Why are my coolant fans not running when AC is turned on?

Coolant fans not running when ac is turned on. AC compressor clutch engage then it will disengage. System has freon in it. It was working find but now nothin7. My car has 234565 miles. My car has an automatic transmission.

Why is my 2003 air conditioner not working?

Owners of 2003’s may comment about poor A/C performance after they have pressed the A/C button and see what appears to be the snowflake illuminated on the display. What has actually happened, though, is that they have disabled the operation of the A/C compressor and the snowflake symbol, upon closer inspection, has a slash through it.

What should I do if my radiator fan is not working?

A blown fuse is no big deal, and changing one does not cost a lot of money. If your car’s radiator fan is non-functional, check your car’s user manual and locate the fuse for the radiator fan controller or the fan. The fan itself often uses a big fuse of around 50A, while there might also be a separate small fuse to the fan control module.

Why does my RV AC make a noise?

This noise is very likely caused by the fact that the rubber shock absorbers are not in their rightful place. To fix this issue, you will need to remove your AC unit shroud, find the rubber shock absorber and make sure that they don’t brush up against the fan or compressor coils. Here is a detailed guide on how to quiet your rv ac. 4.

Why is my a / C not working on my Chevy Silverado?

Subject: Air Conditioning (A/C) Blows Warm Air Intermittently. This condition may be caused by the A/C compressor clutch cycling out early when the low pressure side reaches approximately 380 kPa (55 psi). The fix is to bring the vehicle to the dealer to have the latest software installed into the vehicle.

Why is my AC unit not turning off?

There are a few reasons as to why your AC unit won’t turn off. First, it could be a busted thermostat, in which case you will have to replace it with a new one. If that does not appear to be the issue, then the circuit board could be affected, and so you will have to hire a professional.

Why does my GMC air conditioner stop working?

For about 5 miles the A/C worked normally till we hit a R/R and the bump made it stop blowing cold air and he was finally convinced. Back to the shop and 30 min later they found the problem. Turned out to be the low pressure switch, (under hood on bottom of small tank) it was corroded and causing a loss of electrical contact.

What to do if your a / C won’t turn on?

Have someone watching the A/C compressor while you start the truck and turn the A/C on. If the compressor cycles on, turn it off. You now just narrowed it down to either low refrigerant or a bad pressure switch. Cut your fingernails. That’s not me. And spell your name right. There’s two T’s in Matthew. Unless people wipe their feet on your face.

What are the symptoms of a bad cooling fan relay?

1. Engine running hot One of the first symptoms commonly associated with a bad or failing cooling fan relay is an engine that runs hot or overheats. If you notice that your engine is running at higher temperatures than normal, that may be a sign that the relay is not functioning properly.

Why does my Jetta not have a cooling fan?

Simply the engine is not hot enough to turn on the cooling fan, its not hot enough outside, you are driving getting plenty of air flow through the grille to keep things cool without the assistance of the fan. Its possible that you have no problem at all. Was this answer helpful? I got a 2002 Jetta the cooling fans don’t turn on .

How can I tell if my air conditioner relays are working?

This part can get really complicated, but the first thing to do is run the A/C with gauges connected to observe the system pressures and monitor the circuit from the PCM to the relays. You are looking to see if the PCM sends power to one or both relays to turn on the coolant fans.

Why are the cooling fans not working on my car?

1. Engine running hot 2. Cooling fans do not function 3. Cooling fans stay on at all times Average rating from 129,472 customers who received a Vehicle Engine Cooling Inspection. Most modern vehicles use electric cooling fans to help pull air through the radiator so that it can keep the engine cool.

Why does my air conditioner not work when idling?

When idling, AC does not work and engine overheats. What’s the cause? I drive a 2013 Chevy Sonic. Basically, the air conditioning does not blow cold air if the car is idling, only when in motion. It seems to blow the coldest during long periods of driving fast, such as on the freeway.

Why is my AC not working but fan is running?

In most cases, if the AC is not working, the root of the problem often traces back to the HVAC compressor. The heat of summer can be intense, and the worst thing that can happen is finding yourself with a malfunctioning HVAC compressor. A working AC will provide you with nice and cold air as opposed to bearing the brunt of warm, dry air.

