Where is the PNP switch on a Volvo S60?
Please try again later. Adam gives a quick DIY on how to replace the Automatic Transmission Position Switch, aka Neutral Safety Switch, aka PNP Switch located on the transmission for any 01-07 S60/V70/XC70 automatic, XC90 2.5T, S80 5cyl 04-06. Trans fault code 0039 is a common indicator of a faulty PNP switch. Loading…
What is the fault code for a Volvo transmission?
Common fault codes are TCM-002A, TCM-002B, P0733, P0734. If your Volvo transmission hesitates to shift gears, it bangs into gear; the problem could be the B4 servo.
What do you need to know about Volvo S60R?
Safety 9 Instruments and controls 33 Climate control 63 Interior 75 Locks and alarm 89 Starting and driving 101 Wheels and tyres 137 Car care 147 Maintenance and service 153 Audio (option) 181 Telephone (option) 203 Technical data 219 8 9 Safety
Can a transmission filter be changed on a Volvo?
Change transmission fluid and filter Even though Volvo may state transmission is sealed for life, you can extend the life of your transmission by doing a transmission filter and fluid change. Doing transmission service will often improve the shifting quality. Make sure to use the recommended Volvo transmission fluid.
Are there any issues with the Volvo S60?
Share it! Several complaints have been reported regarding Volvo S60 transmission shifting issues. Long shift times between gear shifts, hard shifting, hard downshifting and a loss of transmission operation all together to name a few. If the issue is minor, a transmission software update may fix this issue.
What to do about shifting in a Volvo?
There are several technical service bulletins (TSB’s) available from Volvo that address these shifting issues and they should be consulted by the repair shop during the automatic transmission diagnostic process. Regular servicing of the transmission fluid can help with preventing transmission failure, but not in all cases.
How can I get my Volvo out of Park?
Use a small flathead screwdriver to pop up the cap that says SHIFT LOCK. Insert the screwdriver into the exposed hole and press down. While you press down on the screwdriver and keep the brake pedal pressed, move the shifter from Park to Reverse, Neutral, or Drive.
Where is the shifter release on a Volvo?
If your Volvo has a big gap in front of the shifter, the shifter release is located under the small storage pad, as shown in the picture. Set the parking brakes and keep the brake pedal pressed during this procedure—there is a risk of the vehicle rolling when you get it out of the park.
What to do with PNP sensor on 1998 S90?
I documented the R&R of the PNP Sensor on our 1998 S90 this weekend. I’ll be doing this procedure again in the next couple of weeks on our 1995 960 so I got a little carried away with the level of detail in the procedue so just read it with a grain of salt. 1. Raise the front of the car, Ramps are preferable. 2.
How to remove O2 sensor from 1998 S90?
1. Raise the front of the car, Ramps are preferable. 2. Chock wheels and put transmission in Neutral. 3. Apply rust penetrant (i.e. Gibbs) to the six (4 front, 2 rear)14 mm exhaust pipe nuts. 4. Remove three 10 mm bolts that hold on the O2 Sensor wiring to the trans. cross member. 5.
What is the PNP park neutral position switch replacement code?
PNP Park neutral position switch replacement cleaning. Error code P0705, Volvo 850, S70, etc. – VOTD – YouTube If playback doesn’t begin shortly, try restarting your device.