Why is my Mercedes air conditioner not working?

Your Mercedes vehicle will flash a host of service lights to inform you when something might be damaged inside the car. If the air conditioner unit is not running normally or is only blowing out warm air, it may be a temporary fault. Sometimes the unit isn’t actually damaged, and resetting your climate control unit …

How do you reset the AC system on a Mercedes?

Hold these buttons down for about five to 10 seconds, or until the LED lights on both buttons start flashing. Wait 45 to 60 seconds for the LED lights to stop flashing. Then turn off the car. Wait 60 seconds and then start the car engine again.

How does the defrost button on a Mercedes work?

The defrost button has three lines going through it, while the recirculated air button has a picture of a car with a curved line through it. Hold these buttons down for about five to 10 seconds, or until the LED lights on both buttons start flashing. Wait 45 to 60 seconds for the LED lights to stop flashing. Then turn off the car.

What should I do if my Mercedes engine stops working?

Be aware that if you reset the unit and it again stops working, you need to take the vehicle in to the dealership for repairs. Insert the key into the Mercedes ignition and turn the ignition cylinder to the “2” position.

What do you call a Mercedes climate control reset?

Sometimes, the process is called a Mercedes climate control reset. The reset procedure is similar no matter whatever you call it. However, if the AC shows any trouble after resetting, you have to take it to a servicing shop or the dealership for a permanent fix.

What’s the process for resetting a Mercedes air conditioner?

Why does my Mercedes E320 AC not reset?

For example, if you want to know about Mercedes E320 AC reset, it is better to check the manual and follow the manufacturer’s recommendations. If a Mercedes air condition reset does not work, these following reasons could be causing the trouble: When the AC is releasing hot air, the possible reason could be a defect in the damper.

What causes a Mercedes Benz to not start?

In most cases you will get a fault code related to one of the following: 1 ECM / PCM computer failure 2 Camshaft position sensor 3 Shifter Selector module 4 Fault codes related to driver authorization or immobilizer 5 Electrical problems

What to do if your a / C compressor is not running?

Don’t chance it! Once you have established that the system has pressure, you can try jumping pin 5 + 7 on the Klima relay, start the car and the compressor should run. If it does not run, something is wrong with the wiring or the compressor. This bypasses the pressure switch.

What to do if your Mercedes AC unit stops working?

Your Mercedes vehicle will flash a host of service lights to inform you when something might be damaged inside the car. Be aware that if you reset the unit and it again stops working, you need to take the vehicle in to the dealership for repairs. Insert the key into the Mercedes ignition and turn the ignition cylinder to the “2” position.

Why is my air conditioner not working properly?

If the air conditioner unit is not running normally or is only blowing out warm air, it may be a temporary fault. Sometimes the unit isn’t actually damaged, and resetting your climate control unit will allow your air conditioner to work as it did before.

Why is my AC not working on my GMC Sierra 1500?

Learn if it’s a simple fix or time to seek out a trusted technician. Not your vehicle? Why Isn’t My A/C Working? What are common reasons my GMC Sierra 1500 has air conditioning problems?

Why does my AC shut down when I Turn on the AC?

The whole system will shut down and won’t start off if the motor is malfunctioning. You need to check the motor to see if the issue is repairable or you need to replace it. Similarly, problems with the AC compressor may cause the whole system to shut down.

What are the most common air conditioner problems?

Common A/C Problems 1 A/C Blowing Warm Air 2 No pressure or low refrigerant levels in the A/C System 3 Compressor Clutch 4 Freon R134a leaks 5 A/C compressor not engaging. 6 Liquid lock of the compressor 7 A/C blowing hot air 8 Compressors switches on then off very quickly.

What causes an air conditioner compressor to disengage?

The A/C system is designed to disenage the A/C if the pressure in the lines is to low. This happenes to protect the system. Compressor could be disengaged becasue the system does not have enough refrigerant pressure to trip the low pressure cutoff switch that cycles the compressor. Be careful to not overcharge the system either.

How to troubleshoot your car’s air conditioner problems?

Check to see that the cooling fans on radiator are running when the air conditioning is on. Most cars are designed to have the radiator cooling fan kick in when the A/C is on. Check the compressor has engaged. Identify the location of your compressor. Look at the pullyer and you should be able to see if it spining or not.

