beyond 100,000 miles.
How do you replace the clutch on a Honda Civic?
The rear transmission mount is held in by a 17mm bolt and the starter has two 14mm bolts, a wire clip, and a 12mm cable nut. The slave cylinder assembly is held in place by two 12mm bolts. Figure 11. Remove bolts for rear torsion mount. Figure 12. Remove the starter bolts. Figure 13. Remove the clutch line bracket. Figure 14.
How do you replace the flywheel on a Honda Civic?
Use the following steps to replace the flywheel and clutch on your Honda Civic. The quickest way to reach the clutch is from underneath the chassis. In order to do this, use a jack to raise the vehicle and a pair of jack stands to support the chassis in the air. Also use this as an opportunity to drain the transmission fluid. Figure 1.
Where are the transmission bolts on a Honda Civic?
Remove the transmission top mount’s 17mm bolts. Proceed to remove the front transmission mount (three 17mm bolts and two 14mm bolts). Remove the final 19mm mount bolt located behind the transmission. Once done, loosen all four bolts that connect the transmission housing to the engine.
Where is the pressure plate on a Honda Civic?
Take the pressure plate and mount it on top of the clutch plate. Position the pressure plate so the three studs on the flywheel are visible. Once fitted, tighten the pressure plate bolts to 19 ft/lbs using a criss-cross pattern.