How much does it cost to replace AC compressor in Honda Civic?

The average cost for a Honda Civic AC compressor replacement is between $753 and $1,144. Labor costs are estimated between $285 and $361 while parts are priced between $468 and $783. Estimate does not include taxes and fees.

Where is the compressor located on a Honda Civic?

Remove four 10 mm bolts from side of the compressor. The A/C drier keeps moisture from building up inside the system. When the compressor is disconnected, air manages to escape, and moisture can make its way into the system. The drier is located right below the windshield washer reservoir.

How to replace AC condenser 2001-05 Honda Civic?

If playback doesn’t begin shortly, try restarting your device. An error occurred. Please try again later. (Playback ID: TQHbbfYVYvfHHUoH)

What happens when the a / C unit fails on a Honda Civic?

When A/C compressor units fail, the refrigerant is no longer able to stay pressurized and can no longer produce cold air. A/C repair costs are usually in the thousand dollar range, because in most cases, the job is labor intensive. However, Honda Civic owners have it easy when it comes to replacing the A/C compressors themselves.

How to install new a / C compressor in Honda Civic?

Loosen the bracket and pull the drier down. With the four 12mm bolts, secure the new compressor to the mounting bracket. Re-install the compressor belt and tighten the 14mm adjusting bolt to a snug fit. With a torque wrench, tighten the idler pulley center nut to 33 ft lbs (refer to Figure 2).

If playback doesn’t begin shortly, try restarting your device. An error occurred. Please try again later. (Playback ID: TQHbbfYVYvfHHUoH)

Where is the a / C drier on a Honda Civic?

The A/C drier keeps moisture from building up inside the system. When the compressor is disconnected, air manages to escape, and moisture can make its way into the system. The drier is located right below the windshield washer reservoir. With your 10mm socket and ratchet, remove the two bolts on top of the drier.

Honda Civic Car AC Compressor Replacement costs $1376 on average. Following is a breakdown of the labor and parts estimates. What is the AC Compressor all about? An AC system has many components: compressor, condenser, receiver dryer, evaporator, and hoses.

What to do if your Honda Civic Air Conditioner breaks?

You don’t normally give the inner workings of your Honda Civic a second thought until something goes wrong, especially when it affects the interior temperature. But visiting the auto mechanic after your air conditioner breaks can be a costly trip if you weren’t planning on such an expense.

What kind of Freon does a Honda Civic use?

Depending on the year of your Civic, the A/C may use R12 freon. Don’t attempt to adjust the level of this freon yourself, as it requires special tools that prevent the freon from being released into the atmosphere. It’s illegal to purchase R12 freon without a license and doing so carries a hefty fine.

What should I do if my Honda Civic is running hot?

Inspect the engine. A Civic’s engine lies alongside the A/C setup under the hood, so if you can’t find anything wrong with the freon levels or the compressor, you may need to consider a different source. If you discover that the engine is running hot, its proximity to the A/C will negatively affect the system’s cooling capacity.

How to add Freon to a 2012 Honda Civic?

How to add freon to your 2012 Honda Civic: hook up the can of refrigerant (likely r-134a) to the low pressure port. When your compressor kicks on, add freon to the correct pressure. In addition to cooling, freon lubricates the compressor when it runs. Advance Auto coupon for 20% off entire order: KIOSK20

What kind of refrigerant does a Honda Civic use?

Recharging the freon in your AC system is an inexpensive and easy first step to restoring the cooling capacity of your A/C system. Most refrigerants include a leak sealer that will seal small leaks in addition to filling the R134a refrigerant. The A/C system in your Civic consists of a compressor that is belt-driven, an evaporator and freon.

What to do about a clogged expansion valve on a Honda Civic?

Replace the expansion valve. Discharge temperature is low, and the airﬂ ow from vents is restricted. Frozen evaporator Run the fan with A/C compressor off, then check evaporator temperature sensor. Expansion valve is frosted. Clogged expansion valve Clean or replace.

What do you need to know about Honda Civic a / C?

2006-2011 Honda Civic A/C Diagnosis and Repair EXPANSION VALVE (Meters the required amount of refrigerant into the evaporator) RECEIVER/DRYER DESICCANT (Traps debris, and removes moisture) A/C COMPRESSOR (Suction and compression) A/C CONDENSER (Radiation of heat) A/C PRESSURE SENSOR

How much does it cost to replace an expansion valve?

At this point, you will need to replace your A/C expansion valve to fix the problem. The replacement cost of an A/C expansion valve is anywhere from $200 to $450. The parts cost itself will be between $100 and $200 while the labor costs will be between $100 and $300.

How much does it cost to replace a condenser on a Honda Civic?

The average cost for a Honda Civic AC condenser replacement is between $376 and $418. Labor costs are estimated between $163 and $205 while parts are priced at $213. This range does not include taxes and fees, and does not factor in your specific model year or unique location.

Where is the a / C expansion valve located in a car?

The A/C expansion valve is found within the air conditioning system of a vehicle. The purpose of the valve is to manage how much refrigerant liquid can flow throughout this system.

What happens when your a / C expansion valve goes bad?

