Are there any problems with the Detroit Series 60?
This issue did not affect all pre-2002 Series 60 engines, but it was a problem that occurred and could cause catastrophic engine failure. As with most engines, it’s a good idea to keep an eye on your cooling system. Overheating is the cause of many major issues with diesel engines, so maintaining this system can help with many preventable issues.
What to do if a Detroit Diesel cylinder misfire?
To determine if a faulty electronic control module (ECM) is causing the cylinder to misfire, perform the following: Note: Carefully disengage the lock tab… To determine if a faulty fuel injector is causing the cylinder to misfire, perform the following steps: Install DDL adaptor to the data cable…
What causes a series 60 engine to misfire?
Loss of compression in Series 60 engines may result from a variety of sources, including worn or broken fire or compression rings, holes in pistons,… To determine if a faulty electronic control module (ECM) is causing the cylinder to misfire, perform the following: Note: Carefully disengage the lock tab…
What causes a Detroit Diesel Series 60 to overheat?
This can indicate a coolant leak. If there is such a leak, you might also notice lower coolant levels in your engine, but things otherwise appear normal. This can lead to an overheated engine. Operators often find that they experience issues with their EGR system on their 14L Series 60 in particular.
Are there any problems with the series 60 engine?
We’ve briefly discussed some of these problems in our Series 60 spotlight, but we’ll dive into them a bit more fully here. It Still Runs also mentions a few of these issues. Cold starts, aptly named for starting your engine in cold temperatures, have given Series 60 engines trouble. They can lose their prime and not start properly.
What kind of engine does a Detroit 60 series have?
Vocational, Technical or Tra… road..brand new..When started, it blows one of the oil filters off. We have a Detroit 60 series engine in an off road pump. Engine is brand new. When started, it blows one of the oil filters off.
Why does my Detroit 60 randomly not start?
…sounds electronic, you’ll have to have someone monitor data stream on a scanner/laptop to see what’s missing (while it’s acting up); it is likely a missing engine position/speed signal. Hey Bob. Yeah I got to thinking about just changing certain things in hope it would fix it.
Why does the engine fan keep coming on and off?
The engine fan will only stay on for a few reasons. Mosf of the time the fan clutch solenoid is bad. It is an electric solenoid that turns the fan on and off. You can find it by following the air line that comes from the fan clutch hub. In you case, it may be the A/C high or low pressure switch since you are getting an A/C trouble code.
What causes a Detroit Diesel Series 60 bearing to spin?
Bearing problems, particularly spun bearings, are typically caused on older Series 60 by low oil pressure at idle. A spun bearing occurs when there is a lack of lubrication causing overheating.
What kind of truck has Detroit 60 series?
The truck is a 2008 Freightliner Colombia with a Detroit 60 series with 630k miles. 1. wont perform auto regen. 2: will not finish a park regen. I took the truck to a well known independent Detroit mechanic which was referred by couple of drivers in the area.
How to check Detroit Diesel Series 60 ECM?
Detroit series 60 ECM – Answered by a verified Technician. Here is diagram of the vehicle harness plug and the pin outs. graphic. Here is a I am going to attach a diagram of the engine harness also, so you can check the SRS and TRS wires. Series 40 detroit Diesel engine in a motor home. Ddec Iv Ecm Wiring Diagram. Source.
Is there charge for Detroit 60 series Regen service?
There is no charge for this service, but standard message and data rates may apply. Maybe the doser fuel pressure sensor. Detroit says even a drop of fuel leaking will cause an error, so check the fuel lines going to the doser. Here is a link to Detroit service bulletin to check for this error.
What causes a Detroit Diesel Series 60 bearing to seize?
Bearing problems, particularly spun bearings, are typically caused on older Series 60 by low oil pressure at idle. A spun bearing occurs when there is a lack of lubrication causing overheating. The bearing can eventually seize, creating even more problems.
Why are my Detroit Diesel Series 60 brakes not working?