Why are my aux and main cooling fans not working?

Cooling Fans: Both Aux and Main Cooling Fans Have Stopped Working… Both aux and main cooling fans have stopped working. Turning on A/C or elevated engine temp doesn’t make either fan come on. I have replaced the Main cooling fan relay but didn’t help. Not sure if there is anything else that controls both fans or would cause them both to fail.

When did my heater and a / C fan stop working?

Heater & A/C fan stopped working. Discussion in ‘ 2nd Gen. Tacomas (2005-2015) ‘ started by RCNG FAN, Dec 12, 2009 . Hope someone here can help me. Yesterday my dash fan vents suddenly didn’t work anymore.

Why does my dash fan not work anymore?

Yesterday my dash fan vents suddenly didn’t work anymore. The A/C and Recirc buttons still light up, but the fans don’t work (at any speed setting) and when I turn the dial on the right hand side to switch from one set of vents to another, nothing happens there either.

Why is my Hyundai Sonata AC not working?

Learn if it’s a simple fix or time to seek out a trusted technician. Not your vehicle? Why Isn’t My A/C Working? What are common reasons my Hyundai Sonata has air conditioning problems?

What happens if your central air conditioner is not working?

That means your central air conditioning system is vital to your home comfort. If it isn’t working correctly, your house can become dangerously hot quite quickly, and you’ll need to troubleshoot the problem.

How to repair a cooling fan in your car?

Cooling fan. How to repair a cooling fan in your car DIY with Scotty Kilmer. How to inspect and repair a cooling fan that’s not working. There’s many reasons why a cooling fan could stop working, such as a bad sensor, relay, fuse and more. DIY car repair with Scotty Kilmer, an auto mechanic for the last 42 years. 1.

Why does my car turn off when the AC is on?

My car has an automatic transmission. With A/C systems, it is important to know in what order things turn on and off. From your description, it sounds as though the compressor clutch is only engaging for a short period of time. This is usually due to a low refrigerant level.

Why are the electric fans not turning on in my car?

A short talk on why and when the electric fans turn on in car air conditioning. Also why the clutch may not engage. This car is a 2003 Dodge Caravan SE. The air conditioning fans were not turning on and thus the air con system was over heating. This is the simple trick that fixed the issue. Loading…

Why is my air conditioning not working on my Lexus RX350?

You can use power washer for cleaning, but make sure that its at low pressure setting, as high pressure can easily damage the delicate fins on the condenser. A clogged or leaking condenser can also be the reason for air-conditioning not working properly on your RX350.

Why does my a / C CLUTCH not spin when I Turn on the AC?

The center part on the pulley of the A/C compressor will not spin when you have the air conditioner off or if there is a problem. Once you turn on the AC the center part of the compressor, the AC clutch should engage and start to rotate with the pulley.

Why is my a / C compressor not working on my Mercedes?

One other reason why the A/C compressor does not engage is the fact that the system may be low on R134 refrigerant. Typically older cars may have very slow leaks that may require top off with refrigerant every couple of years. You can use a R134a recharge kit to recharge your system if the A/C compressor is not working.

What to do if your Mercedes AC unit stops working?

Be aware that if you reset the unit and it again stops working, you need to take the vehicle in to the dealership for repairs. Insert the key into the Mercedes ignition and turn the ignition cylinder to the “2” position. This is as far as the cylinder will go without cranking the engine.

Why does my AC fan keep failing to start?

If you leave the unit running, the fan motor will keep attempting and failing to start. The capacitor may also be used to keep the fan motor running properly as well as starting it.

Can a bad capacitor cause a fan not to start?

You took over its job of kick-starting the fan by pushing the blades. If the fan doesn’t start running, you may have a bad fan motor. If you have difficulty getting the blades to turn, there may be debris wrapped around the fan axle, or the motor bearings may be dirty or jammed. Here’s a second way to check for a bad capacitor.

How to troubleshoot your Mercedes Benz air conditioner?