You will notice when the A/C expansion valve goes bad because your air conditioning system will ultimately stop functioning properly. It will either produce less cool air or it won’t produce any cool air at all. At this point, you will need to replace your A/C expansion valve to fix the problem.

What causes a Honda Civic AC compressor to fail?

The AC compressor clutch is one of the most common points of failure on the compressor. The clutch is dependent on precise spacing between the clutch plate and pulley, a smooth bearing inside the pulley, and proper functioning of the electromagnetic coil to engage properly.

Is the AC on my Honda Civic 2007 working?

Here’s my investigation after reading about Civic 2007 electrical circuits, AC, sensors and so forth: All fuses are OK and working. I tested every single one in the AC circuits. The relay that kicks in the compressor/clutch is fine. I tested it outside the car, using power-supply and multimeter.

What’s the warranty on a Honda Civic AC?

As a result of the lawsuit, Honda extended its AC warranty to Ten (10) years and unlimited miles. “American Honda is extending the warranty on the A/C condenser to 10 years from the original date of purchase with unlimited miles. This warranty only covers vehicles that have a defective A/C condenser from the factory.

What should I do if my Honda Civic AC is not working?

3. If the system is not cold enough, feel the large line under the hood for the A/C. If it is warm feel the small line and be careful, if the compressor is working the small line should be hot. If not, the compressor is going bad. If the large line is cool but not cold and the small line is hot the system just needs a recharge. 4.

Where is the condenser on a Honda Civic?

From inside the engine bay, locate the pressurized charge line and condenser hoses connected to the top of the compressor. With a 10mm socket and ratchet, remove the hose connectors along with the hoses. Disconnect the electrical connector on top of the compressor.

Is it safe to replace an AC compressor?

The compressor’s clutch also may not engage and will just stay cycled off all the time. While this may seem like a death sentence—especially in the height of summer—replacing AC compressors isn’t the most complicated task. We break it down for you here. Remember to wear safety glasses and latex gloves before you get started!

How do you remove an AC compressor from a car?

Remove the negative battery cable from its post. Remove the bolt at the compressor that secures the refrigerant lines and inspect the lines carefully for dirt or signs of wear. Disconnect the compressor’s electrical connections. Remove the compressor’s mounting bolts and pull the unit from the vehicle.

What causes an AC compressor to stop working?

The AC compressor has several moving parts (including pistons and valves). These internal parts can fail, causing the AC compressor to stop working. It is common for the internal parts of the compressor to come apart and disperse metallic debris throughout the system.

Is it normal for Honda Civic a / C compressor to leak?

I had taken it to the dealership last week and they said my A/C Compressor had a leak, it’s a common issue with this make and model year and that repairs would be covered under warranty- however my service rep told me that the parts for this fix aren’t available and there’s no ETA as to when they will be able to get them. Is this normal?

What should I do if my AC compressor is faulty?

Check for power and ground at the compressor. If compressor is found to be faulty, remove all of the refrigerant. Remove the compressor, receiver drier, orifice tube, and/or expansion valve. Flush all foreign materials from the AC System. Install new compressor, receiver drier, and orifice tube. Evacuate and recharge the AC system.

Do you need an AC compressor for a Honda Civic?

A class-leading compact automobile, your Honda Civic has shown time and time again why it’s counted on for dependability, superior fuel economy and top-notch features. Protect the functionality of your air conditioning system by upgrading your Honda Civic AC compressor with AutoZone.

What to do if your Honda AC is not working?

Ac not working in your Honda well this video will guide you on most Honda’s , from changing the compressor, condenser and charging, how to tell if your compressor is working, and checking your ac fan.

When to replace AC compressor in Dodge Ram 1500?

The clutch is driven by a drive/serpentine belt, which engages the compressor when you switch on the AC. The clutch can burn or the bearing can fail. If the bearing or clutch have failed, it is recommended that the compressor be replaced.

When to replace the a / C compressor in a Honda Civic?

When an A/C compressor dies, the refrigerant is no longer cycled through the system. This article demonstrates how to properly replace the A/C compressor in your Honda Civic. This article applies to the Honda Civic (1992-2000).

How much does it cost to replace a Honda AC compressor?

Know what price you should pay to get your vehicle fixed. The average cost for a Honda Civic AC compressor replacement is between $634 and $994. Labor costs are estimated between $166 and $211 while parts are priced between $468 and $783.

How much does it cost to repair a Honda Civic?

Honda Civic Car AC Repair at your home or office. Honda Civic Car AC Repair costs $222 on average. Following is a breakdown of the labor and parts estimates. For an AC system to work, it needs a gas or liquid substance called refrigerant (R-12 in older cars, R-134a in 1995 and newer cars).

How can I Fix my Honda Civic air conditioner?

Determine if the air conditioning system charge is low. Add the correct refrigerant to top off the air conditioning system. Install thermometer in vents to monitor vent temperatures. Check system for leaks. Check for proper operation of AC system. It is common for refrigerant to leak.

received a AC Condenser Replacement. Honda Civic AC Condenser Replacement costs $543 on average. What is the AC Condenser all about? The AC system has many key components: compressor, condenser, receiver dryer, evaporator, and hoses.

Navigation