Why is my golf cart so bouncy?
One of the common issues associated with the golf cart bounce is the tire. If the tires are not aligned properly or the threading has worn out, it could cause the cart to bounce. Check for the air pressure in your golf cart’s tires. If the air pressure in it is too much, this could cause it to bounce.
How often should you check golf cart batteries?
once every two months
You should aim to check the water level in your battery cells every at least once every two months to ensure that your battery isn’t ask risk of being ruined due to low water levels.
Can you adjust a clutch on a golf cart?
If you are unsure about removing the drive belt or the clutch, then you can adjust it. Just take out the belt and wound it again with the secondary clutch according to the requirements, and your problem should be fixed.
What does a clutch do on a golf cart?
Golf cart clutches, working together, provide a smooth start up and take off, and smooth acceleration and deceleration. As the engine spins, internal flyweights cause one drive clutch sheave (pulley half) to slide in along its main shaft toward the other sheave, which is fixed to the engine crankshaft.
What to do when your golf cart starts but nothing happens?
If your golf cart starts up fine and you’re able to take it short distances, but find that after a few minutes it simply comes to a stop, you may be looking at a problem with your solenoids. If these have begun to break down, you’ll likely need to replace them in order to get your golf cart up and moving again.
What causes a Yamaha G1 golf cart to stall?
Usually, it is two things that cause stalling in your Yamaha G1 golf cart: A dirty or oily carburetor-check the rubber boot in the cylinder for any dirt formation. Take the carburetor out and clean it using a carburetor spray. Clean the inside boot.
What are the symptoms of a bad solenoid on a golf cart?
On an electric golf cart, the most common symptom is the solenoid is not delivering electricity to the controller when the vehicle’s ignition is turned on. In normal operating conditions, the solenoid clicks on and off with the ignition switch. A failing solenoid will generally not click.
When to replace ignition coil on golf cart?
If your ignition coil is just starting to fail, a common symptom is that your cart will start and run just fine when it’s cold but die when it starts to warm up. You’ll have to replace your ignition coil if this is the case.
Why does my electric golf cart not start?
The first and most obvious symptom is the golf cart won’t start. If it is a gas-powered cart, the engine doesn’t turn over, and if it is an electric cart, the cart doesn’t move. The engine on the gas-powered cart starts, but the starter doesn’t disengage after starting.
Usually, it is two things that cause stalling in your Yamaha G1 golf cart: A dirty or oily carburetor-check the rubber boot in the cylinder for any dirt formation. Take the carburetor out and clean it using a carburetor spray. Clean the inside boot.
Why does my golf cart keep cutting off?
Sometimes, one or both of the batteries could be dead making the cart cut off. Ensure that both the batteries are working fine and have enough water and electrolytes. If the batteries are dead, then replacing them will solve the issue. One of the most common complaints with golf carts is that it dies after driving for some time.
What should I do if my golf cart dies?
The cart will generally oblige and run for a few minutes before shutting off again. By letting the engine cool off for a few hours, you may be able to start the cart and make it run for some time. After running the engine for a while, the cart may once again die. Method #1 – Check Carburetor