What to do if your AC blower is not working?

Disconnect cables to motor and resistor. Remove hose from motor, it should just pull off with little effort. Unscrew motor and resistor. Screw new motor and resistor in. Connect hose to motor. Connect cables to motor and resistor. Turn on car and test AC. Thanks for watching! Loading…

Is the a / C blower motor still original?

It just doesn’t cut it in the Georgia summer heat! – the blower motor turns just fine and doesn’t seem to have a lot of resistance to it, although the plastic fan portion itself is still labeled 2/99 so it is original. I’m not sure if the motor itself is original.

Why does my blower motor not come on?

You should be able to find this relay or sequencer by tracing the blower motor wires back to the relay or sequencer. If power is going into the sequencer or relay and not coming out when the 24 volts are applied then you have a relay or sequencer problem and the sequencer or relay will need to be replaced to get your blower running right again.

Why does my air conditioner fan not come on?

Top 10 Reasons Why the Blower Fan Motor will not come on. Furnaces, Air Conditioning and Heat Pumps • Arnold’s Service Company, Inc. Top 10 Reasons Why the Blower Fan Motor will not come on. Furnaces, Air Conditioning and Heat Pumps

What is the recirculated air button on a Mercedes?

This is as far as the cylinder will go without cranking the engine. Press and hold the defrost and recirculated air buttons simultaneously. The defrost button has three lines going through it, while the recirculated air button has a picture of a car with a curved line through it.

What happens when a Mercedes Benz fuse blows?

If a fuse has blown, the inside element will be melted. Blown fuses must be replaced with fuses of the same rating, which you can recognize by the color and value. If a newly inserted fuse also blows, have the cause traced and rectified at a qualified specialist workshop, e.g. an authorized Mercedes-Benz Center.

Where are the fuses located on a Mercedes Benz W210?

Fuses on Mercedes Benz E Class W210 are located in several locations. First we will show you where to the fuse box are located on your E Class. You can also see a list of all the fuses, their designation and layout. The fuse boxes shown below are apply to 1996 1997 1998 1999 2000 2001 2002, models E320 E420 E430 E55 AMG.

Where is the fuse box on an E class?

E Class (1996-2002) W210 Fuse Box Chart Location Designation Diagram Function Fuse number ABS/ESP 19, (11)* Adjustable mirror, driver’s side 16, (3)* Adjustable mirror, passenger side (1,3)* Adjustable steering column (8,9,13,14)*

Where are the fuses located on an E420?

The fuse boxes shown below are apply to 1996 1997 1998 1999 2000 2001 2002, models E320 E420 E430 E55 AMG. The main fuse box is located on the left side in the engine compartment near the windshield. Here is a layout of the fuses in the main fuse box. Fuses in the auxiliary fuse box located on the side of the dash.

How do you defrost a Mercedes Benz without cranking the engine?

Insert the key into the Mercedes ignition and turn the ignition cylinder to the “2” position. This is as far as the cylinder will go without cranking the engine. Press and hold the defrost and recirculated air buttons simultaneously.

Why is my Mercedes-Benz E350 AC not working?

Learn if it’s a simple fix or time to seek out a trusted technician. Not your vehicle? Why Isn’t My A/C Working? What are common reasons my Mercedes-Benz E350 has air conditioning problems?

Why does my Mercedes air conditioner keep blowing hot air?

In many models, the AC keeps blowing hot air even after recharging the coolant. It is a frustrating problem, especially during the summer, when it is almost impossible to drive a car without the AC on. A Mercedes air conditioning reset is a possible solution. Do you know how to do it? Is there any other way to fix the glitch?

How to troubleshoot your Mercedes medic air conditioner?

Turn the A/C ON. If you have an Economy button make sure that is off. Make sure fan is on HIGH, temperature selector is turned all the way to COLD, and that the A/C and recirculate light indicators are on. Set the temperature to cold, the lowest setting. Set the cooling fans on high on the climate control.

How does Mercedes Benz air conditioner system work?

While the pictures on this article are of Mercedes Benz cars, this guide is written to apply to all makes and models. How the A/C System Works. A/C compressor not engaging.

