How do I know if my EZ GO controller is bad?
Press the accelerator and watch to see if the voltage increases. It should increase from a reading of 0 to the full voltage of the battery. If the motor is not turning, the problem may be in the directional switch or motor. If there is no voltage, the controller is bad and must be replaced.
How much are Trojan batteries for a golf cart?
More videos on YouTube
| Product Name ↓ | Price |
|---|---|
| Trojan 27-GEL 12V, 91AH (20HR) Gel Battery, Group 27 | $392.62 |
| Trojan 31-AGM 12V, 100AH (20HR) AGM Sealed Battery | $334.90 |
| Trojan 31-GEL 12V, 102AH (20HR) Gel Battery | $406.67 |
| Trojan 5SHP-GEL 12V, 125AH (20HR) Gel Battery | $484.61 |
How do I test my EZGO TXT controller?
How to test a EZGO controller
- Connect the battery pack negative post to the negative of the meter probe.
- Connect the battery pack positive post to the positive of the meter probe.
- Switch on and then put the gear in forward, and then put the positive of the meter probe on the solenoid’s battery side.
Why is my EZGO golf cart not working?
Battery Problem Since the batteries on EZGO golf carts contain corrosive acid you’ll need to wear thick work gloves before checking the battery. Also, make sure the golf cart is turned off.
How long does an EZGO golf cart battery last?
Most batteries last five years, but some may be good for twice that long it properly maintained. If the battery is still good, examine the water level–if it is too low it can make the cart lose power. Fill with distilled water to cover the battery plates up to 1/4 inch below the fill tube.
Why is my EZGO TXT RXV clicking but not moving?
The problem of the cart’s solenoid clicking but the cart not moving is reported by many. Experts advise that checking the batteries is critical. The important thing to note is that if your cart has a battery pack rated at 36 V, it must indicate 38.22 V when fully charged. Make sure that this is happening.
Why is the forward switch on my EZGO TXT not working?
The Forward/Reverse switch carries the brunt of transmitting power from the battery to the motor. Over time it can become worn out and its contacts can burn. If this is the case you’ll need to have a certified technician to replace it with a new one that is made specifically for the EZGO TXT Golf Cart.