How to test the Honda Civic radiator fan relay?

START HERE: The Radiator Fan Motor Relay Tests. TEST 1: Checking The Radiator Fan Relay Power Circuits. TEST 2: Bypassing The Radiator Fan Relay. TEST 3: Bypassing The Radiator Fan Switch. TEST 4: Bench Testing The Radiator Fan Relay. Where To Buy The Radiator Fan Relay And Save. More Honda Civic Test Tutorials.

How to troubleshoot a Honda Civic temperature gauge?

A malfunction on the gauge is simple to troubleshoot. With this guide, you will be able to locate the fault and make the necessary repairs in a matter of minutes. Turn the ignition switch to the On position but do not start the engine.

What happens when a Honda Civic overheats?

Your temperature gauge will max out (as you’re driving around). Your Honda Civic will not re-start (once it has overheated). Coolant (or water) boiling in the radiator’s overflow tank as the engine runs or when you turn off the engine. Coolant boiling in the radiator’s overflow tank and the radiator fan motor does not activate.

How does the coolant temp sensor work on a Honda?

3. Disconnected the 2-pin wire harness for the ECT sensor and measured the resistance between both pins while the engine is cold. Measured the ambient temperature in my location and matched the resistance against this temperature through the chart along the specification path (specs).

Why does my Honda Civic not re-start?

Your Honda Civic will not re-start (once it has overheated). Coolant (or water) boiling in the radiator’s overflow tank as the engine runs or when you turn off the engine. Coolant boiling in the radiator’s overflow tank and the radiator fan motor does not activate. Your Civic’s radiator fan motor relay is located in the under-hood fuse box.

Where is the fuse box on a Honda Civic?

The under-hood fuse box is located towards the rear of the engine compartment. If you remove the radiator fan motor relay, you’ll notice that its socket (in the under-hood fuse box) has four female terminals.

Where is the clutch relay on a Honda?

Open the hood of the Honda vehicle. Locate the AC clutch relay. Trace the wire that runs off the AC compressor; this wire plugs into the clutch relay. The relay is mounted on the firewall.

Where is the AC relay on a Honda Accord?

Turn the Honda engine on. Turn the AC settings to “Off.” Open the hood of the Honda vehicle. Locate the AC clutch relay. Trace the wire that runs off the AC compressor; this wire plugs into the clutch relay. The relay is mounted on the firewall.

How to know if the AC clutch relay is bad?

Locate the AC clutch relay. Trace the wire that runs off the AC compressor; this wire plugs into the clutch relay. The relay is mounted on the firewall. You will notice a three-wire connection on the relay. Connect the test light clip to the negative battery terminal. Touch the test light lead to the middle of the three wires.

Why is my Honda Civic a / C not working?

Clogged condenser or radiator ﬁ ns A/C condenser or radiator fan not work- ing properly Clean. Check voltage and fan rpm. Check fan direction. Line to A/C condenser is excessively hot. Restricted ﬂ ow of refrigerant in system Restricted lines. Discharge pressure abnormally low Excessive bubbles in sight glass; A/C condenser is not hot.

Why is my Honda Civic not cooling properly?

In cases like that the coolant is no longer cooled mostly by airflow through the radiator. When you stop the temperature spikes and the thermostatically controlled electric cooling fan starts…and runs until temps. are brought below the lower limit of the sensor that controls on/off of that fan.

What to do if your Honda Civic overheats?

Since the car is overheating and you have essentially changed out everything in the cooling system that is what I would suspect.

Why is water boiling out of radiator in Honda Civic?

When it is sitting idle and the temperature is in normal operating range, the water is contsantly boiling out. We have bled the system as directed but no luck. When you step on the gas peddle the water will shoot out of the radiator with the cap off. The top hose is hot, the bottom is cool but does not feel like there is any pressure.

Why is the radiator not working on my Honda Civic?

Just because the radiator fan is not on does not mean that it is not working. They are designed to only run when needed. If your Civic is running hot, and the fan is not running we’ve laid out the most common causes of this issue below. There are a few simple reasons that the fan would not be cycling on.

Why does my Honda Civic fan not run?

With the jumper attached, the fan should run continuously when the ignition is in the “ON” position. If the fan does not run, this is an indication that the thermo switch is faulty. If this is the case, you will need to replace the thermo switch. Figure 2. Location of thermo switch in a Honda Civic’s thermostat housing.

What happens when the radiator fan relay fails?

Since the radiator fan motor relay is one of the main components that gets your Honda Civic’s radiator fan motor to run.. when it fails the most obvious symptoms that your Honda Civic will experience is overheating. Your temperature gauge will max out (as you’re driving around). Your Honda Civic will not re-start (once it has overheated).

Where is the battery on a Honda Civic radiator?

Fuse #4, of the under-hood fuse box, is a 20 amp fuse. Circuit labeled with the number 3 . Provides battery power for the radiator fan relay’s coil. This female terminal gets power from the #14 fuse of the under-dash fuse box (inside your Honda Civic). Battery power is only available (at this terminal) with the key in the On position (position II).

Navigation