Do you need help troubleshooting the charging system on a Honda?
I need help troubleshooting the… I need help troubleshooting the charging system on a honda gx630 with the 17amp charging system…it only has 6hrs on the motor.
What to do if Honda Express battery blows?
Check the fuse in the little casing. If it is blown, replace it. once all this has been done, put the seat back on. The 1977 and 1979-1980 express used one type of battery. The 1978 used a different type. The 1981+ used a third larger type. Make sure to get the right one for your bike should you need a new one. Pull out the spark plug.
Why does my Honda ATV battery keep dying?
When the battery in your Honda ATV keeps dying, the problem may not be the battery itself, but rather the machine’s charging system. If playback doesn’t begin shortly, try restarting your device.
How can I tell if my Honda Express is corroded?
Pull the timing cover off (the round shiny metal cover on the right hand side of the motor with HONDA written on it). turn the flywheel until you can see the points (the two metal “Fingers” that open and close as the flywheel turns. Do they look corroded? rusty? Are the surfaces worn and uneven?
What to do if you have rust on your Honda?
Rust is a common occurrence on older model Hondas, so much so that Honda-Tech forum members have offered several helpful tips for repairing areas that have succumbed to the copper colored corrosion. Here are five tips to consider before tackling this repair yourself. 1. Clean the Area
I need help troubleshooting the… I need help troubleshooting the charging system on a honda gx630 with the 17amp charging system…it only has 6hrs on the motor.
Where is the Charger wire on a Honda?
The black/yellow wire shoudl have 12 volts when engine is running, this si to supply power to the fuel solenoid to keep the engine running. The White wire is to keep the battery charged. can you see the pic I attached. the black wire (ground from regulator), is landed under a long 5/16 head”x 3+” long bolt going to starter cover.
What are the resistance measures of a Honda Charger?
There is continuity, and resistance measures .01-.03 ohms. Neither of the gray wires coming from the motor have continuity to ground. Also checked the other side of the same wires, (the pigtail coming out of the regulator/rectifier.) There is continuity between the 2 gray wires, resistance measures 2.0-2.4 ohms.