How to troubleshoot a Mercedes Benz convertible problem?
You can also bridge the top relay for a couple of seconds to see if the hydraulic pump start to run. Replace the convertible top relay if necessary, PN 0025421319. Next, check the micro switch where the divider locks. You know that trunk separator that you are supposed to pull out and engage it in this hook?
What to do if your convertible top malfunctions?
Have the codes read. Takes a scanner. These have like 20 sensors and switches for the top and trunk. You can try to close the latch on the trunk with a screwdriver to get it to work. Another thing is there is a cover that pulls out . This has to be pulled out and latched in place. This will keep it from working also.
Why does my convertible top not open without a key?
The trunk won’t open without a key…unless the windows get stuck halfway up. Then the trunk works with a key, but then the windows don’t. I had a wire harness fixed under warranty in the trunk the last time this happened, but this time the harness looks OK.
Why does my Chrysler 200 convertible top not work?
The windows wont close all the way, trunk wont open, rear defrost doesn’t work, and so on. Top is fully secured in the up and down position and I have no error on the dash. However I do get a “ding” from the dash but again no error to be found. Been very frustrated by this can anyone help???
Have the codes read. Takes a scanner. These have like 20 sensors and switches for the top and trunk. You can try to close the latch on the trunk with a screwdriver to get it to work. Another thing is there is a cover that pulls out . This has to be pulled out and latched in place. This will keep it from working also.
The trunk won’t open without a key…unless the windows get stuck halfway up. Then the trunk works with a key, but then the windows don’t. I had a wire harness fixed under warranty in the trunk the last time this happened, but this time the harness looks OK.
The windows wont close all the way, trunk wont open, rear defrost doesn’t work, and so on. Top is fully secured in the up and down position and I have no error on the dash. However I do get a “ding” from the dash but again no error to be found. Been very frustrated by this can anyone help???
Can a convertible top be raised or lowered?
Unbelievable there is no contingent plan for the raising & lowering of a convertible top and they stop making switch that obviously may be in greater need later than sooner in this vehicle’s lifetime. Idea: if parts are on the “endangered” list, please let people know…Had I known, I would’ve purchased one on spec, just in case.
What to do if your Mercedes convertible top is blown?
If it is blown, replace it with a new fuse with the same ampere rating. Check the convertible top relay as well. Swap it with a known working relay that is identical. You can also bridge the top relay for a couple of seconds to see if the hydraulic pump start to run. Replace the convertible top relay if necessary, PN 0025421319.
How to fix a leak in a Mercedes convertible?
Leak at the o-ring at any of the lift cylinders. Inspect in the trunk area for hydraulic fluid leak. Low fluid in the convertible top reservoir. Start by pressing the convertible switch. Do the windows go down? If the windows don’t go down, make sure the trunk compartment divider is pulled out. Next, check the fuse for the convertible top.
Where is the convertible top motor in a Mercedes?
Locate the convertible top motor in the trunk. In most Mercedes-Benz cars including SL, SLK, CLK class, it is located in the trunk left or right side. You will need to remove the trunk lining to see the reservoir. Remove the 12mm bolt from the reservoir. Use a clean syringe to add fluid to the reservoir.
What are the most common convertible top problems?
Let us go over the list of most common convertible top problems: 1 Low Hydraulic Fluid Level 2 Failed convertible top pump/motor 3 Broken or bend top armor cable 4 The low fluid level in the top pump reservoir 5 Poor Ground Connection 6 Air in the System 7 Weak Cylinders 8 Defective micro-switches More
Why does my Mercedes convertible not go up or down?
Mercedes Convertible Top Won’t go up or down. Convertible top moves very slow. This can be caused by low fluid level or air in the hydraulic lines. Air in the hydrauilc lift cylinders. It can be caused by binding of mechanical arms. Weak convertible top lift cylinder. Weak battery or ground connection.
Is there a problem with the Boxster convertible top?
The Boxster convertible top mechanism is used a lot, and is often exposed to a lot of stress and strain as a result. It’s very likely that you will experience a problem with the opening or closing of your top somewhere along the line: knowing what to replace and fix is valuable information.
What causes a Mercedes convertible top to leak?
The majority of Mercedes convertible problems are caused by a bad relay, weak lift cylinder or lift cylinder leaking by the o-ring. If you find out that the convertible top reservoir is low in fluid that means that you have a leak most likely at one of the convertible lift cylinders.
What is the harmonic balancer on a Mercedes Benz?
This is a common problem on Mercedes-Benz models ending with 240, 320, 430 and 500. What is a Harmonic Balancer? A harmonic balancer (also called vibration damper or crank pulley) is the main pulley that drives the accessory belts on a Mercedes-Benz engine. It is connected directly to the crankshaft. The harmonic balancer has two metal components.
