How to remove and replace an inner CV joint?

How to remove and replace an inner CV joint?

How to remove and replace an inner CV joint. VW Passat shown but German cars disassembly similar – YouTube

What kind of CV joint does front wheel drive car have?

Typical CV axle (shaft) of a front wheel drive car with a Rzeppa outer CV joint and closed tripod-style inner joint. The inner CV joint can work under small angle too. The design of outer CV-joint allows it to transfer the rotation motion at greater angles.

How can you tell if a CV joint is damaged?

The easiest way to spot damaged boots on CV joints is to look for grease splatter on the inside of your wheels. Once the CV joint boot is cracked or damaged, grease will begin to leak. CV joint grease isn’t the same as bearing or chassis grease. The grease is usually a green to blackish colour and so is easy to spot.

What causes a CV joint in a boot to break?

The most common problem with the CV joints is when the protective boot cracks or gets damaged. Once this happens, the grease comes out and moisture and dirt get in, causing the CV joint to wear faster and eventually fail due to lack of lubrication and corrosion. Usually outer CV-joint boots break first,…

What’s the best way to replace a CV joint?

To replace outer CV joints, follow these steps: Ensure that the handbrake is up to prevent the car from moving while the CV joints are being replaced. Remove the center cap of the wheel and remove the driveshaft retaining nut and washer. Loosen the nuts that secure the front wheels.

When do you know your inner CV joint is bad?

If you hear a similar sounding but far softer clunk as you did when accelerating, you almost certainly have a bad inner CV joint. Listen carefully for a grumbling vibration, which could indicate damage or severe wear on the inner CV joint.

What kind of joints does a CV axle have?

A CV axle or shaft has two constant-velocity or CV joints: inner and outer. A typical inner CV joint has three rollers on a tripod (spider) that can slide inside the CV joint housing, so the CV axle can extend or contract as needed. Typical CV axle (shaft) of a front wheel drive car with a Rzeppa outer CV joint and closed tripod-style inner joint.

How much play does an inner CV joint have?

Almost all CV joints have a little bit of play, but any more than 1/8-inch in any direction indicates a damaged or worn-out inner CV joint. 00:00 00:00 An unknown error has occurred Brought to you by Leaf Group