These brakes could require different programming than what is standard on the Series 60, and the disconnect could cause a loss of throttle. If this is not the issue and you’re still experiencing throttle issues, you’ll probably want to take a look at your TPS (throttle position sensor).
Is there a problem with my Series 60 engine?
Discussion in ‘ Trucks ‘ started by Bob Horrell, Jun 28, 2009 . The truck is a 98 Western Star with a 12.7 liter series 60 Detroit engine (500hp). The problem is that it is loosing prime when sitting overnight and is hard to start. A description of the fuel system is as follows.
What causes a Detroit Diesel Series 60 to spin?
If there’s an issue with your throttle, that’s a good place to start. Bearing problems, particularly spun bearings, are typically caused on older Series 60 by low oil pressure at idle. A spun bearing occurs when there is a lack of lubrication causing overheating. The bearing can eventually seize, creating even more problems.
Is there a Detroit Series 60 12.7 engine for sale?
2006 Detroit Series 60 12.7 Used diesel engine for sale. 455 HP, Serial # 06r0942511.Tested and inspected with warranty. Call or visit our website for more information.. (GOOD USED) 2005 Detroit Series 60 12.7L Diesel Engine (EGR-MODEL), Serial # 06R0850770, Family # 5DDXH12.7EGY, 455HP@1800RPM, 12.7L, Low Miles, Runs Great!
What is Flash code for 60 series Detroit?
FLASH CODE:31DDR DISPLAY:ENG BRK LOW OPEN CIRCUITSAE J1587 CODE:SID: 51 FMI: 3Indicates that the Engine Brake Low function assigned to the Auxiliary Output #3 circuit is open or is shorted tobattery (+). This diagnostic condition is detected when Engine Brake Low driver is OFF and the DDEC III ECMmeasures a high voltage on the circuit output.
1 Coolant Leakage. Older Detroit engines are prone to coolant leakage in the EGR (exhaust gas recirculation) system. 2 Throttle Problems. The Series 60 was one of the first in the industry to be offered with a drive-by-wire system. 3 Starting Issues. 4 Spun Bearings. 5 Bad Fuel Economy.
How does Series 60 Detroit Diesel engine work?
The Series 60 was one of the first in the industry to be offered with a drive-by-wire system. This configuration does not utilize any mechanical connection between the throttle pedal and engine, relying instead on the truck’s computer to modulate air delivery by demand.
Why is my Series 60 diesel engine not running?
However, it took Detroit about 10 years to realize that the engine’s idle speed was not fast enough to operate the oil pump. As such, many older (pre-1997) engines have had lower engine bearings replaced more than once due to oil starvation. When it comes to power, the Series 60 tends to favor the higher end of the RPM band.
Why did they change the bearings on the Detroit 60?
Spun Bearings. In a bid to save fuel, the engineers at Detroit designed the 60 to idle at very low speed. However, it took Detroit about 10 years to realize that the engine’s idle speed was not fast enough to operate the oil pump. As such, many older (pre-1997) engines have had lower engine bearings replaced more than once due to oil starvation.
https://www.youtube.com/watch?v=y84iXqaa8jw
Are there any problems with the Detroit Diesel 14L?
Another common complaint, especially with the 14L, is poor fuel economy. As the engine got bigger and was designed for more horsepower, fuel usage seemed to increase as well. Some argue that this lowering of fuel economy is not due to engine design, but to poor operating practices.
https://www.youtube.com/watch?v=EjK5zHxYjj8
What to do if your Detroit Diesel engine wont start?
Using a starting fluid should help combat this issue, and you shouldn’t have any other problems from it once the engine is running. Changing the SRS (Synchronous Reference Sensor) and TRS (Timing Reference Sensor) could also help with this issue. These two sensors should be replaced at the same time to maintain proper operation.
How does Detroit Diesel Series 60 engine work?