What does it mean when your radiator fan is not working?

This is what we call a blown fuse. A blown fuse is no big deal, and changing one does not cost a lot of money. If your car’s radiator fan is non-functional, check your car’s user manual and locate the fuse for the radiator fan controller or the fan.

Why does my Mercedes car flash service lights?

Why is my air conditioner blowing hot air?

There are many different reasons why your AC is blowing warm air. Before calling a professional, check out these common causes that are simple to diagnose and easy to fix on your own. All of the sudden your air conditioner starts blowing hot air. With the record heatwave, your handyman may not be available anytime soon.

Why is my Mercedes air conditioner blowing hot air?

Another benefit of preventive maintenance is that in the harsher months of summer, when the weather is extremely hot, new problems can arise with your Mercedes, or any vehicle for that matter.

How to troubleshoot your Mercedes Benz air conditioner?

Identify the location of your compressor. Look at the pullyer and you should be able to see if it spining or not. The engine running turn the A/C on max cool, set fans high, and make sure that the clutch is engaging on the compressor. The pulley spins any time the engine is running. The center part of the A/C pulley only engages when the A/C is on.

How to troubleshoot a / C compressor clutch problems on your Mercedes?

This video is helpful if you are trying to troubleshoot air conditioner problems, the A/C compressor clutch in particular. This opens in a new window. Start by turning the engine on. Set the AC to maximum cold setting. Open the hood and look at the serpentine belt to locate the AC compressor.

Why is my a / C compressor not working properly?

If that unit detects an error it will not engage the A/C compressor to avoid it getting damaged. One other reason why the A/C compressor does not engage is the fact that the system may be low on R134 refrigerant. Typically older cars may have very slow leaks that may require top off with refrigerant every couple of years.

Why does my Mercedes zgw control module not work?

Mercedes-Benz Central Gateway Module ZGS (also referred to as CGW) may fail, causing various warning lights or systems to stop working. Mercedes Central Gateway module is the hub that allows communication between various modules. Mercedes ZGW Gateway control module stores data for Mercedes ASSIST or ASSYST plus.

What happens if a CGW fails on a Mercedes?

A bad CGW can also cause the engine to randomly shut off even when driving. You will have several warning lights stay ON on your cluster, and several features stop working. Below is a list of warning lights and problems you may notice if your Mercedes Central Gateway Control module fails.

Why does my Mercedes C220 AC not work?

While there are a variety of reasons your Mercedes-Benz C220 air conditioning won’t work, the most common 3 are a refrigerant leak, an electrical climate control issue, or a problem with the air conditioning compressor. What will be the outcome of an air conditioning system diagnosis?

Why is my a / C CLUTCH not working on my Mercedes?

The A/C compressor clutch engages to create the high pressure in the refrigerant and it’s state is controlled by the Air Conditioner Control Unit. If there are error codes on the A/C Control Unit the compressor will not engage and you will need to reset the fault codes using a diagnostic scanner such as the Launch Creader or iCarsoft MB II.

What to do if your Mercedes heater blower is not working?

My blower motor was fixed in with 3 posidrive screws. Had to use a stubby screwdriver on one of them too due to a serious lack of room. Check first before just pulling it out Rooty.

Why is my C230 Komp heater not working?

C230 Komp blower has been off and on since last year, and only working on 5 when it did. Worked fine over summer. Now that it is cold, it stopped for the most part. Read the threads here….pulled cover off from under passenger foot well and access the blower motor and wiring. Wiggled wires and checked connections and that did the trick.

Where is the fan on a 1999 V220 Ambiente?

Click to expand… I have a 1999 V220 Ambiente with same problem, fan sometimes works and comes on over speed bumps. I have located the motor, visible behind left hand dash vent, but can’t get at it to remove. Even when working it’s not powerful so needs replacing or new brushes, just need to remove it.

What are the warning lights on a Mercedes Benz?

The following are warning lights and indicators found in vehicles built by Mercedes Benz. Click a link to learn more about each one. They are roughly ordered by importance, which tends to be by color (red, amber, yellow, orange, green, blue, gray), but there are over 40 of them so be patient!

What to do when your Mercedes goes into limp mode?

