How does the fuel pump work on a ezgo golf cart?

The fuel pump has several nozzles on it to accept the vacuum line, and both the Fuel In and Fuel Out lines. Inside the pump, there are several diaphragms which use the pulsing action created by the vacuum of the crankcase pressure to draw fuel from the storage tank and push it onward to the carburetor of the golf cart.

How do I prime my EZ GO fuel pump?

How to Prime a Golf Cart Fuel Pump

Turn the engine of the golf cart on and remove the gas cap.
Keep a rag around the filler hole.
Blow hard into the gas tank. You may have to do this a few times until the engine starts purring and the fuel filter has fuel in it.

What kind of gas does a EZ Go golf cart use?

Use only regular grade unleaded (87 octane) fuel. Never use fuel that contains more than 10 percent ethanol. Make sure the gasoline tank cap is securely tightened after each refill. Keep the area around the fuel cap clean and free of grass clippings and other debris that could fall into the tank.

Can you clean a fuel pump on a golf cart?

Often, fuel pumps can be cleaned out, repaired and rebuilt. After the golf cart fuel pump problems were repaired, we also needed to clean out the carburetor to remove similar varnish and debris, replaced all fuel lines and changed both fuel filters, both in the gas tank and inline.

Should I put premium gas in my golf cart?

Golf cart manufacturers recommend running only 87 octane gasoline. If you are located in a high altitude level, or running your golf cart under high loads or heavy use you may benefit from a higher octane gasoline.

How to tell the year of an EZGO golf cart?

EZGO Serial Numbers do not indicate the year of production. You will need the Model/Manufacturer Number to determine the year of an EZGO Golf Cart. To help you match the right aftermarket parts and accessories to your EZGO cart, we’ve created a basic mdoel number guide below. Contact us for more information EZGO golf products.

What kind of golf cart is an E-Z?

E-Z-GO Golf Carts are broken down into eight base models. Four of these models, Marathon, Medalist, TXT, and RXV are the most common. Serial & Manufacturer Number Locations E-Z-GO Golf Carts Pre-1976

What kind of oil to use on EZGO golf cart?

Replace as needed Either Clean filter in a solvent or replace with new. Always replace ‘O’rings. Replaced with a SAE 10W-30 or 10W-40 grade oil. Adjust in accordance with wheels service guidelines below. Pack with wheel bearing grease. Clean and adjust in accordance with breaks service guidelines below.

Can a golf cart have an oil leak?

Issue 2: Since golf cart fuel pumps are based on a vacuum created by crankcase pressure, if there is any type of leak in the crankcase or lower end of your engine, you may experience fuel issues. An effective cannot be produced from an engine with a leaky crankcase. Check for any outward signs of an oil leak.

What should the fuel pressure be on a golf cart?

The fuel pump of a Yamaha G14 golf cart has a standard pressure of 178PSI. The minimum pressure must always be 142PSI. An electric fuel pump in a Yamaha G2 cart often has a low pressure of 3 to 5PSI with 1/4-inch lines. In some cases, the fuel pump gets activated when the fuel pressure is lower than 2PSI.

What happens if the fuel tank is empty on an EZGO?

If the fuel tank of an EZGO golf cart is empty, there is likely to be a problem in the vacuum tube that connects the crankcase and the fuel pump. The tube may either be completely damaged or have just a hairline crack that drains off the fuel. Consider replacing this tube.

What happens when you run out of gas in a golf cart?

If your golf carts runs out of gas, the engine will stop running. This in turn stalls the cart and makes it difficult to control the braking and steering. The fuel line will be filled with air causing the fuel injectors to get clogged or the fuel pump to get damaged.

Navigation