Identify the location of your compressor. Look at the pullyer and you should be able to see if it spining or not. The engine running turn the A/C on max cool, set fans high, and make sure that the clutch is engaging on the compressor. The pulley spins any time the engine is running. The center part of the A/C pulley only engages when the A/C is on.

What causes a capacitor on an AC unit to fail?

Like batteries, capacitors lose the ability to hold a charge over time. They can also suffer damage from high temperatures or high voltage. Scorching outdoor temps plus the heat of the motor can overwhelm a capacitor and cause it to fail.

Where is the contactor switch on an air conditioner?

If you’re unsure as to what your air conditioner’s contactor switch is, it’s a switch located on the inside of your unit that ensures that there is enough voltage being provided to control the compressor as well as the condenser fan motor. When this switch goes bad, your air conditioner’s fan will not spin.

What should I do if my air conditioner fan is not spinning?

To lube up your bearings, you’ll want to first start by shutting down the power. This includes unplugging your air conditioning and turning off the breaker that provides power to it. Once you have the power off, remove the panels and insert oil into the into the lubrication ports on the motor.

Why is my air conditioner fan not working?

It’s possible that it is simply not getting power or that the capacitor is dead but the condenser fan motor itself is good. In this video I show you how you can check your AC fan motor to see if it is good or bad. Check out my “How to Fix Your AC” playlist for more videos on how to diagnose and fix your air conditioner yourself! 🙂

Where is the fan located in an air conditioner?

And while that explanation makes sense, an air conditioner has so many parts, that it can be confusing to figure out which specific component is causing the AC to fail. The air conditioner fan is located in the condenser unit (the portion of the AC that is parked outside your home).

How can I tell if my air conditioner fan is running?

Walk outside to check the condenser unit (the big box that sits outside your home). You’ll be able to see the fan from the top. If the air conditioner is on, you should be able to hear the compressor (the loud humming sound that’s typical of a running air conditioner) and you should be able to see the fan blades turning.

What to do if your AC fan motor is bad?

If you suspect the fan motor is bad, the first thing you should check is the power to the motor and the power to the air conditioning unit. Locate the circuit breaker and ensure it hasn’t tripped. If the power is fine, check to see if there is proper voltage.

What causes a cooling fan relay to stop working?

Cooling fan relays can stop working for any number of reasons. Common causes for relays going bad include: There are several ways to tell if a bad cooling fan relay is to blame for an overheated engine. The easiest method is to start the engine and then turn on the air conditioning.

What should I do if my radiator fan stops working?

Turn the air conditioning to the maximum setting – this should spark the cooling fan to immediately come on. In older cars, this typically takes about 15-20 minutes for the engine to reach the right temperature. If there’s a problem with the engine’s temperature, then this can damage the radiator.

What to do if your air conditioner cooling fan is not working?

If there is no power to the cooling fan, then check the fuses and see if they are burned. If the fuse is good, then check the cooling temperature sensor / switch. If the sensor has power to it an after, then the switch is working. If there is no power after the switch, then the coolant temperature sensor / switch would need replaced.

When to troubleshoot an electric car cooling fan?

On a warm engine, the fan may come on even if the engine is not running. When working on a hot engine or an engine that is running, keep your hands and tools away from the fan blades and moving components. Troubleshooting a cooling fan that doesn’t work can be a relatively straightforward task at times.

Why is my a / C not running when the AC is turned on?

Volume and pressure are two different properties of a gas, which the refrigerant in your A/C system is a gas when it is allowed to escape to the atmosphere. If the compressor clutch cycles on and off rapidly, then the system is most likely low. The best remedy for this is getting your A/C serviced.

Why are the fans on my car not working?

It melts and this particular part sends power to the cooling fan thermal switch AND the Fan control module. The fan module also sends power to the a/c compressor. So pretty much the fans don’t work and your a/c blows warm. Check this first before checking other areas.

Why does my PCM not turn on the fans?

You are looking to see if the PCM sends power to one or both relays to turn on the coolant fans. This should happen as the high side of the system approaches 214 psi. If it exceeds this amount of pressure and the system doesn’t turn on, one of the sensors in the system that the PCM uses to know when to turn the system on and off has failed.

