Where is the fuel pump on a King Quad 300?
there is a fuel pump under the front left hand side on the front guard. it is driven by the vacum from the motor. most likely it is not broken! they have a good reputation.
Is there a problem with a vacuum fuel pump?
Another problem I have seen with vacuum powered fuel pumps is the wrong kind of hose is being used. Regular soft rubber fuel hoses can reduce the signal strength, a the proper hose is a flexible but somewhat stiff hose that will not collapse or expand under vacuum or pressure.
How does the fuel pump work when the car is not running?
Starting from the basics, take off the fuel cap and listen closely for the fuel pump to come on as a helper turns on the ignition key. The pump runs for only 2 seconds at a time when the engine is not running. The computer shuts the power off to the pump if it does not see a signal from the crankshaft sensor.
How to get fuel to a Suzuki King Quad 300?
with the 250 and 300 LTF kingquads made by suzuki, when ever you cannot get fuel to the carbi, just put the fuel tap on to prime, then blow in to the fuel cap vent hose (the one sticking out of the fuel cap) once you clean the dirt off it, blow with your mouth for about 10 seconds with the same sort of pressure you would blow up a baloon.
Where is the vacuum line on a Suzuki quad fuel pump?
The third one on the back of the pump is the vacuum line that activates the pump. That line also goes to the carburetor. It’s on the opposite side of the fuel connection on the carburetor. What happens is when you crank the engine the vacuum created in the carburetor moves the diaphragm in the pump.
How does the fuel shut off system work on a Suzuki quad?
But- it does have a vacuum powered shut off system on the fuel valve. This shut off valve will activate (allow fuel to flow) when the engine pulls a vacuum load on the valve, and then allows fuel to flow from the tank. This is an automatic fuel shut off system.
How to start a Suzuki 95 King Quad?
Lift the seat and disconnect the fuel line from the pump to the carb,try to start the machine,if the fuel exits the fuel line in a steady stream the pump is good. (use a container to except the fuel from the hose.. dont want a fire).If the fuel flow is a dribble replace with a new pump
Where does the fuel line go on a Suzuki King Quad?
That’s the one that goes to the carburetor fuel inlet. The third one on the back of the pump is the vacuum line that activates the pump. That line also goes to the carburetor. It’s on the opposite side of the fuel connection on the carburetor.