What causes a convertible top to lock up?
The most common problems, in order of occurrence, are: Frozen pump: Broken or maladjusted tray fold switch: Burned-out relay: Low fluid level in the pump reservoir: Worn pump “O-ring: Poor ground: and Weak battery. (Pictures of 63) TOP DOWN HOW TO GET A LOCKED TRUNK OPEN
How do you open the trunk on a convertible?
HOW TO GET A LOCKED TRUNK OPEN Locate the 9/16 –inch bolts forward of the rear wheels up under the wheel well area. Remove the bolts, and, using a screwdriver wrapped in cloth to prevent marring the paint, pry up the deck lid at the left forward corner until it can be raised three or four inches.
What to do when your convertible top stops working?
By the time your convertible top stops working, the leaks should be easy to identify. Inspect the hydraulic lines. Make sure they are tightly connected. The hoses should not be cracked or leaking. Address any leaks that you may find at the pump, cylinders, or solenoid. Replace any damaged or leaking o-rings.
How can I tell if my convertible top is leaking?
You can visually inspect all the cylinders for leaks by manually opening and closing the convertible. At first, the leaks will be minor, but they will worsen over time, and you will eventually see leaks on the trunk floor or a stained convertible top.
How to add / top off hydraulic fluid for the convertible hard top?
How to add/top off hydraulic fluid for the convertible hard top. Another contribution from yours truly :] Please do sticky this for reference. Step 1: Locate access panel for the hydraulic convertible top cylinder (main).
By the time your convertible top stops working, the leaks should be easy to identify. Inspect the hydraulic lines. Make sure they are tightly connected. The hoses should not be cracked or leaking. Address any leaks that you may find at the pump, cylinders, or solenoid. Replace any damaged or leaking o-rings.
What causes a Mercedes convertible top to leak?
The majority of Mercedes convertible problems are caused by a bad relay, weak lift cylinder or lift cylinder leaking by the o-ring. If you find out that the convertible top reservoir is low in fluid that means that you have a leak most likely at one of the convertible lift cylinders.
What’s the best way to close a Mercedes SLK top?
Then a person on each side of the roof can lift it up and push it forward until the roof contacts the windshield. A 5mm hex wrench (check the toolbag in the trunk panel for one) is used in the headliner screw to reel the latches into the windshield and lock the top in place.
What makes a Mercedes convertible top not go down?
Mercedes convertible top won’t go down or raise 1 Convertible top pump / motor defective 2 Bad convertible top relay 3 Low fluid 4 Defective divider microswitch 5 Transmission not in Park / Neutral 6 Switch at center console is faulty 7 Convertible top fluid leak Inspect in the trunk area for hydraulic fluid leak.
Can a convertible top be opened and closed?
Keep children away from the opening/closing path of the convertible top. For safety reasons, only operate the convertible top while the vehicle is standing. While opening and closing, the convertible top pivots upward.
Can a convertible top box cover be locked?
The convertible top box cover cannot be locked if there is an electrical defect and would then open while the vehicle is in motion. Incorrect handling can result in damage. Closing the convertible top manually should be performed by two people. The rear seats must not be occupied. 1. Open the trunk lid. 2.
HOW TO GET A LOCKED TRUNK OPEN Locate the 9/16 –inch bolts forward of the rear wheels up under the wheel well area. Remove the bolts, and, using a screwdriver wrapped in cloth to prevent marring the paint, pry up the deck lid at the left forward corner until it can be raised three or four inches.
What causes a convertible top to go bad?
Electrical mal- function causes most top operating failures, simply because there are more electrical components. The “flip-top” birds build from 1961 to 1966 go through eight operations: 1. Deck Lid Unlock: 2. Deck Lid Lock: 3.