Why does my AC fan not come on?

When the ac is of the radiator hoses both become same heat after a while and the overflow reservoir starts boiling over and the fan do not kick in. Any advise please. You might have an initial temperature sensor which causes the fan to come on when the temperature begins to rise; that sensor might be defective.

What to do if your Honda fans are not working?

Honda Fans not working? DO this easy check First! If your Honda Fans aren’t working it can be easy repair. I found that both the radiator fan and the AC fan weren’t working. or replace the fans, relays, temperature switch or even the fuses. The temperature switch is an easy repair and it’s even easier to replace.

What does it mean when your radiator fan is not working?

This is what we call a blown fuse. A blown fuse is no big deal, and changing one does not cost a lot of money. If your car’s radiator fan is non-functional, check your car’s user manual and locate the fuse for the radiator fan controller or the fan.

How can I tell if my AC fan motor is bad?

Check the power If you suspect the fan motor is bad, the first thing you should check is the power to the motor and the power to the air conditioning unit. Locate the circuit breaker and ensure it hasn’t tripped. If the power is fine, check to see if there is proper voltage.

Why does my AC fan keep buzzing when I turn it off?

DO NOT try the following unless you’re completely comfortable and familiar with that process. You risk dangerous electric shocks if there is still electric current flowing to the unit. Capacitors store power and may have the ability to send electric jolts even with the power to the A/C unit shut off.

Is there a way to test a radiator fan?

You can test the electrical radiator fans by taking a wire from the car battery, unplug the radiator fan connector, and put 12v+ and ground into the connector. This is the fastest and easiest way to test your radiator fans. Because the radiator fan is often drawing so much power, there is often a relay that is powering the coolant fan.

What to do when your AC Fan is not working?

Checked for incoming resistance ground to the blower, from the dash control switch and it works. Checked for battery at the blower, when the car is running. There is no battery to operate the blower. Rotated all the PDC relays around, they have the same ID, other than ABS pump.

What happens if my heat pump fan is not working?

One purpose of the fan is to cool the compressor. With the heat pump fan not working, the compressor can overheat and be damaged – and that will increase your repair bill by $1,250 to $2,000 plus. If that happens, your heat pump might be “totaled.”

Can a climate control system work with no fan?

It will still work with no fan, and you’ll usually still be able to control the temperature of the air that is blowing or trickling, out. But a climate control system with no fan to push the air around is anything but controlled.

What happens when a car fan is not working?

That means a trickle out of your vents instead of the rush you asked for. When it does happen, you’re left with a miserably underpowered heat or AC system. It will still work with no fan, and you’ll usually still be able to control the temperature of the air that is blowing or trickling, out.

When does the air conditioner fan come on?

To check the temperature at which the fan comes on, turn the A/C off and keep the engine running until it reaches normal operating temperature. Most fans should come on when the coolant reaches about 200 to 230 degrees. If the fan does not come on, something in the control circuit is defective.

How does a radiator fan work when the AC is on?

The electric radiator cooling fan assembly is controlled by a thermoswitch located in the side of the radiator. At higher coolant temperatures, the switch closes to start the cooling fans. Any time the coolant temperature rises to higher than normal levels, the fan will start and continue to run until coolant temperature returns to a normal range.

When does the cooling fan come on in a car?

Beside above, when should the cooling fan come on? To check the temperature at which the fan comes on, turn the A/C off and keep the engine running until it reaches normal operating temperature. Most fans should come on when the coolant reaches about 200 to 230 degrees. If the fan does not come on, something in the control circuit is defective.

Why is my AC fan running constantly?

Another reason your AC may be running constantly is due to air leaks in your home. If you have an older home with older air ducts, there’s a good chance that there may be areas of your ducts that allow cool air to escape. The more air that escapes, the harder your air conditioning system has to work to keep your space comfortable.

Why is AC not getting cool?

The other possible technical reasons behind AC not cooling can be a faulty run capacitor of the compressor, defective control board, bad thermistor, choked capillary, faulty motor etc.

Why is my air conditioner not cooling?

