Why is my fuel pump not working on my Kawasaki 3010 mule?
Has been hard to start since bought used several months ago, full choke had almost no effect, but finally cranked after 30-45 seconds of cranking. Once started, it seemed to run fine. Now, it won’t start at all. Pulled fuel line between filter and fuel pump, fuel flowed from tank. Pulled fuel line at carb, but no fuel when cranking.
What kind of fuel pump does a Kawasaki MULE use?
See and discover other items: kawasaki 1000 mule parts, kawasaki mule 2510, kawasaki mule accessories, kawasaki mule parts, kawasaki mule, fuel pump replacement There’s a problem loading this menu right now.
Where is the fuel pump relay on a Kawasaki?
If that is good, then it is likely the relay or the igniter. Lift the seat out and follow the wiring harness, you will find the relay. Take a look at the parts diagrams on Kawasaki.com to get an idea of what you are looking for. These use a power lead from the igniter to the coil to power the pump relay.
Has been hard to start since bought used several months ago, full choke had almost no effect, but finally cranked after 30-45 seconds of cranking. Once started, it seemed to run fine. Now, it won’t start at all. Pulled fuel line between filter and fuel pump, fuel flowed from tank. Pulled fuel line at carb, but no fuel when cranking.
See and discover other items: kawasaki 1000 mule parts, kawasaki mule 2510, kawasaki mule accessories, kawasaki mule parts, kawasaki mule, fuel pump replacement There’s a problem loading this menu right now.
If that is good, then it is likely the relay or the igniter. Lift the seat out and follow the wiring harness, you will find the relay. Take a look at the parts diagrams on Kawasaki.com to get an idea of what you are looking for. These use a power lead from the igniter to the coil to power the pump relay.
How to troubleshoot a Kawasaki MULE that will not start?
Pulled plug changed plug, and it gets plenty of spark, finger over spark plug hole will blow back when turning engine over, cleaned fuel filter, new gas, pull fuel line to carb gas is pumping to the carb, pulled carb cleaned it…. That still didn’t work, then I tried to start with Ether and it would not hit even with ether.
Why is my fuel pump not working on my Kawasaki?
If the pump will not freely pump when directly connected to 12 volts DC, then it is likely defective. A generic pulse type pump from an auto parts store works great and usually costs less than ten bucks. But, if you do that you need to wire in a new fuel pump switch and get the load off the coil lug.
Why does my car not start when I pull the fuel line?
Now, it won’t start at all. Pulled fuel line between filter and fuel pump, fuel flowed from tank. Pulled fuel line at carb, but no fuel when cranking. Measured voltage across wire harness fuel pump leads (pump disconnected) when cranking, only saw 2-3 volts.
What should I do if my Kawasaki MULE wont start?
Let it pump a minute, then try to start the Mule. Also, make sure you are not trying to start with a low battery, that could be a life long effort. These require the battery be fully charged for the pump and relays to function properly. Do not jump start it from a running vehicle, or you will damage relays and the igniter and may never start.
If the pump will not freely pump when directly connected to 12 volts DC, then it is likely defective. A generic pulse type pump from an auto parts store works great and usually costs less than ten bucks. But, if you do that you need to wire in a new fuel pump switch and get the load off the coil lug.
How do you Prime a Kawasaki 3010 mule?
If you have a manual with a diagram, you can find the fuel pump relay and jump two of the wires together…then the pump runs when the key is on and will prime the system. Seems like its the bk/blu and blk wires.
Why does my fuel pump not turn on?
It is a safety thing so the pump shuts off when the ignition is killed. If the igniter does not generate enough power the relay will not trip, or if the pump shorts it burns out the relay too. If the pump will not freely pump when directly connected to 12 volts DC, then it is likely defective.
What kind of fuel pump does a mule have?
RTV900 G Parting out a mule 1000 kaf 450. Has hydraulic dump bed and good igniter. Let me know what you need and I will shoot you a price.
Is there no power to fuel pump tips and repair?
Kawasaki mule 3000 no power to fuel pump tips and repair !!!!400TH UPLOAD!!!! If playback doesn’t begin shortly, try restarting your device. Videos you watch may be added to the TV’s watch history and influence TV recommendations.