Is the ZR 600 stator an open ignition?
Open Ignition: 1998 and newer ZR’s and ZL’s 1998-2002 ZRT 600,800 and 1000 with the exception of the 1997 ZR 580 that is an open ignition. With open ignitions a live wire goes from the ignition system to all of the switches.
Can a spark plug make a motor run poorly?
Spark plugs with the gap set too small on them can make the motor run poorly. If you have no spark and your trigger tests ok, your stator tests ok and you have tried a new set of coils then we’re possibly looking at a bad CDI box. There is no real good way to test the CDI other than swapping the box out with a known good CDI box.
What causes a no spark condition open loop?
If after unplugging the 4-plug connector there is no spark or the spark still looks weak, this tells you that the problem is in the major ignition components like the stator, coils, cdi, spark plugs, spark plug wires, possibly a short in the wiring harness, a bad trigger coil or on EFI models your Injector Coils are bad (they measure 19-20ohms).
When to replace spark plugs on Ski Doo?
When i replace the spark plug caps it was mild that day and the sled was running good. The next day which was a lil colder, I started the machine again and all was good. The day after it was cold again, even colder and it started after the third pull.
Why is the spark not working on my seadoo?
Once I try to start the seadoo beeps followed by a clicking noise down by the battery area. New discovery. If I press the start button before attaching my key then attach the key and press start again, my spark starts. Any thoughts ? I’m still betting faulty start switch.
Why does my jet ski engine not start?
Spark plugs are often the problem if your jet ski engine turns over, but doesn’t start, especially if you have a 2-stroke jet ski. Take the spark plugs out and examine them to see whether they’re wet or dry. If they’re dry and light brown in color, you have the correct fueling.
What was the problem with starting Ski Doo?
They put the sled on the computer and it showed up that the TPS valve was off 2 to 3 degrees. They adjusted it and all was good for that week. So my cousin and I checked it out and replaced the spark plugs.
Open Ignition: 1998 and newer ZR’s and ZL’s 1998-2002 ZRT 600,800 and 1000 with the exception of the 1997 ZR 580 that is an open ignition. With open ignitions a live wire goes from the ignition system to all of the switches.
What do you do when you unplug a 500 / 600 sled?
When you unplug this 4-prong connector (3 prong on the 1998-1999 500/600 EFi sleds) you are bypassing all of your switches (Throttle Safety Switch, Kill, Tether ect..) and all of your lights, hand warmers ect..in your handlebars. Pull the recoil over and see if you have spark or if the spark is now blue.
Where does the power go on an EFI sled?
The other 2 yellow wires in the 4-prong connector sends the power to the lights/hand warmers/tachometer. When you unplug this 4-prong connector (3 prong on the 1998-1999 500/600 EFi sleds) you are bypassing all of your switches (Throttle Safety Switch, Kill, Tether ect..) and all of your lights, hand warmers ect..in your handlebars.