You may also get a check engine light if your transmission goes into limp mode. When a Mercedes-Benz goes into limp mode, it only operates in second gear and reverse only. When you put it in gear, you may also feel a bang as transmission engages. The first thing you should try is to check the transmission fluid level.

Why does my Mercedes engine not turn off?

Last but not least, the issue with this Mercedes was the engine not turning off when the key was removed from the ignition. While the instrument cluster lights would turn off once you removed the key, the engine would still run.

What to do if your Mercedes AC unit is not working?

However, there might not be any damage in the AC unit when it is blowing warm air or not running properly. It could be a temporary fault and a reset is likely to be enough to restore the normal function. Sometimes, the process is called a Mercedes climate control reset. The reset procedure is similar no matter whatever you call it.

Why is my car heater not working properly?

The last common problem with car heaters is a water leak. There are many different places leaks can surface, so be sure to check your hoses, radiator and water pump for damage. If any of these three are leaking, your car heater won’t work properly.

What to do if your car AC is blowing hot air?

If the puncture is large and easy to see, replacement is likely your best bet. If you cannot see the puncture, consider adding UV dye to your air conditioning system to identify the puncture point, or simply add Red Angel Air Conditioning Stop Leak to your air conditioning system to quickly and permanently seal the leak.

Can You charge an air conditioner with 134a?

Once I cleared codes (easily), I was able to hook up a can of 134a to the low side line and charge the system successfully. If you have the same problem and no leaks (or very slow) you should be able to rectify this with a $30 can of 134a and some simple button pushing.

Is there a reset procedure for The S430 HVAC system?

I have read thru the encyclopedia, and have done advanced searches with no answer – is there a reset procedure for the 2003 S430 HVAC System without using the DAS/STAR system? Mine is occasionally doing some odd things… I have the same car.

What is the code for Mercedes Benz air conditioning?

Also make note of the recharged bar pressure (17) – you can periodically check code 7 to make sure the system is holding the refrigerant pressure – if it decreases over time you have a slow leak and need to address it. Hope this helps and good luck! 2001 E55, 1999 C43. thanks!

Is the Mercedes Benz HVAC unit N22 defective?

B1000 Control unit N22 (AAC pushbutton module) is defective. B1464 M16/20 Right center vent temperature regulating flap actuator motor. Click to expand… And a followup to EX-FED.

How do you reset the air con in a Mercedes Benz?

Pop out the left and right auto vent buttoms, then press the the left one in FIRST, and then the right one. The system resets. Ignition off, then back on again , and the air con screen is back to normal. I assume this should be performed AFTER you have replaced the AC charcoal filters (not the cabin filters).

Why is the air conditioner on my Mercedes not working?

The hot summer days are here and you realize that the air conditioner on your Mercedes-Benz is no longer blowing cold air. A/C problems can be complicated but it also can be something as simple as the system being low on freon. This is usually one of the most common problems.

Why does my Mercedes-Benz A / C blower run uncontrolled?

But under fault conditions it could fail as ‘always on’ or ‘never on’. Mostly (according to this forum) a failed BR causes the a/c blower to run uncontrolled. Btw your WIS a/c circuit diagram is not identical to mine for W208. However the blower motor/regulator part is the same.

How can you tell if a Mercedes CLK320 is bad?

You can tell they’re bad when they rattle just off idle. The power seat motors are common. If you’re handy, each motor will take about an hour and cost about $130 at the dealer. If you’re not handy the dealer will probably bill a couple of hours labor on top of the part.

How does the climate control reset work on a Mercedes Benz?

The reset works as follows: With the key in the ignition and in posistion 2 push both the defrost button and the recirc button (at the same time) for five seconds or untill the led lights in those buttons begin to flash. Wait for 30 seconds or untill the led’s stop flashing.

Why is my Mercedes air conditioning not working?

All Mercedes cars have a series of service lights that there is something wrong with an internal component or system. However, there might not be any damage in the AC unit when it is blowing warm air or not running properly. It could be a temporary fault and a reset is likely to be enough to restore the normal function.

What should I do if my Mercedes is overheating?

If you are able to top off the coolant, or use a bottle of water for now, it may help bring your car out of its heat spell. After you have pulled over, and if you are not the world’s most prepared driver who carries extra antifreeze in his car, give your Mercedes a break—let it cool off for about a half an hour.

