Where can I find a Kawasaki MULE service manual?
Please visit our Home Page to see a complete list of all the useful service manuals we offer. “Service Manual” is a generic term we use to describe Repair Manuals, Technical Manuals, Workshop Manuals, Shop Manuals, etc. The Service Manual Vault has made every effort to make your Kawasaki Mule service manual shopping experience as easy as possible.
What causes a kawaskai mule to not start?
Click to expand… A defective Bendix or Starter Clutch as it is sometimes called could cause these systems. When you turn the key, the solenoid could energize and the starter motor could try to turn but if the Bendix is frozen it will not start . . .click-click-click!
How to troubleshoot a mule that will not start?
Everything was running fine put it up one night, went out the next morning was a little harder to start (normally fires right up said it kind of sputtered) road it around a little and then parked it went back later and it will not start turn over but will not start. So hear is what I have went through.
Can a solenoid be replaced on a mule 550?
I would say replace the solenoid, they are $30 or so on eBay and easy to install, but I had the same problem on my Mule 550 gas and a new solenoid did not fix the problem. I posted a similar question yesterday, but have not received any replies.
How to troubleshoot a Kawasaki MULE that will not start?
Pulled plug changed plug, and it gets plenty of spark, finger over spark plug hole will blow back when turning engine over, cleaned fuel filter, new gas, pull fuel line to carb gas is pumping to the carb, pulled carb cleaned it…. That still didn’t work, then I tried to start with Ether and it would not hit even with ether.
What’s the weirdest thing about a kawaskai mule?
Sometimes it would start cold and after riding a while, if you shut it off…..click, click, click. Sometimes it wouldn’t start cold but if you waited a while, it would start. Weirdest of all…..sometimes if you held the key in start position, after about 4 seconds it would start.
What was the problem with my 02 550 mule?
Had the same problem with my 02 550 mule. Just a click but couldn’t get the engine to turn over. Sometimes it would start cold and after riding a while, if you shut it off…..click, click, click. Sometimes it wouldn’t start cold but if you waited a while, it would start.
I would say replace the solenoid, they are $30 or so on eBay and easy to install, but I had the same problem on my Mule 550 gas and a new solenoid did not fix the problem. I posted a similar question yesterday, but have not received any replies.
Is there a recall on the Kawasaki 2091 mule?
The Kawasaki 2091 Mule PRO-FXT Ranch Edition is part of a 72,000 vehicle recall. Hazard: Debris can ignite on the vehicle’s exhaust manifold; and frozen water can block the breather hose allowing oil to leak, posing a fire hazard.
When did the Kawasaki kaf400 mule 600 come out?
Covers all 2005-2010 Kawasaki KAF400 Mule 600 2×4 / Mule 610 4×4 / Mule 610 4×4 XC Models Mobile Device Ready Manual* (Works with most devices, CLICK HERE and see question #5 for details) Covers all 2011-2016 Kawasaki KAF400 Mule 600 2×4 / Mule 610 4×4 / Mule 610 4×4 XC Models
What kind of engine does a Kawasaki MULE 4010 have?
Covers all years and versions of the Kawasaki Mule 4010 Trans series with the gasoline engine. Mobile Device Ready Manual* (Works with most devices, CLICK HERE and see question #5 for details) Covers all years and versions of the Kawasaki Mule 4010 Trans series with the diesel engine including the following:
Are there any recalls on the Kawasaki MULE?
Kawasaki recently announced two large recalls of their Mule utility vehicles. The recalls of 80,000 and 72,000 vehicles are for separate issues but there is a large overlap among the model years and Mule models affected. The first recall involves excessive wear of the steering shaft that can affect steering control and result in a crash hazard.
Is there a recall on 80, 000 GMC mules?
The recalls of 80,000 and 72,000 vehicles are for separate issues but there is a large overlap among the model years and Mule models affected. The first recall involves excessive wear of the steering shaft that can affect steering control and result in a crash hazard.
Where is the VIN on a Kawasaki MULE?
They have four wheels, side-by-side seating for three to six people and automotive style controls. Mule Pro is printed on the right and left front fender. Kawasaki is printed on the cargo box. The Vehicle Identification Number (VIN) is located on the steel frame between the right front lower A-arm mounts.
What did Kawasaki do at 20 HR service?
Kinda unrelated but My dealer called me up at first 20 hr service on my 2015 and asked if they could drill a hole in plastic below rear seat to access oil filter without taking panels off completely. They said Kawasaki made a rubber plug for the hole because they were aware of issue with filter location.
What’s the capacity of a Kawasaki MULE side X?
The MULE PRO-FXT ™ side x side is a full-size, high-capacity vehicle featuring a 3- to 6-passenger Trans Cab ™ system. Strong enough for work and play, this side x side has an impressive hauling and towing capability, even in six-passenger mode.
When did the Kawasaki MULE 500 come out?
In 1991, the MULE™ 500 utility vehicle was also introduced. This personal-sized utility vehicle was compact in size, easy to use, and could easily fit into the back of a pick-up truck for transportation to work sites.
Is there a Kawasaki 3010 mule for sale?
Beware Of Internet Scams! Up for auction is Kawasaki 3010 Mule 4×4, Runs an drives as it should, up to 6 people seating, Factory top, Dump Bed, Unit drives better in low than in high. This is a used item so there will be no warranties or guarantees provided.
What are some Kawasaki MULE 2510 specs?
- Lubrication. The Kawasaki Mule 2510 had two power mill configurations – a liquid-cooled V-twin OHV engine and a fuel-injected diesel one.
- Drivetrain.
- Ignition.
- Brakes.
- Suspension.
- Capacities.
- Exterior.
- 1999 Kawasaki Mule™ 2510 4×4 Review
- 1993 Kawasaki Mule™ 2510 vs.
How much does a Kawasaki MULE weigh?
The Mule has four-wheel, sealed hydraulic drum brakes and rack and pinion steering. The 3010 Mule is 112.6 inches long, 57.5 inches wide and 76.2 inches tall. It has a 73.6-inch wheelbase with 7.2 inches of ground clearance. Its dry weight is 1,314 lbs. It carries 803 lbs. and tows 1,200 lbs.
What is the top speed of a mule?
The Ranger takes the top-speed honors by 15 mph with a 62-mph reading. The Mule is no slouch, either, but it is electronically governed at 47 mph. Getting up to speed is no contest, either. The Ranger smokes the Mule off the line and powers all the way to top speed.
What is the history of the Kawasaki MULE?
The Kawasaki MULE (Multi-Use Light Equipment) is a series of lightweight Utility Task Vehicle that have been built by Kawasaki since 1988.