Can a worn wiper linkage cause a failure?
Worn wiper motor linkage bushings can also cause failures. Replacement of windshield wiper motor linkage and windshield wiper motor transmission components is not difficult on most applications where access to the wiper motor linkage and wiper motor transmission parts is not limited.
How does the transmission work on a wiper?
Wiper motor transmission parts and wiper motor linkage components link the wiper motor and wiper blades. If the wiper motor transmission or wiper motor linkage components are bent or otherwise damaged, the wipers may not function.
What does the odometer say on a 1997 passport?
1997 Passport, 164250 on odometer…driving at 65 w/ cruise ON, when cruise cuts off, speedometer begins to bounce between 65 and 0 mph, and the odometer is only registering a fraction of the actual mileage. Anyone know whether this is a mechanical or electrical type pblm or a solution to pblm.
What is the problem with my 97 Passport?
My ’97 Passport appears to have some weird electrical problem. At random times, the battery indicator will start to move in sync with the turn signal or show a drop with any other pull on the battery (lights, radio, etc.).
How do you replace the linkage on a windshield wiper?
Generally, the linkage can be gently pried off the mounts on the motor using a flathead screwdriver or small pry bar. Step 12: Connect the new linkage to the motor. Push the linkage onto the motor. Typically, this can be done by hand, but you can carefully use pliers if needed. Step 13: Mount the linkage assembly.
What causes a windshield wiper to stop working?
Automotive windshield wipers are an important safety component and should be kept in top working order. Common causes of wiper failure include bent or worn out wiper motor transmission and wiper motor linkage components. Wiper motor transmission parts and wiper motor linkage components link the wiper motor and wiper blades.
How to repair a Nissan Dorman windshield wiper linkage?
*I used two metal wrench sockets on each side and a vice to press the plastic into place. *Stop by your Nissan dealer and get 5 or so of the push connectors that hold tha plastic down over the motor and linkage assembly. You will probably break a few on disassembly. Good luck!
What kind of bushing for windshield wiper linkage?
Tried some mods that all failed, but ultimately bought the generic 49447 kit and used the larger bushings. These are a bit of a challenge to install (i used a flathead screwdriver), but do grip the ball joint better than the original bushings. Perhaps some wear on the ball joints?
Can you use Dorman linkage bushing on windshield?
They will work but fit loosely and the linkage arm will pop off and get bent, which will mess with the wiper sweep alignment. Use 49447, there’s a set of four in the pack that will work, they will be tough to get in, soak them in boiling water for a minute then insert them.
Why did my GMC Terrain wiper bushing pop off?
2010 GMC Terrain wiper linkage main arm to motor actuator popped off. Ordered these to replace ‘worn out’ bushings. Identical to original linkage bushings, but were ultimately not the fix. Arm popped off again almost immediately after using wipers.