What causes oil leak in Saab 9-5 engine?

Oil leaks from the timing cover, valve cover, and/or rear main seal may be due to excessive crankcase pressure. An updated PCV (Positive Crankcase Ventilation) kit was released to fix this concern. Saab 9-5 Vehicles With This Problem.

How much coolant does a Saab 9-5 need?

At least, that was the case with my 2004 9-5 2.3T. Other engines may be different so measure and do your own calculations. After a full drain, there is still 2.1 liters of distilled water left in the engine. The recommended mix of coolant/water is 50/50. 7.4 divided by 2 is 3.7 liters of coolant needed.

Where is the oil pressure switch on a Saab 9-3?

The procedure to access the Saab oil pressure switch on a 9-3 is as follows: Remove the air cleaner cover. Disconnect the pipe of the mass air flow sensor. Remove the upper engine cover. Remove the upper turbocharger delivery pipe.

How do you fill and flush a Saab 9-5?

Open the cap on the expansion tank and release the pressure. 2. Raise the car. 3. Remove the lower front cover. 4. Open the drain cock on the radiator and drain off the coolant. 5. Close the drain cock. 6. Lower the car to the floor. 7. Switch off the A/C or ACC. Fill with coolant to the MAX level.

Where to remove coolant from Saab turbocharger?

Again, don’t worry if nut comes off or entire stud with nut comes off they will go in just as they came out. (16)Remove the coolant feed line banjo bolt (12MM) from directly beneath the water pump left of the turbocharger (left while standing in front of the vehicle). Don’t lose the two copper washers.

Where is the banjo bolt on a Saab turbocharger?

(17 cont.)Remove the 12MM banjo bolt from the turbo coolant return line and remove the rubber coolant line which has a hose clamp (circled in blue). (17 cont.)Remove the 10MM bolt which holds the turbo coolant return line in place. It is located approx. halfway between the turbo and banjo bolt just removed.

How to disconnect Turbo lines on a Saab?

(7 cont.)Disconnect turbo lines from Turbo compressor housing, waste gate, and cobra pipe. Also, wear rubber gloves (I ran out) then you won’t be spending the next week trying to get crud out from under your nails. (7 cont.) Remove the boost controller (slide it off) and push it to the side.

Where is the direct ignition cassette on a Saab?

(24) Unplug the Direct Ignition Cassette (DIC) which is located directly on top of the engine. (25)Unplug fuse 19 for the fuel pump. (26)Crank engine for several seconds (10 should do fine) so as to prime the turbo with oil. (27)Plug everything back in and start her up.

How much does it cost to replace PCV valve on Saab 9-5?

The average cost for a Saab 9-5 PCV Valve Replacement is between $60 -$68. Learn More I have already changed the crankcase unit last year. Now I see oil leaks from the timing cover and/ rear main seal.

What kind of engine does a Saab 9-3 have?

Affected models include the 2000-03 Saab 9-3 and 1999-2003 Saab 9-5. This video is put up specifically for the SAAB Central Forum. It’s a head gasket replacement and sludge cleaning process for 2002 9-3 Viggen.

Why is YouTube not working on my Saab 9-5?

If playback doesn’t begin shortly, try restarting your device. Videos you watch may be added to the TV’s watch history and influence TV recommendations. To avoid this, cancel and sign in to YouTube on your computer. I Bought the Cheapest Saab 9-5 in the US!

Is there a problem with my Saab 9-5 Aero Turbo?

I guess either the car has electrical problem, or the indicator is faulty. Well actually it may also be ECU failure. To be honest with you – I will be tricky to sort out. When you put your foot down the needle should go into the red field no problem. BTW, Welcome to the EU, I hope there will be more Saab owners in Poland from now on.

Where is the turbo gauge on a Saab 9-5?

It should certainly go to the top of the orange/bottom of the red boundary though. If it doesn’t make it to the top of the orange, all is not well. The turbo gauge on the 9-5 is operated by a feed from the ECU. The gauge is just an electrical meter.

How many miles does a Saab 9-3 engine take?

We own a 2008 9-3 Saab that has approximately 120,000 miles on it. When it is cold outside (50 degrees and below), our car starts very roughly after 2-3+ minutes of continuous cranking. Once the car starts and has warmed up, it runs quite smoothly.

What to do if you have oil build up in intake manifold?

What you have to do to get rid of this problem is to pour an engine flush formula into the oil and run the engine for a few times. When the buildup is cleared, change the engine oil and don’t forget to replace the air filter. If it does not solve the issue, take the help of a professional mechanic. A blocked oil passage is another reason.

When to worry about oil in air intake?

It is the first component to look into when the problem occurs although you should not be worried if there is a small amount of oil in air intake. It is not rare to have blocked PCV valves on cars with less than 100,000 mileage. You have to examine the entire PCV system.

What’s the p / n code for a Saab Turbo?

I’m ready to try replacement of this next to eliminate the 1105 and 1106 fault code. According to the EPC is the original P/N 55 560 162 “No Longer Serviced” – obsolescent – , replaced by 91 97 948, then 30 584 326 and finally by 55 563 262.

How many quarts of oil should I add to my engine?

Steve first tested this oil pressure problem by adding a half quart (to be safe) and recorded an even greater pressure drop. He eventually drained 2 ½ quarts of oil from the engine and not only did the oil pressure stabilize, but the power improved by a solid 20 hp as well.

What kind of ballast does a Saab 9-5 have?

Saab 9-5 Xenon Lights Genuine Ballast D1S Gas Bulb Control Unit HID Assembly Wires Cable Parts.If your SAAB 9-5 Mk1 Xenon HeadLight have Problems like : flickering or ballast bad light not working can find us replacement the oem xenon parts.Professional supplied by www.oemxenonshop.com. Acura Alfa Romeo Aston Martin

What was the rating of the 2002 Saab 9-5?

4.6923075 average Rating out of 26 reviews. 4.5555553 average Rating out of 9 reviews. Ever wonder what happened to the honor roll students from high school and college?

What kind of headlights are in a Saab?

VW OEM HID Xenon Headlights Car Model> Saab>9-5 Mk1

What kind of engine does a Saab 9-5 have?

Part will fit : Driver side / Passenger side / Left / Light / Front Saab 9-5 : 4-door sedan , 5-door station wagon , 1.9L , 2.0L , 2.3L , 3.0L V6 , Aero

Is there a leak in the footwell of my Saab?

I have however noticed a long pipe/outlet-type gutter above the footwell which seems to be damp, so not sure if it’s coming out of there – the heater has been making a sort of dripping sound recently from that side, but only intermittently. It looks like this is part of the heater or air con. The heater is working fine though at the moment.

Where does the water go in a Saab?

Water cannot then run down to the ground behind the front wheels and ends up in the car instead. Thanks for all your help – hopefully I’ll get to the bottom of it and will have a good look around to clear any unblocked drains…

Navigation