One of the main reasons behind air conditioner not cooling properly is ice formation in a split ac indoor unit or window AC as it leads to the reduction of airflow. Dirty filters, coils and below par working fans are the major reasons for ice formation on air conditioners leading to ac not cooling issue.

Why is AC not cool?

If your AC is blowing hot air, there could be a restriction somewhere in the system. The root of the problem could be as simple as a clogged refrigerant charging hose or expansion tube, as the Firestone Complete Auto Care team articulates. 2. Not enough refrigerant Another common issue is that the system’s refrigerant level is too low.

Can a car fan still run after the engine is turned off?

Then you notice the engine cooling fan is still running even though the car is turned off. It is ok for the engine cooling fan to keep running for a few minutes after turning off the car. Your car fan will run for a few minutes after you turn off the car then turn off. This is normal in many vehicles, such as BMW or Mercedes-Benz.

What are the signs of a bad cooling fan?

Common signs include the engine running hot and cooling fans either not functioning or running all the time. 1. Engine running hot 2. Cooling fans do not function 3. Cooling fans stay on at all times Most modern vehicles use electric cooling fans to help pull air through the radiator so that it can keep the engine cool.

Why does the radiator fan run all the time?

The radiator fan may run up to five minutes and sometimes longer. Unless there is an electrical issue, it may stay on all the time until it drains the battery. When the engine is running, the coolant circulates from the engine and flows to the radiator, where heat is dissipated.

Why are the cooling fans running on my Infiniti M35?

Forum for Infiniti M35 and M45, and Nissan Fuga owners. I noticed the other day when I pulled my 06′ M35X out of the garage the cooling fans were running which I thought odd but blew it off.

Is there a recall on Infiniti cooling fans?

To prevent this potential condition, Infiniti is conducting this Voluntary Service Campaign to replace the radiator fan control module free of charge for parts and labor. I went online to the Infiniti recall site and put in my VIN number to see if it cited a recall. Nothing. So are you saying this is a dealer initiated recall Campaign?

Why are my cooling fans running at all times?

3. Cooling fans stay on at all times. If the cooling fans are staying on at all times, this is another (less common) symptom of a possible problem with the cooling fan relay. If the relay shorts internally, it may cause power to be permanently switched on, which will cause the fans to run at all times.

What does the AirTap Register fan on AC infinity do?

The AIRTAP register fan is designed to quietly increase airflow coming from your home’s heating and AC systems. The AIRCOM cooling system prevents overheating, optimizes performances, and extends the lifespan of receivers, amplifiers, and other AV components.

Where are the fuse panels on an Infiniti Q45?

Here you will find fuse box diagrams of Infiniti Q45 1996, 1997, 1998, 1999, 2000 and 2001, get information about the location of the fuse panels inside the car, and learn about the assignment of each fuse (fuse layout) and relay.

Can a faulty thermostat cause a fan to run?

Faulty Thermostat: If both the fan and either the cooling or heating system are running unexpectedly, you may have a faulty thermostat. Broken Relay Switch or Short Circuit: If only the fan is running, there may be a broken relay switch preventing the settings you enter on the thermostat from being sent to the fan.

When does the HVAC fan turn on and off?

In normal operation, when your thermostat is set to “auto,” it will tell the blower fan plus the heating or cooling components to turn on and off at the same time when the desired temperature is reached. In many systems, the blower fan runs a minute or so before heating or cooling begins and ends to get air flowing.

Why does my air conditioner fan keep running?

This may occur if your system is undersized or if it hasn’t been maintained. In that case, it will keep running until the outside weather improves. Faulty Thermostat: If both the fan and either the cooling or heating system are running unexpectedly, you may have a faulty thermostat.

Why is the air conditioning in my car not working?

Having your car’s air conditioning go out suddenly can ruin your day fast. The most common causes of broken air conditioning are leaks or compressor issues. If your air is blowing cool but not cold, the problem could be a clogged filter, cooling fan problem, radiator trouble, or it could simply be that you need to recharge your AC.

What happens if your air conditioner compressor is not working?

The compressor is what pumps refrigerant through the entire system. If it is not functioning, then the system can not operate, and will be unable to produce cold air.

What are the symptoms of a bad AC pressure switch?