You can also bridge the top relay for a couple of seconds to see if the hydraulic pump start to run. Replace the convertible top relay if necessary, PN 0025421319. Next, check the micro switch where the divider locks. You know that trunk separator that you are supposed to pull out and engage it in this hook?
What do you use to keep a Mercedes crankshaft from turning?
You will use the harmonic balancer tool to keep the crankshaft from turning. Next, use a 27 mm socket on the bolt to loosen it up. You will need to use a breaker bar such as Neiko 00206A 1/2 Inch Drive Premium Breaker Bar, 24″ Length | Cr-V Steel to get this bolt loose.
Leak at the o-ring at any of the lift cylinders. Inspect in the trunk area for hydraulic fluid leak. Low fluid in the convertible top reservoir. Start by pressing the convertible switch. Do the windows go down? If the windows don’t go down, make sure the trunk compartment divider is pulled out. Next, check the fuse for the convertible top.
The majority of Mercedes convertible problems are caused by a bad relay, weak lift cylinder or lift cylinder leaking by the o-ring. If you find out that the convertible top reservoir is low in fluid that means that you have a leak most likely at one of the convertible lift cylinders.
What causes a Mercedes convertible top to move slow?
Mercedes Convertible top moves very slow 1 This can be caused by low fluid level or air in the hydraulic lines. 2 Air in the hydrauilc lift cylinders 3 It can be caused by binding of mechanical arms. 4 Weak convertible top lift cylinder. 5 Weak battery or ground connection. 6 Leak at the o-ring at any of the lift cylinders. …
Why is my convertible top not working properly?
Check cylinders for fluid leaks. Another common reason why convertible tops fail to operate is due to leaks at convertible lift cylinders. The hydraulic cylinders move the hardtop or soft-top up and down. They have seals and o-rings that shrink and crack due to age.
Mercedes Convertible top moves very slow 1 This can be caused by low fluid level or air in the hydraulic lines. 2 Air in the hydrauilc lift cylinders 3 It can be caused by binding of mechanical arms. 4 Weak convertible top lift cylinder. 5 Weak battery or ground connection. 6 Leak at the o-ring at any of the lift cylinders.
Let us go over the list of most common convertible top problems: 1 Low Hydraulic Fluid Level 2 Failed convertible top pump/motor 3 Broken or bend top armor cable 4 The low fluid level in the top pump reservoir 5 Poor Ground Connection 6 Air in the System 7 Weak Cylinders 8 Defective micro-switches More …
If it is blown, replace it with a new fuse with the same ampere rating. Check the convertible top relay as well. Swap it with a known working relay that is identical. You can also bridge the top relay for a couple of seconds to see if the hydraulic pump start to run. Replace the convertible top relay if necessary, PN 0025421319.
What happens if you break down a Mercedes Benz?
A simple phone call summons help if you need a jump-start, tire change, or if you run out of fuel. If you’ve broken down more than 100 miles from home, there’s no need to worry. Mercedes-Benz will reimburse your travel expenses, up to $300 per day for three days.
How often does a Mercedes Benz need repair?
The other factors that contribute to Mercedes-Benz reliability include an average of 0.7 visits to a repair shop per year and a 13% probability of a repair being severe. There are 11,730 related questions for Mercedes-Benz vehicles. RepairPal’s professional community answers hundreds of questions each day.
When did Mercedes Benz start using traction control?
Traction control system (TCS), also known as Acceleration Slip Regulation (ASR) to prevent wheelspin (a Mercedes-Benz first). Available only on European models from 1989 until the model year 1991, when it was introduced on 560 SEL and SEC models in the United States for that last production year only.
Are there any problems with the Mercedes CLK320?
Tap the to learn more about the most common Mercedes-Benz CLK320 problems. The engine may stall when the engine is warmed up. The AC compressor may seize resulting in loss of cold air from the AC vents. Bulletin 13N02 – This program extends the coverage of the brake booster to ten years…
Why does my Mercedes Benz make a clicking noise?
It requires electrical power to crank the engine. The car makes a clicking noise but won’t start. Hint: Starter Problem or Low Battery This may seem obvious, but an old battery is the root of many headaches and can cause all sorts of malfunctions on Mercedes-Benz cars.
What are the problems with a Mercedes Benz?
Top 5 Mercedes-Benz no start problems 1 Engine Click, No Start 2 Engine Dies Right After It Starts 3 Car turns over, but it won’t start 4 The car makes a clicking noise but won’t start. Hint: Starter Problem or Low Battery 5 Key will not turn the ignition More
Why is the battery on my Mercedes Benz not working?
Hint: Starter Problem or Low Battery This may seem obvious, but an old battery is the root of many headaches and can cause all sorts of malfunctions on Mercedes-Benz cars. How old is the battery on your Mercedes-Benz?