What kind of oil does a Volvo 850 use?
F (-20 C) Volvo oil (P/N1161001-1) (2) – DO NOT use Dexron fluid in manual transmissions. (3) – Use low pressure grease gun to prevent seal damage. (4) – Fill until lubricant squeezes out from the base of seals. (5) – Fill ball joint until seal starts to swell. FLUID CAPACITIES FLUID CAPACITIES TABLE
How to check the transmission fluid in a Volvo?
Here are instructions on how to check Volvo transmission fluid level. Drive the car for at least 15 minutes. Manually shift the gears between 1, 2, 3, 4, 5 during your warm-up drive. Park the car on a level surface. Set the parking brakes and place the shifter in Park.
What should I do if I have a transmission problem in my Volvo?
Doing transmission service will often improve the shifting quality. Make sure to use the recommended Volvo transmission fluid . In most cases correcting the transmission fluid level, changing fluid and filter, updating the transmission software, and replacing the valve body will fix it.
What kind of maintenance does a Volvo 850 need?
1993-96 MAINTENANCE Volvo Maintenance Information 1993-96 850 Sedan 1994-96 850 Turbo Sedan 1995-96 850 T-5R Turbo Sedan 1994-96 850 Wagon 1994-96 850 Sportswagon 1995-96 850 T-5R Turbo Sportswagon * PLEASE READ THIS FIRST *
How to change the transmission on a Volvo 850?
1) Remove drain plug and drain transmission. Disconnect filler tube and remove oil pan. 2) Remove and clean oil strainer. Install strainer. Tighten strainer bolts to 18-25 INCH lbs. (2-3 N.m). Install oil pan with new gasket. Tighten bolts to 42 INCH lbs. (5 N.m). Tighten filler tube to 65 ft. lbs. (88 N.m).
How to check fluid level in Volvo 850?
Move gear selector lever through all gears, while pausing 4-5 seconds for engagement at each position. 2) Return gear selector lever to “P” position. Wait 2 minutes and check fluid level with engine idling. Level should be between MIN and MAX marks. 850 (AW50-42) ………………….. Dexron IIE Or Mercon 940 (AW-70) ………………………… Type “F” Or “G”
When to replace camshaft belt on Volvo 850?
Although some manufacturers do not recommend belt replacement at a specified mileage, others require it at 60,000-100,000 miles. A camshaft drive belt failure may cause extensive damage to internal engine components on most engines, although some designs do not allow piston-to-valve contact. These designs are often called “Free Wheeling”.
What kind of car was the 1996 Volvo 850 GLT?
This 1996 Volvo 850 GLT represents a watershed moment in Volvo’s history. While not the company’s first FWD car — an honor that would go to the eminently funky 480 series — it was Volvo’s first mid size model to feature this layout and would presage the marque’s move entirely to FWD and FWD-biased AWD.
Why does my Volvo PCV breather box stop working?
This is due to clogged oil suction strainer to the oil pump or oil filter. Illuminated check engine lamp. This is due to incorrect engine fuel trim level parameters. Noise (whistling). Noise due to high pressure in the crankcase. This noise will stop if the oil filler cap is removed. Poor drivability.
What makes up a transaxle on a Volvo 850?
Transaxle consists of lock-up torque converter, oil pump, 3 planetary gear sets, clutch and brake units, accumulator pistons, valve body and 4 electronic valve body solenoids. Valve body with solenoids and Transaxle Control Module (TCM) are used for controlling transaxle operation.
How often should you change the transmission fluid in a Volvo?
Even if your Volvo owner’s manual states that the transmission fluid is sealed for life, our recommendation is to change the transmission fluid and filter every 60,000 miles. Volvos may develop hard shifting or slippage due to the Transmission Control Unit (TCU) software issues.
How to identify a 1995 Volvo 850 transaxle?
For 1995 850, see the AIR BAG RESTRAINT SYSTEM article in the ACCESSORIES/SAFETY EQUIP section. Transaxle can be identified by identification plate attached to top of transaxle case. See Fig. 1.