Detroit Diesel Electronic Controlled Series 60 engines can be equipped with a variety of options designed to warn the operator of an engine malfunction. The options can range from “Check Engine” and “Stop Engine” panel lights to automatic reduction in engine power followed by automatic engine shutdown.
What is the model number of a Detroit Diesel engine?
Detroit Diesel Series 60 engines equipped with DDEC II electronic control systems are identified by a “U” in the sixth position of the model number. Example: 6067GU60. Detroit Diesel Electronic Controlled Series 60 engines can be equipped with a variety of options designed to warn the operator of an engine malfunction.
Is there a 1999 Detroit Series 60 engine for sale?
1999 Detroit 12.7 Series 60 used engine for sale . 500 HP, Serial # 06R0568768 . Tested and inspected with warranty. Call or visit website for more info!
Why does my Detroit have a misfire problem?
Thisdiagnostic condition is detected when the DDEC III ECM is unsuccessful in turning ON the Engine Brake Low driveroutput.NOTE:The Engine Brake Low output is a high side driver which means that the DDEC IIIECM supplies battery (+) to the engine brake low circuit to turn ON the function.
This engine comes in 2 configurations: factory reman or in-house reman. The factory reman is remanufactured by Detroit Diesel with all genuine Detroit parts.
What to do about excessive white smoke in the exhaust?
Run the engine at idle with a no-load for approximately 5 minutes, allowing the engine coolant to reach normal operating range. Visually inspect exhaust for excessive white smoke. If the engine exhaust emission appears normal, no further troubleshooting is required. Shut down the engine.
What kind of engine is Detroit Diesel Series 60?
Almost by definition, truckers have always been practically obsessed with engine reliability fuel mileage. To meet the demand for a new type of engine that would help usher turbo-diesels into this millennium, Detroit Diesel (a subsidiary of Chrysler AG) introduced the Series 60 as its industry trump car.
What causes a Detroit 60 series engine to derate?
Low boost, exhaust leaks before the turbo, boost leaks, and/or bad turbo Air in the fuel due to injector o-rings, crack in the suction line, etc etc. Faulty sensor- Usually followed by a check engine light, and the engine will derate.
Is there charge for Detriot Series 60 12.7?
Yes, let employers and TruckersReport text me with new opportunities, job alerts and other career information to the number I provided. There is no charge for this service, but standard message and data rates may apply. The 12.7 will run rings around cat when it comes to fuel, but the torque is only 1650. Very reliable motor.
What’s the purpose of the series 60 return valve?
Series 60 Fuel Return Check Valve. with one comment. The purpose of the check valve is to reduce the risk of fuel prime loss and fuel siphoning from the head when the fuel filter is removed.
When did I overhaul my Detroit S60 diesel?
I have overhauled my Detroit S60, year 2000 I put new pistons, new head, new fuel pump, new injector, new harness, new ecm and it does not work properly. It is idling roughly, doesnt have as much power as before, slow building turbo boost pressure from 16psi to maximum 24psi.
What do I need to know about Detroit Diesel power loss?
Air TO the V-pod MUST be greater than 100 psi, air FROM the V-pod TO the turbo actuator will NOT exceed 74 psi. Basically greater pressure then faster turbo speed. Sounds like you need a new V-pod. careful, I have gone thru 3 on 1 truck to find a good one. They are covered with a 1 year warranty though. Save the receipt.
Why does my Series 60 make a knocking noise?
This fuel could come from a leaking injector, but it could just as well be an internal oil leak. The Series 60 is more than capable of using its oil for fuel, so oil leaking into the cylinder through bad seals or through the turbo will act as an additional fuel and incite preignition.
What makes a series 60 diesel engine Rattle?
All diesels operate under a certain amount of uncontrolled detonation or even preignition, and direct-injection engines like the Series 60 are even more prone to rattle. Add that to the engine’s normal fuel injector and fuel pump racket and you’ve got a recipe for constant, though normal, clatter.
Why does my Detroit Diesel engine keep failing?
