What would cause a golf cart not to run?
As the main source of power to your electric golf cart, the batteries are commonly the cause for why your electric golf cart won’t start. Acid-based batteries are typically used for electric golf carts and must be recharged in order to work properly.
How can you tell if a golf cart fuse is bad?
Replacing a Fuse Properly Now, open up the fuse box and identify the fuse that has blown. This step should be quite easy – the fuse will look “burned out” and may even have burns on its side. There may be a warning icon, too, that lets you know when a fuse has burned out.
How do you troubleshoot an electric club car?
There are a few simple problems that you can fix yourself that will not necessitate professional maintenance.
- Test the wall socket where you charge your cart.
- Expose your golf cart batteries.
- Test the batteries for voltage.
- Replace dead batteries.
- Expose the motor for inspection.
- Reset the motor.
- Test the cart.
Where is the fuse on a Club Car?
In a 1997 Club Car, the fuse is located in the electrical components black box that is present near the battery. On the other hand, in a 2005 Club Car Precedent, the fuse is connected to a blue wire under the golf cart seat.
How do I reset my club car OBC?
In any situation where the controller did not obviously fail, but it just stopped the OBC needs to be reset first. The reset process is easy to do, but can take a fair amount of time. The reverse buzzer will sound and go off in about 30 seconds. Leave the cart like that for 5 min to cause the OBC to reset.
What kind of power does a club car have?
Acceleration is jerky on takeoff and when running the cart will suddenly lose about half power; intermittently it switches back to full pow … read more I have a 2005 club car precident cart. 48 volt electric 4-12volt batteries. Cart is fully charged, play 6 or 7 holes and cart just runs down and stops.
Why is my club car not running well?
Gas and air. If it can’t get the proper amount of either your cart will have a tough time running well. If your Club Car feels like it is bogging down when you give it the throttle there is a good chance it is not getting enough air into the motor. Making sure the air filter is clean will help get a good air flow moving into the cart’s motor.
Can a 48 volt club car lose power?
48 volt club car was driving and suddenly lost 90% of power… Batteries are fully charged… was running fine and just I have a 1991 club car golf cart. Purchased 2 months ago. I have a 1991 club car golf cart. Purchased 2 months ago. Batteries were 2 yrs old, so replaced all 6 (8 volt) last week. Immediately noticed … read more
Is the speed sensor on a club car bad?
In a Club Car golf cart in which the speed sensor is working fine, it will slow the cart down. If the cart keeps moving, then the sensor is bad. One important advice concerning batteries is that only golf cart batteries should be used in golf carts. Do not use deep-cycle batteries.