What causes RPM surge at idle?
If an engine is not getting enough fuel (this is called “running lean”), due to fuel pressure (regulated by the fuel pump and regulator), restricted fuel injectors, a vacuum leak or really anything that throws off the fuel mixture going in to the engine, this can cause the surge.
What is surging while driving?
Engine surging is when an engine starts easily and accelerates smoothly, however after a few minutes at a steady speed, it either surges in speed or misfires. Misfiring happens when one of the cylinders of an engine’s combustion cycle fails.
Can timing cause surging?
Timing, mixture setting, and idle would not cause an engine to surge.
What causes engine RPM to fluctuate?
If your RPM fluctuates while accelerating, it could be because your spark plugs have gone bad on you. Worn-out spark plugs can cause misfires to occur within your engine, and those misfires can lead to your engine vibrating a whole lot. Those vibrations can lead to the RPM in your engine going haywire on you.
Why does the engine surging stop at idle?
If I put a load on the engine by turning on the airconditioning compressor, the surging will often stop. This is an intermittent problem but seems to occur at least 50% of the time and seems to be worse after the engine has warmed up. Thank you for any input. My car has 225000 miles. My car has a manual transmission.
How often does the engine idle during a drive?
• The learned idling air flow volume remains at the maximum or minimum volume five times or more during a drive cycle. • After driving at 6.25 mph or more, the actual engine idling speed varies from the target idling speed by between 100 and 200 rpm, five times or more during a drive cycle.
What causes the idle air controller to surge?
The idle air controller is simply a computer-controlled motor that controls idle. There could also be another sensor that is telling the computer to compensate, and in turn, this causes the idle to surge as it looks for the correct RPM level.
What causes an engine surge when the ECU is off?
If closed TPS voltage changes, the ECU may assume that your foot is on the throttle, causing a richer fuel mixture to be delivered. This can also be caused by a faulty TPS, or even a poor ground. With the engine off, check TPS voltage with the accelerator pedal relaxed. Then work the pedal a few times and see if the voltage changes.