For some reason, there was a defect in some of the wrist pins that led to the separating of the piston pin and crown. This separation allowed the connecting rod to disconnect as well, and one of the loose components would then damage the engine block, often by creating a hole through it.
What should the PSI be on a Detroit 60 series?
You should have around 20 psi at idle and around 70 at full throttle. If you had egr issue, i would figure it would be logging a 39 code in the ecm.If you had a sucking air in the fuel system, truck will normally be hard to start and the pressure would be low.
What causes a series 60 engine to fail?
This separation allowed the connecting rod to disconnect as well, and one of the loose components would then damage the engine block, often by creating a hole through it. This issue did not affect all pre-2002 Series 60 engines, but it was a problem that occurred and could cause catastrophic engine failure.
How to get Detroit Diesel Series 60 engine parts?
You may also call us at 877.480.2120 to inquire about current pricing and availability of our products. We carry a large assortment of new and remanufactured parts for all three engines—11.1L, 12.7L, and 14.0L—including fuel injectors and turbochargers.
How to fix the problem with ECM Detroit 60?
ECM Detroit 60 Series how to fix the problem. – YouTube ECM Detroit 60 Series how to fix the problem. If playback doesn’t begin shortly, try restarting your device. Videos you watch may be added to the TV’s watch history and influence TV recommendations. To avoid this, cancel and sign in to YouTube on your computer.
When did my Honda 60 series idle stutter?
Had a daunting intermittent issue where the idle on my (late 1996 build) 60 Series would “stutter” from the normal 700 rpm up to 1000 rpm the normal high idle speed. I would not characterize this as a galloping idle, which is a different issue that I also experienced in a different life.
https://www.youtube.com/watch?v=UCMjeUholb0
Why does my Detroit 60 truck not start?
No matter how much fuel in the tanks or no specific time before it will not start. I have tried to figure a pattern but it is just to random and often. Truck exibits no problems while I drive it.
Is there a charge for Detroit 60 service?
There is no charge for this service, but standard message and data rates may apply. Could be as simple as a clogged up fuel filter. That is the problem I ran into. Yep, the turbo would be bad. I had a 12.7 I ran for 7 years and every 200k miles I had to put a new turbo on the truck.
Why does my Detroit Diesel have dead pedal?
Also, if you have Detroit Diesel Diagnostic Link, you can see how the engine controller interprets those voltages. After testing the sensor, we found that it was returning nearly 5 volts on the signal wire anytime the pedal was floored. That was all it took for this truck to have a dead pedal.
How to set up injector N3 ( Detroit Diesel Series’s 60 )?
Refer to “1.6.2 Removal and Cleaning of One-piece Rocker Cover For Diesel Engines Only” for one-piece, refer to “1.6.3 Removal and Cleaning of Two-piece Rocker Cover For Diesel Engines Only” for two-piece rocker cover, and refer to “1.6.5 Removal and Cleaning of Three-piece Rocker Cover” for three-piece rocker cover.
Is the Detroit Series 60 14.0 engine for sale?
(GOOD USED) 2008 Detroit Series 60 14.0L Diesel Engine For Sale, 515HP @ 1800RPM, DDEC 6, Engine Family 8DDXH14.0ELD, Emissions: EGR, DPF Model, Engine Serial# 06R1007716, Stock# 1959 Engine is… See More Details
Is there an issue with my Detroit Series 60 Freightliner?
Discussion in ‘ Freightliner Forum ‘ started by Berzerker, Nov 30, 2014 . Hey all, I have this issue with my detroit series 60 14L. Its 07 Freightliner. When I drive and apply normal throttle, or even just have cruise control on set at lets say 55mph.
Are there any Detroit Diesel engines still on the road?
There are millions of Detroit Diesel Series 60 engines still on the road today and it is extremely easy to remanufacture Detroit Diesel Series 60 engines due to their unrestricted open source design.
What to do if your Series 60 engine is not working?
