What causes a kawaskai mule to not start?

Click to expand… A defective Bendix or Starter Clutch as it is sometimes called could cause these systems. When you turn the key, the solenoid could energize and the starter motor could try to turn but if the Bendix is frozen it will not start . . .click-click-click!

How to troubleshoot a mule that will not start?

Everything was running fine put it up one night, went out the next morning was a little harder to start (normally fires right up said it kind of sputtered) road it around a little and then parked it went back later and it will not start turn over but will not start. So hear is what I have went through.

What kind of Mule is my grandpa’s?

Hey folks this has me stumped hopefully you can help me figure it out, This is my grandpas mule 550 KAF300-C6.

Can a solenoid be replaced on a mule 550?

I would say replace the solenoid, they are $30 or so on eBay and easy to install, but I had the same problem on my Mule 550 gas and a new solenoid did not fix the problem. I posted a similar question yesterday, but have not received any replies.

How to troubleshoot a Kawasaki MULE that will not start?

Pulled plug changed plug, and it gets plenty of spark, finger over spark plug hole will blow back when turning engine over, cleaned fuel filter, new gas, pull fuel line to carb gas is pumping to the carb, pulled carb cleaned it…. That still didn’t work, then I tried to start with Ether and it would not hit even with ether.

What’s the weirdest thing about a kawaskai mule?

Sometimes it would start cold and after riding a while, if you shut it off…..click, click, click. Sometimes it wouldn’t start cold but if you waited a while, it would start. Weirdest of all…..sometimes if you held the key in start position, after about 4 seconds it would start.

What was the problem with my 02 550 mule?

Had the same problem with my 02 550 mule. Just a click but couldn’t get the engine to turn over. Sometimes it would start cold and after riding a while, if you shut it off…..click, click, click. Sometimes it wouldn’t start cold but if you waited a while, it would start.

Hey folks this has me stumped hopefully you can help me figure it out, This is my grandpas mule 550 KAF300-C6.

What’s the problem with my Kawasaki MULE 610?

Here is an on-line part sheet that showed the 27002 as a relay. I have never seen a 610 so I can’t be much more help. Also check for blown fuses. I had a 610, the same thing happened to me. I even replaced the ECM, you won’t believe what the problem was. The ground cable was oxidized and loose.

Where can I find a Kawasaki parts diagram?

The proper maintenance of your Kawasaki vehicle is the best way to ensure that it operates at its full potential. Whether you work on your vehicle or bring it to an authorized dealer for service, we recommend that you use Kawasaki Genuine Parts. Select a category and model to find the parts diagram you are looking for.

What’s the model number on a Kawsaki mule?

Need help determining your Mule model number? Copyright Kayden Enterprises, Inc.. 2003-2016, All rights reserved. Universal ATV CV Boot. Replace that damaged or worn out CV Boot. Fits most ATV’s Honda/Yamaha Starter Solenoid.

Why does my Kawasaki MULE 610 not start?

But about 50% of the time when you turn the key, you can hear (and feel) the solenoid moving in the starter motor, but the motor itself fails to turn, so it does not start. And then 5 minutes later you might be able to go back to it and turn the key and it will start right up. Or it won’t start at all.

Why is my Kawasaki UTV SxS 610 not starting?

I have been having in intermittent problem with starting. The battery is good, no loose ground wires, or any other easily identified issues. But about 50% of the time when you turn the key, you can hear (and feel) the solenoid moving in the starter motor, but the motor itself fails to turn, so it does not start.

What did I do to my kawaskai mule?

I replaced solenoid, battery, cleaned all wire terminals only worked when battery was fully charged until I added the relay.

What’s the problem with the Kawasaki MULE PRO MX?

The Kawasaki Mule Pro-MX UTV had a safety recall where the vehicle might be susceptible to fire outbursts. The engine cooler hoses were not strong enough and might cause an oil leak. The second issue on the Kawasaki Mule Pro-MX was a faulty fuel tank gas cap. The cap was thought to be leaking, raising the risk of fire.

What kind of starter relay does a Kawasaki Bayou use?

Cyleto Starter Solenoid Relay for Kawasaki BAYOU 220 KLF200 1988-2002ATV/BAYOU 250 KLF250 2003-2010 ATV/KLX650 KLX 650 1993-1996/VN800 VULCAN 800 1996-2005/HONDA VT750C Shadow 2000/SUZUKI GSXR750 1993 . Only 15 left in stock – order soon.

What should I do if I have a bad starter relay?

They can also be hazardous and can cause damage. If you run into symptoms of a bad starter relay or solenoid with your car, truck, or SUV, make sure to have a trusted technician to diagnose the specific problem. This article is intended only as a general guidance document and relying on its material is at your sole risk.

How many Kawasaki starter solenoid mules are there?

Only 7 left in stock – order soon. . Only 12 left in stock – order soon. . Only 18 left in stock (more on the way). . Only 5 left in stock – order soon.

Are there any Kawasaki road passion Relays left?

Road Passion Starter Solenoid Relay 12v for KAWASAKI BAYOU 220 KLF220 1988-2002 BAYOU 250 KLF250 2003-2010 ATV KLX650 1993-1996/VN800 VULCAN 800 1996-2005/SUZUKI GSXR 750 1993/HONDA VT750C Shadow 2000 . Only 9 left in stock – order soon. . In stock on May 16, 2021. . . Only 14 left in stock – order soon. . . . . Only 8 left in stock – order soon. .

Navigation