Why is my Jaguar XK8 steering rack leaking?

Issue: The steering rack of some 1997 MY-ON XK8 vehicles may leak at one of the transfer pipe union nuts. The cause of the leak is damage to the O-ring seal beneath the union nut caused during installation. Before replacing the entire steering rack, the O-ring (Illustration 1) should be replaced and the system tested.

What kind of fluid does a Jaguar use?

I went to Taggarts Jaguar Motherwell Christmas Eve, and asked for power steering fluid, they sold me Mobil ATF 320 premium Automatic Transmission Fluid. According to their technican & parts department this is the proper fluid to use.

What kind of fluid do you use for power steering?

Mobil ATF 320 is recommended for most passenger car and commercial automatic transmissions. It is also suitable for power steering systems, hydraulic applications and some manual transmissions where an automatic transmission fluid is specified. The correct frictional requirements to give smooth transmission operation over wide operational bands

How to repair a Jaguar 4 wheel drive?

Align the pinion centering cap with the lug on the pinion housing (Illustration 2) to precisely center the rack. 5. Loosen and remove the lower column clamp bolt at the pinion coupling. 6. Disconnect the steering column from the pinion and then move the column upwards. 7. Disconnect the transducer multi-plug. 8.

Is there a hydraulic steering system for the Jaguar XK?

For many years hydraulic power steering racks were the only realistic option for the XK. This system works well; there are however three significant drawbacks.

Are there any modifications to the Jaguar XK120?

To that end we have developed a range of modifications and upgrades for the XK120, XK140 and XK150 to make them more useable and pleasurable to drive in the modern day.

How to repair a power steering rack leak?

Action: When diagnosing a customer complaint of power steering rack leakage on a 1997 MY-ON XK8, proceed as follows: REPLACING TRANSFER PIPE O-RINGS 1. Open the hood and install fender covers. 2. Raise the vehicle on a suitable hoist. 3. Center the steering wheel and remove the ignition key. TRANSFER PIPE O-RING O-RING TRANSFER PIPE JSI-3153

Why are the rubber boots on my steering rack leaking?

The other two points are inside the rubber boots at the ends of the rack. If any of these points have power steering fluid coming out, then the rack seals need to be renewed. Further clarification: There should be NO fluid inside the rubber boots. The rubber boots are not there to contain the fluid, they are there to keep dust and dirt out.

Why are my steering rack SEALs coming out?

If any of these points have power steering fluid coming out, then the rack seals need to be renewed. Further clarification: There should be NO fluid inside the rubber boots. The rubber boots are not there to contain the fluid, they are there to keep dust and dirt out. If your boots are cracked, your rack seals are being damaged.

What makes a Jaguar XK8 fall off the road?

The paint is known as being pretty ‘soft’ meaning chipping and damage is common. Check behind the bumpers where electrolytic corrosion can set in between the alloy mounts and steel bolts – especially at the rear causing the bumper to fall off. Floors rot through now so check the chassis thoroughly. Inspect the tyres.

When did the new Jaguar XK8 come out?

After the once unloved XJ-S enjoyed a bit of Indian summer for sales, the XK8 was launched at the Geneva motor show, following in the footsteps of the E-type 35 years previously. Cost constraints meant that the new car had to use an existing platform, which was a development of the old XJ-S platform, itself a direct descendent to the XJ6 of 1968!

Is the Jaguar XK8 a good car to drive?

Like all moderns, the XK8 is ultra user-friendly and daily driving is both possible and pleasurable – if you can afford the petrol that is.

What to do about power steering fluid leaks?

Watch the video above to see how to fix minor power steering fluid leaks in your 2005 Jaguar X-Type. The power steering fluid helps make your X-Type easier to turn, especially at lower speeds.

Where is the leak on the steering rack?

There are three main leakage points on the steering rack (not including the hoses.) The first point is at the top of the rack tower, where the steering column connects to the rack. The other two points are inside the rubber boots at the ends of the rack.

Navigation