The most common symptom of a bad AC pressure switch are that you will notice that the AC compressor is cutting on and off rapidly when you are idling your car. These switches between on and off can be noticeable on the engine’s rpm, and you may see or feel fluctuations from it.

What happens if there is no pressure on the AC compressor?

If the AC compressor is pumping the refrigerant without the right pressure and a loss of oil, it may result in serious damage to the compressor, which may result in prohibitive repair costs.

What to do if your AC unit won’t turn on?

If your AC unit won’t turn on, here are the 6 most common reasons why and what to do. If your AC unit won’t turn on, the first thing you should check is if there was a blown fuse or a tripped breaker. There’s a good chance that the problem is a tripped breaker if the circuit was overloaded.

What happens when your air conditioner pressure switch goes bad?

When you turn on the air conditioning, you expect to feel cold air pour out. However, when the AC pressure switch goes bad, warm air might be all you get. However, this problem is also caused by low refrigerant levels, which should be checked regularly. If the compressor is clicking off and on, you are going to notice some strange sounds.

Why is my a / C not working on my truck?

This, in turn, causes the compressor motor to continue running while coolant leaks out of the system. Because the compressor needs refrigerant to operate safely, the motor ends up burning out and failing at some point.

Why does my air conditioner have excessive low side pressure?

Since the fan is not on, the freon actually seems to boil in the condenser causing the compressor to cycle and excessive low side pressure because of the condenser not being cooled down Your right about that. than there is two relay in the outside fuse box the control high and low fans. and two relay for this system.

When do you use both radiator fan and AC?

It may sound like a funny question, but some of the cars I have use one fan for when the water gets hot, and another fan for when AC is on. Onto my point.

Why are the cooling fans not running on my Pontiac?

The stock engine comes with a plastic intake manifold gasket, which is prone to failure. It leaks coolant into the cylinders and causes inefficiency in the cooling system, leading to low coolant and overheating. You can replace this gasket with a metal one, the repair is a little involved but I managed with a Haynes manual. Good luck!

Why is my Pontiac Bonneville not cooling properly?

Often they fail in the on mode and the blower won’t shut off. Ours failed on a 98 where it would go on and off and operate at funny speeds different than the regular 6 speeds settings that can be picked. I was told they’re available at Advance Auto as well as dealers, GMpartsdirect.com, rockauto.com.

Can a Pontiac Bonneville have an air conditioner?

The air conditioning works fine but if you turn the temperature up to 80 or 85 so it should be heating it does switch the air from the dash opening to the floor openings but the air is cool not hot.

How does the cooling system work on a Pontiac?

The PCM sends the signal to the BCM, which turns the fans on. Or you can buy a separate temperature fan relay system with a temp probe and bypass the system. It will work as normal cooling when needed only. Its the connecter that you unplug from the temp sensor.

Is it normal for cooling fans to run all the time?

Even with the cooling fans running all of the time, the engine thermostat should force the engine to warm up at a normal speed. The thermostat will regulate the coolant to the radiator/fans if it is working properly. It can be normal for the cooling fans to run constantly under certain conditions.

Is the Rad fan always running when the a / C is?

No problem!! A/C isn’t cooling ok till you start driving. Sitting still it doesn’t cool and the rad fan only seems to run when engine temp is calling for it. I changed the low speed fan and high speed fan relays and get the same result.

Why is my cooling fan not working on my Volvo?

Diagnosing volvo cooling fan issues. Airflow speed through a radiator is a major influence on the heat it loses. Vehicle speed affects this, in rough proportion to the engine effort, thus giving crude self-regulatory feedback. Where an additional volvo cooling fan is driven by the engine, this also tracks engine speed similarly.

How to troubleshoot an electric cooling fan problem?

1.Has the Cooling Fan Actually Failed? 1 If the fan comes on when the AC is running at MAX, but doesn’t run when the engine is hot, check the temperature sensor… 2 If the fan fails to come on, first check for a fan blown fuse or triggered breaker. On older vehicle models, you may… More …

How does an electric cooling fan work in a car?

