Why is my Polaris RZR turbo overheating?
At first we thought that maybe the air hadn’t been properly bleed from the cooling system but as the months went by we had logged at least 60 calls from people all over the US. At that point we decided to address this issue and see if we could find a solution.
When did Polaris Ranger 1000 start overheating?
Putting around the pasture it usually goes to about 207 then starts back down until fan shuts off. Bought our 2018 Polaris Ranger 1000 last November, used it during hunting season in cold weather, ran fine.
What should I do if my Polaris Sportsman 570 overheats?
I was able to limp back to the truck. Took it to my Polaris Dealer and they checked it out and tried to recreate the overheat and were not able to. They said everything is fine and that if I am traveling at 25 mph or lower that I should be in low as this will be better for overheating.
How tall is the radiator on a Polaris RZR?
First thing we did was to build the engine radiator 4″ taller than the stock unit about 35-40% larger. We triple passed it, this means that in a cross flow design (this is) we place a baffle or plate 1/3 the way down the tank on the upper inlet side of the radiator.
What is the most likely cause of overheating in a Polaris RZR 800?
What is the most likely cause of overheating in a Polaris Rzr 800 is coolant is boiling over. Fan is no running. Very difficult to see or following the fans connection and wiring harness. Is there a fuse or relay that is bad which is located somewhere specific which we can check?
Why does my Polaris Ranger keep overheating?
If you pull over to stop, with engine running, it really heats up fast. It has blown out coolant several times. When it shuts off, it has to cool down before it will run again. Since it’s still under warranty, we will probably have to see if it’s anything the dealer can fix.
Are there any issues with the 2016 Polaris RZR Turbo?
In August of 2015… …shortly after the release of the 2016 Polaris RZR Turbo we began receiving calls about overheating problems with this side x side. At first we thought that maybe the air hadn’t been properly bleed from the cooling system but as the months went by we had logged at least 60 calls from people all over the US.
What can I do to keep my RZR Turbo from overheating?
All three of them also tell the stock fan to come on seven degrees sooner and not turn off unless the engine is below 188 degrees. Boondocker also does the ECU ref lash ($399), clutch mods including fans and cover as well as turbo kits for NA RZR’s.