If this is not the issue and you’re still experiencing throttle issues, you’ll probably want to take a look at your TPS (throttle position sensor). This sensor works with the electronic control system in drive-by-wire applications like the Series 60 engines, allowing for the electronic control to occur.
What are the codes for Detroit Diesel Series 60?
Detroit Diesel Series 60 Engines only; Codes 43, 44,45,51 and 53 are critical codes and if they are shown; the Stop Engine Light will come on which causes the engine protections to engage and your engine may shut down.
Are there any problems with my 2004 Columbia?
Not open for further replies. I have a 2004 Columbia with a 60 series Detroit and for the last two years there has been an intermitent electrical problem. The tach and speedometer will go to zero while the warning beeper is screaming, the shift indicator will go blank, sometimes the truck and traliler ABS indicator sounds as well.
What are the starter cables on a Detroit 60?
Starting Issues The factory starter cables on some Detroit 60 engines have been known to weather badly. While the 4-gauge wires the engine came with were sufficient from the factory, time can reduce the cable’s ability to transfer current to the starter.
Is there a turbo whistle on my Detroit 60?
The turbo whistle is very faint. I have a little bit of black smoke out of pipe when i accelerate onto the interstate. I had a brand new crate model put in 2008 and they didnt change the turbo. I believe this is the original turbo.
What kind of engine does a Western Star have?
ALL NEW MEMBERS PLEASE READ THIS FIRST!!! Discussion in ‘ Trucks ‘ started by Bob Horrell, Jun 28, 2009 . The truck is a 98 Western Star with a 12.7 liter series 60 Detroit engine (500hp). The problem is that it is loosing prime when sitting overnight and is hard to start. A description of the fuel system is as follows.
What should the PSI be on a Detroit 60 series engine?
1200-1300, you should have 30-45 psi 1800-2100, you should have 65-80 psi If the fuel pressure is high, I would suspect a plugged fuel filters or faulty fuel pressure regulator. If the guage is really bouncy, and unstable, especially under boost, then compression could be leaking past the injector o-rings.
What should the fuel pressure be on a Detroit Diesel?
Attach a calibrated gauge capable of reading 0-551 kPa (0-80 psi) to the fuel pump port. Crank or start the engine and record the reading on the gauge. If pressure is 0-60 kPa (0-10 psi) within 20 seconds of cranking, refer to “4.14.4.2 No or Low Fuel Pressure Test” , “No or Low Fuel Pressure Test.”
What kind of engine does a Freightliner Columbia 120 have?
Very Clean Farmer Owned Unit, recent engine overhaul 10000 miles ago, 14 liter Detroit 10 speed, great truck, call with any questions. 2003 Freightliner Columbia 120 470 hp 60 series Detroit 10 speed 963553 miles 130 gallon tanks 250″ wheelbase 100% tread on steers 90% on drives new paint aluminum wheels new chro…
How is a blow by test done on a 60 series?
What is a blow by test and how is it done on a 60 series… I have a 2001 freightliner classic xl with 60 series Detroit. I have a 2001 freightliner classic xl with 60 series Detroit. My heater is not working, it just blows cold air! Any suggestions? … read more Comercial transport technic… Vocational, Technical or Tra…
How much horsepower does a Detroit 60 series have?
DETROIT 60 SERIES 12.7 LITER 1 500 Horsepower 2 1650 Torque 3 3 Year 300k mile standard warranty from Fitzgerald (in-house only) 4 Warranty upgrades available (in-house only) 5 Most popular pre EGR Detroit Diesel engine available
Are there any changes to the Detroit Diesel engine?
There have been a number of design changes to the 60 Series Detroit Diesel engine in the piston assemblies. Although the DDEC series indentifies the engine control type and not the piston design, generally speaking that breakdown is as follows:
When does the engine shut off in a truck?
