How to fix your Honda Foreman 500 electric shift problems?

How to fix your Honda Foreman 500 Electric Shift Problems. Neutral was blinking 13 times, which means there is a problem with the throttle position sensor. Category Autos & Vehicles Show moreShow less Loading… Advertisement AutoplayWhen autoplay is enabled, a suggested video will automatically play next. Up next

How to fix Honda ATV electric shift issues?

Here’s your fix. Stop selling your Hondas cheap and take a few minutes to watch this & I’ll explain what you need to buy to fix the ES non shifting issues. TPS or Angle sensor or low battery voltage. End of story. Google how to replace these items. Good luck fellow riders. Loading…

Are there any issues with the Honda Foreman 500 es?

I know on the Foreman 450 ES model it was common for the angle sensor to go out and cause a similar issue to what you’re having. Not too familiar with the 500’s but this could be a possibility. Had a Rancher 350 that had the same issue.

Why is my Honda Foreman 500 blinking 13 times?

Neutral was blinking 13 times, which means there is a problem with the throttle position sensor. How to fix your Honda Foreman 500 Electric Shift Problems. Neutral was blinking 13 times, which means there is a problem with the throttle position sensor. Skip navigation Sign in Search Loading… Close This video is unavailable.

Is there a problem with Honda es shift?

Unfortunately, there has been one problem with ES shifting that has affected many ES owners at one time or another: The problem is that, at times, when you make a shift (up or down) on an ES machine, the shift is not complete.

Is the Honda foot shift electric or manual?

Many of us have Electric Shift (ES) models. In fact, Honda sells approximately EIGHT times as many ES models for every foot-shift model sold. The ES models are very reliable. But, because of the number of ES machines that are sold and owned, it sometimes seems that there are more difficulties with ES shifting than with manual shifting.

How big is the electric shift motor on a Honda ATV?

The ES Shift Motor is a 12 volt motor controlled by the ECU (computer). and that is the SAME SHAFT as the non-ES (manual shift) footpedal shifter. the shift drum, then a spring returns the shaft to center. are careful not to hold the shift buttons down more than 1 second. I estimate the shift motor is 0.25 HP = 180 Watts = 0.25 ft-lbs / 6000rpm.

How often does a Honda Foreman 500 es go into reverse?

9/10 times if a honda won’t go into reverse, that cable is not being pulled. I know, I know I kick myself everyday, but it is easier for wife and kids. I know, I know I kick myself everyday, but it is easier for wife and kids.

Can you put a Honda es into reverse?

Cannot put the Honda ES into reverse? Check to see if the reverse switch is functioning properly. If not working, replace the reverse switch on a Honda ES ATV by watching the following video. Loading…

What kind of motor does a Honda Foreman use?

DB Electrical 430-58001 New Power Shift Control Motor for Honda Trx450 Trx450es FourTrax Foreman Es 1998 1999 2000 2001 98 99 00 01, Trx450 Trx450fe 2002 2003 2004 02 03 04 31300-HN0-A11 31300-HN0-A12 Only 5 left in stock – order soon. Only 12 left in stock – order soon.

How to install a manual shift on a Honda Foreman?

Buy a bolt on shifter off of Ebay and just remove the shift reduction gear. Take the rear cover off and install the shift shaft from a manual shift and use an OEM shifter (still removing the reduction gear). Did you find the recommended reading relevant to this discussion?

How to install Honda TRX 500 Foreman OE shift?

Took about 15 minutes once located. Advice: Jack up front and install from the bottom…much easier than from the side. This was on a 2006 honda foreman 500 es. Correct fit!! OEM for TRX500ES Foreman Precise fit. Removed air filter housing for easy access.

Why is the electric shift not working on my Honda Foreman?

The Gear selector indicator flashes 5 times and that indicates a ECM motor driver circuit. The 4 wheel drive selector also has stoped working. I have put power direct to the electric shift motor but it appears dead. My next trick is to remove it and put power to it again. Assuming that it is faulty, I would prefer to fix it – brushes or whatever.

What kind of OEM does Honda TRX 500 have?

OEM for TRX500ES Foreman Precise fit. Removed air filter housing for easy access. Pages with related products. See and discover other items: honda 2013, honda foreman 500, 2008 trx 500, foreman parts, 2006 honda 500 products, Honda ATV Parts

Are there any issues with the Honda Foreman 450?

I had to roll to a stop.. get out the manual shift lever, put it in neutral, shut the bike off and start the bike again and it worked… on the way back home… I took it easy on the speed so the same issue wouldn’t occur…

Navigation