What causes a Mercedes C class to fail a state inspection?

If you take a Mercedes-Benz for state inspection, it is very likely to fail due to suspension issues especially if the car has over 100k miles. Broken window regulator on Mercedes C-Class. Window regulators do the hard work when you press the button to lower or close the windows.

What are the most common problems with Mercedes Benz cars?

8 Most Common Mercedes-Benz Problems 1 Rust. Rust behind license plate / trunk area. 2 Engine Mounts. Engine mounts on Mercedes-Benz cars are oil filled. 3 Suspension & Steering Components. Ball joint / front control arm. 4 Window Regulators. Broken window regulator on Mercedes C-Class. 5 AirMatic Components. …

Where does air leak in Mercedes Benz W210?

Just be sure to check all possible places air can leak in between the cylinders and the ICV. This also includes the oil dipstick O-ring, the oil filler cap, valve cover gasket, PCV valve and also the intake manifold gaskets. Sometimes, the process of eliminating all of the leaks can be quite frustrating.

Why is my Mercedes Benz W210 running rough?

Many times, a lean running condition can be traced back to a cracked or torn boot in the system. A good quick way to check the overall health of the system is to take the oil filler cap off with the engine running. If the system is in good shape, the idle of the engine should drop and the car will run rougher.

Why does my AC blower trip the breaker?

This causes the blower to draw more electricity and trip the breaker. Solution: Change the air filter. Your AC system has an inside unit and an outside unit. The inside unit absorbs heat from your air using refrigerant. That refrigerant flows to the outside unit to disperse the heat.

Why does my AC keep starting and stopping?

As a result, your AC system will start and stop continuously. Check whether the screen of your thermostat is fading or even goes blank. If that’s the case, then it may be running low on power or intermittently losing power.

Where is the climate control on a Mercedes Benz?

And another thing, the cabin temperature sensor for climate control is located in the cabin light, on roof, my started to make irritating noise from age, so I took that appart, there is a motor (fan, it’s tiny) I removed it, and assembled sensor back, it works without that fan, it just reacts to changes in temperature quicker.

Why does my air conditioner spin when the engine is running?

The pulley spins any time the engine is running. The center part of the A/C pulley only engages when the A/C is on. If the clutch is engaging and disengaging rapidly, the refrigerant may be low. Locate the Low Pressure A/C recharge port.

What should I do if my air conditioner is not working?

Common Air Conditioner Problems and Solutions 1 Tighten valve 2 Remove some refrigerant 3 Replace expansion valve 4 Replace reed valves 5 Replace head gasket

Why does my air conditioner keep releasing hot air?

When the AC is releasing hot air, the possible reason could be a defect in the damper. The component is in charge of the air path that goes into the cabin. Check the onboard computer if it can verify the damper’s position.

Are there any problems with my Mercedes C270?

EGR can cause problems also if blocked so a check of the EGR system is advisable. Sensor readings should be checked on a diagnostic tool such as Mercedes STAR diagnosis – the MAF (air mass) sensor can be a particular problem.

Why does my CDI sound like an air leak?

The catalytic converters are prone to blocking & can sound like an air leak at times due to the pressure build up in the system from the turbo – inspect around the cat joints for signs of soot being forced out, another tell tale sign of this problem. EGR can cause problems also if blocked so a check of the EGR system is advisable.

Why is the air conditioning in my car not working?

Having your car’s air conditioning go out suddenly can ruin your day fast. The most common causes of broken air conditioning are leaks or compressor issues. If your air is blowing cool but not cold, the problem could be a clogged filter, cooling fan problem, radiator trouble, or it could simply be that you need to recharge your AC.

How to turn off an air conditioner in a car?

Proceed to EXITING DTC DISPLAY MODE. Simultaneously press down and up arrow push buttons until the pre-selected temperature setting of “72 °F” is displayed. Turn ignition off. 1) Turn ignition on. Simultaneously press down and up arrow push buttons until the pre-selected temperature setting of “72 °F” is displayed. Press the AUTO push button.

How to remove DTCs from Mercedes A / C air conditioner?