However, some longitudinal (front to rear) mounted engines use the electric fan as well, but they usually have an engine-powered cooling fan. The electric cooling fan uses a direct current (DC) electric motor with a thermo switch, module or computer control to turn it on or off, depending on coolant temperature or AC operating condition.

Why does my car have a radiator fan?

You probably already know the purpose of the radiator and the cooling system in your car. When you are driving fast, the wind is passing through the radiator to cool the coolant down without issues, but when you are driving slow, there is no wind pushed through the radiator. This is why we use a radiator fan.

How can I tell if my radiator fan is working?

When a radiator fan works it usually makes a whirring sound that is easily noticeable. However, the radiator fan does not always start spinning on ignition. The ECU signals the radiator fan to work at the precise time. So, do not worry if the fan doesn’t immediately start working. Visually check the fan if you don’t hear its noise. 1. Broken Fuse

Why are the fans not running in my Pontiac?

your issue is with the temp switch not the temp sensor. the sensor will only operate the fans when it fails to avoid a possible overheating issue ,where as the switch is the fans main controller via ecm. the switch should be on the radiator itself or near the water pump. Hi, thanks for the answer.

What to do if your car fan is not running?

Or you can buy a separate temperature fan relay system with a temp probe and bypass the system. It will work as normal cooling when needed only. Its the connecter that you unplug from the temp sensor. That connection is usually bad and can be fixed by directly putting the wires together or cleaning each connector.

What should temp be when cooling fan does not come on?

NOTE: if the cooling fan doesn’t come on when the engine has been operating for 20 minutes or more, make sure that coolant is reaching operating temperature, around 220°F (104°C). You may be dealing with a stuck-open thermostat.

Why does the radiator fan not come on when the AC is on?

In order for the AC Condensor to do its job it must stay as cool as it can. As for the engine coolant temp sensor, if the coolant is not hot enough to make the fan come on, then there is no need for the fan yet and there is no problem.

Where is the relay on a radiator fan?

The fan relay is often located in the engine bay’s fuse box, but the best way is to check your repair manual to find where it is located. Testing a 4 pin relay is often very straightforward. Remove the relay and give 12 volts to pin 30 and 85. Ground pin 86 and check if there is voltage coming out from pin 87.

What happens if your coolant level is low?

If your coolant level is low, there is a chance that you will get air in the system, and the coolant temperature sensor will not read the coolant temperature correctly. If the coolant level is low, you need to refill the coolant to optimum levels. Failing to do so could risk your engine becoming overheated and seized.

How to troubleshoot the air conditioning in a Saturn Vue?

Air conditioning problems can often be quite simple to diagnose and even fix. Start the engine and let it to run for a few minutes to allow the air to cool. Double check the controls to make sure the correct buttons are selected. This may seem simplistic, but human error could be to blame. Check for proper levels of coolant.

Where is the blower motor on a Saturn Vue?

When properly working the sound should increase with increased air and decrease accordingly. The blower motor in a Saturn Vue is found by first removing the passenger side insulator panel. Unplug the electrical connector, remove the four screws and pull out the blower motor.

What to do if your computer cooling fan won’t run?

Replace the cooling fan relay with a new one. A stuck closed relay is the only thing that can operate the cooling fan continuously with the key off. The computer looses power with the key off and the same applies to the coolant temperature sensor. The relay, however, has direct power to one side, the same as a light switch.

Do you turn the radiator fan on or off?

The coolant temp has to be hot for the fan to come on. Yes, the fan will come on when you turn the A/C on, so that proves the fan works. Leave the A/C off for the rest of the test. Start your vehicle, and let it idle for 10-15 minutes.

Where are the fuses located on a new beetle?

The panel is located underneath the steering wheel on the underside of the dash panel. The fuses are located on the left side of the dash panel behind a cover. It is located in the center of plenum chamber (engine code BEW only, from June 2003 up to December 2006 only).

Why are the Bentley radiator fans not working?

I checked the fan circuits as per the Bentley manual today, When I jumper the terminals at the thermo switch on the radiator the fans come on, but only high speed. They won’t work on low speed. I turned the AC on with the fans on hoping it would be cool but it still won’t cool.

Navigation