Discussion in ‘ Freightliner Forum ‘ started by lucky25, Sep 9, 2013 . HI, I HAVE 2001 FREIGHTLINER CENTURY DETROIT S60 WITH FRESH OERHAUL, AND PROBLEM IS, EVERY TIME I ENTERING A HIGHWAY ENGINE SHUTS OFF BETWEEN 9TH AND 10 GEAR AT 1700 RPM.
When does a Detroit 14L lose all power?
I have a detroit 14l, it starts and runs just fine. Idles fine, no missing. Hold above 1500rpm and after about 60 seconds it loses all power abruptly. No missing or fuel starve …
What does L stand for in Detroit Diesel Series 71?
L or N would stand for low profile, a setup commonly used in buses. The larger of the 71 series in a V-Block configuration were usually two of the smaller setups married together our used the same set of heads allowing parts to be easily swapped.
Is the Detroit Diesel Series 71 a V-block?
The larger of the 71 series in a V-Block configuration were usually two of the smaller setups married together our used the same set of heads allowing parts to be easily swapped.
Why are the gauges on my Western Star not working?
(Gauges worked fine untill we sent the truck to get painted, only thing we know is they unhooked the batteries, pulled the doors off and pulled off the hood. they climbed around the engine bay to paint the top of the cab but all connections look to be good. Gauges haven’t worked since truck left the paint shop)
What makes a Detroit Diesel Series 60-515 better?
By optimising the torque curve the Detroit Diesel Series 60-515 DDEC IV 14.0 515HP engine produces more torque at lower RPM. This also means that you can change gear earlier, so your Detroit Diesel Series 60-515 DDEC IV 14.0 515HP engine will run at lower revs and therefore more efficiently.
Are there turbochargers for the Detroit Diesel Series 60?
We offer new and remanufactured turbochargers for Detroit Diesel Series 60 11.1L, 12.7L, and 14L engines. For your convenience, please use the product links below to shop our inventory.
Do you need Jake brake on Series 60?
Do not install a Jake Brake on engines with lower serial numbers. Effective August 10, 2000, Model 795 Jake Brakes are used on all Series 60 engines requiring an engine brake. Former Jake Brake production models for the Series 60 engine were the 760A (which replaced model 760), 760B, 765, 765A, 770 and 790.
Which is Jake Brake model for Detroit Diesel?
Detroit Diesel engine model Nos. 6067GU28 and 6067GK28 are for bus/coach applications. Due to interference fits on some coach chassis, a two-housing Jake Brake kit may be required. Contact your Detroit Diesel Distributor for information on these kits. Jake Brake® is a registered trademark of Jacobs Vehicle Systems.
How to troubleshoot a Detroit Diesel engine problem?
Always start and operate an engine in a well ventilated area. If operating an engine in an enclosed area, vent the exhaust to the outside. Do not modify or tamper with the exhaust system or emission control system. Start the engine, and check for fuel leaks. Using “Check Engine” light, read the DDEC II Diagnostic codes.
How to test a misfiring cylinder in a Detroit Diesel?
Move the vehicle requiring test to the chassis dynamometer; refer to OEM guidelines. Start the engine. Run the engine and bring the engine coolant temperature to normal operating range. Run vehicle to full load and rated speed. Attach a manometer calibrated to read in. H 2 O, to the oil dipstick opening. Measure and record crankcase pressure.
How to stop a Detroit Diesel engine blowing white smoke?
Remove the Cam front cover, rotate the engine so the three holes in the cam gear line up so you can remove the (3) 13mm, 6 point bolts that go through the holes. I stuff a rag down in the front cover incase you drop one of those, this prevents the bolt from finding its way to the timing gears.
Is there a Detroit that won’t start?
By continuing to use this site you consent to the use of cookies on your device as described in our cookie policy unless you have disabled them. 2000 series 60 detroit that… Submitted: 10 years ago. Category: Heavy Equipment Yes it turns over and no smoke its like the ecm just isn’t sending signal to injectors to fire Hi and welcome to JA.