1) After display window shows “En° d”, press AUTO push button once again. Display window should show “dE L” (delete). 2) To erase DTCs, simultaneously press down and up arrow push buttons for more than 5 seconds. The display window should show “- –“. If not erasing DTCs, press the AUTO push button. The permanent DTCs will again be displayed.

How to know if your air conditioner has a trouble code?

2) Within 20 seconds, simultaneously press REST and defrost push buttons for more than 2 seconds. The Light Emitting Diode (LED) in the recirculated air push button will blink and the display window will show “di R”.3) Press AUTO push button repeatedly, recording each DTC,until all DTCs are displayed.

Why does my climate control not work on my car?

For example, when you press the buttons to change the temperature up or down, the temperature doesn’t change. You press the fan buttons, but the blower fan speed doesn’t work. If you pay close attention, you may notice that the button doesn’t spring back.

How can I replace my climate control unit?

You can either buy a used Mercedes Climate Control Unit online to replace yours. These units don’t require any programming. Use a third party service which specializes in fixing Mercedes-Benz climate control units. You will need to remove the climate control unit which takes less than five minutes if you have the right tools.

How does the climate control work on a Mercedes?

Connect the wire harness on the back and press it in until you hear it lock in place. You should hear a click when the climate control unit is fully inserted. By the way, if the LCD display is too dim, make sure to change the small light bulb on the unit before you reinstall it.

Why is there no air coming out of the vents?

If this filter becomes clogged due to lack maintenance it will stop or slow the flow of air exiting the vents. To check this filter locate the filter housing which can be either under the dash on the passenger side or under the hood of the car, near the base of the windshield on the passenger side, remove the cabin air filter and inspect.

How to troubleshoot and repair vents low air flow?

Easy step by step guide one how to troubleshoot and repair vent low air flow, this article pertains to most vehicles. Step 1 – Most air control vents are equipped with a flow control door that is located at the vent outlet. This door is controlled by a thumb wheel that when activated will open and close the vent air flow door.

How do I stop no air from dashboard vents?

This door is controlled by a thumb wheel that when activated will open and close the vent air flow door. Work the thumb wheel from one side to the other while checking the airflow. The flow should stop and start again, if the thumb wheel does not make a difference the problem is somewhere else.

Why is my air conditioner not working in my car?

What to do when your air conditioner wont turn on?

Why does my AC only work when I Am driving?

Your AC only working while you are driving might have to do with a low refrigerant level, or it may be an indication that your electric fans are not turning on. Try checking the fuse and relays for your fans to make sure they are turning on when you turn the AC on. My AC was working fine til today I just started my car an the AC just shut off.

What to do when your air conditioner is not working?

When a system is low on refrigerant, the compressor will cycle on and off frequently. If the system is very low, the compressor will not turn on at all. The system must be checked for leaks; any leak found should be repaired and the system properly evacuated and recharged. How to find a leak (when the engine is off):

What happens if you reset your AC unit?

Sometimes the unit isn’t actually damaged, and resetting your climate control unit will allow your air conditioner to work as it did before. Be aware that if you reset the unit and it again stops working, you need to take the vehicle in to the dealership for repairs.

Why is my Mercury Grand Marquis AC not working?

Learn if it’s a simple fix or time to seek out a trusted technician. Not your vehicle? Why Isn’t My A/C Working? What are common reasons my Mercury Grand Marquis has air conditioning problems?

Why is my air conditioner not shutting down?

Adjust Thermostat Temperature Settings Check the set temperatures on your thermostat – if the set temperature is lower than the current room temperature, the air conditioner cycle will not stop. Adjust the temperature up a few degrees higher than the current room temperature, which should trigger the thermostat to shut down the air conditioner.

Can a mode door problem cause AC not to work?

Sometimes an AC system with a mode door problem could be working fine, but the air flow is being directed somewhere else, like back out to the engine, instead of into the car. Look at your cabin air filter.

Why is my AC not working in my car?

Since the AC condenser is located in front of the radiator, it’s susceptible to damage from flying road debris and other small front-end impacts. Another possibility is that AC hoses and pipes can rub against other parts while you drive, eventually causing a leak. One way you can verify this is by listening to the AC compressor.

Navigation