What should I do if my ATV is not getting fuel?

Try starting the engine for at least 20 seconds. If it does start, don’t let it run for longer than 20 seconds. Then you want to sit and wait about 10 minutes or so. You need to give the fuel injector cleaner time to do its work. Repeat the process five more times, but only try to start for 10 seconds, and then let sit for ten minutes.

What to do if your fuel pump is not working?

To make sure you’re vacuum operated fuel pump is working correctly, pull the vacuum line to the fuel pump off and crank the engine. You should feel a good amount of suction at the mouth of the carb. The engine crates a vacuum pulse to the fuel pump, which in turn creates an amount of pressure that pushes fuel into the carburetor.

How do you replace the valve seal on an ATV?

To check and replace the valve seal, you’ll need a pick or something to pull it from the carburetor. I’ve used a sheet rock screw before. Just thread the screw in a little and pull out the seal. Check out the picture for an idea of what you’re looking at. Once you’ve removed the old seal, insert the new one and make sure it’s seated all the way.

How to start a Kubota RTV 900 without fuel?

There is a hex bleeder near where the rubber fuel line enters the injection pump. Bleed it there. Loosen the hex, crank engine until fuel comes out, tighten bleeder, then start the engine. It may take some cranking if it has a lot of air in it. IIRC the hex bleeder is 10mm on the old 900’s. Here’s how I diagnose a no-fuel situation.

When did the workshop manual for rtv900 come out?

WORKSHOP MANUAL UTILITY VEHICLE RTV900 KiSC issued 03, 2008 A 2. TO THE READER This Workshop Manual has been prepared to provide servicing personnel with information on the mechanism, service and maintenance of RTV900.

How long does it take to replace fuel filter on Kubota?

If the answer is yes, you should purchase a replacement . Replacing the fuel filter is a fairly simple process, you just need to be sure to pinch the lines connecting to it before you remove it, so you don’t spill fuel all over you or your tractor. You’ll be able to remove the filter and replace it in about 10 minutes or so.

When did Kubota rtv900 utility vehicle KISC issued?

1. WORKSHOP MANUAL UTILITY VEHICLE RTV900 KiSC issued 03, 2008 A 2. TO THE READER This Workshop Manual has been prepared to provide servicing personnel with information on the mechanism, service and maintenance of RTV900.

Why is my fuel pump not working on my ATV?

The engine crates a vacuum pulse to the fuel pump, which in turn creates an amount of pressure that pushes fuel into the carburetor. If you’re not getting good suction, try replacing the diaphragms in your fuel pump and make sure your vacuum lines aren’t cracked.

Where is the needle valve on an ATV?

The needle valve will be attached to the under side of the float, here is a picture of what you’re looking for. You can try cleaning the needle valve using carb cleaner. Just soak the thing and let it sit in carb cleaner for a few hours.

Why does my ATV run for a few minutes then stall?

As the engine heats up the coil looses its resistance and fails to deliver the charge needed to start the engine. Without bombarding you with technical numbers or making you buy testing equipment, I would simply run the ATV until it dies and pull the plug.

Why does my Honda ATV keep spewing gas?

We kept cranking it and bailing gas, and eventually, the ATV started, but after a couple of seconds more gas would start spewing, and it would die. We continued this until the gas stopped coming. All together, we probably bailed a gallon of gas out of the air cleaner housing. Now, it will start and seems to run fine without the air filter.

Is the air cleaner on my Honda ATV working?

Cleaned all again and put back together and it ran like a top, adjustment screw working idled good and no backfiring or stalling. before it was running very lean and was cold natured had to use the choke a long time until it got completely hot but not now. I drove it for 3 or 4 miles and all was good.

Where does the gas come from in a Honda rancher?

We have a 2005 Honda Rancher which has been running great. About 3 weeks ago, we noticed a gas leak on the floor. I looked underneath, and it was coming from the drain tube from the carburetor.

Why is gas spewing into the air cleaner housing?

I just pulled the carb again getting searching for a new bowl gasket or Kit whichever is available. going to get an inline clear fuel filter for the fuel line and clean the fuel tanks. All the vacuum vent tubes are clear. I’m concerned about the vent line on the fuel cap, if that isn’t working properly that may be an issue.

Why is my ATV not getting a spark?

You will find the proper steps for troubleshooting an ATV that is not getting a spark further down this post. If the spark plug is still dry after cranking the engine for a few seconds, you know that fuel, for some reason, is not getting to the cylinder.

How to start an ATV that wont start?

1 Remove the spark plug from the cylinder-head and connect it to the spark-plug wire or ignition coil. 2 Grab the plug wire and hold the plug about 1/8th of an inch away from the cylinder head. 3 Activate the starter. 4 As the motor turns, you should see repetitive bright blue spark arching from the spark plug to the cylinder head.

Why does my Kymco 450i UXV quit running?

A KYMCO 450i UXV ,gas is getting into the oil. I changed oil and it ran about 2 weeks and quit.This is a throttle body and I have no idea why gas is in the oil?Can you help.Thanks. , usually due to a leaking fuel line or malfunctioning fuel injectors.

How to fix a Kymco UXV 500 4×4 ATV?

Same problem with my mxu 500. Charged battery. Nope. Checked all connections in starting system. Nope. Swapped out solenoid relay. Fixed mine. Was cheap online- less than $20. Mine would start with jumper cables or batt charger on 80amp boost. Good luck! belt drive ? or chain. ? belt slipping ? sprocket on chain loose?

Why did my 2010 Kymco 500mxu shut down?

2010 kymco 500mxu irs shut down while riding. There is no power at ignition to attempt to restart. What fixed it? choke it ? gas not getting to piston air filter clogged ? Kymco mxu 250. With battery removed, and key on, what should ohmmeter read between positive cable and ground?

How old is my Kymco 700 4 wheeler?

My kymco 700 4 wheeler is stuck in park. Its about a year old. Try rocking quad toward and back while you try to shift out of park. I have 2005 kymco 250 mxu atv and can’t get spark has new coil,cdi, solenoid any help thanks…

Why is there no fuel in my gas tank?

If there is, then you have no problems getting fuel from the gas tank and it is probably a needle valve or float problem. If there’s no fuel coming from the tank down that fuel line, then you’re problem may be an issue with the fuel pump, if you have one, or an obstruction in the fuel line or shut off valve.

How can I Fix my gas pump nozzle?

Try rotating the pump’s nozzle so that it is more horizontal to the ground. Try it one way, if that does not work rotate it 180 degrees to the opposite direction. Some pump nozzles are a bit touchy and will sense any splash back from the gas tank. What really helps… only put the pump nozzle half way into the tank.

Where was the gas tank on my Honda ATV found?

My ATV was found dead in a barn after 3 years of sitting. It was a metal tank and I didn’t want to chance nuts, bolts, or chains. Also had hard angles in this old ’86 250 to wedge them in. So I took tank off and shook out all what I could from old fuel.

Are there any Honda 300 gas tanks left?

Only 5 left in stock – order soon. . . . Only 12 left in stock – order soon. . Only 4 left in stock – order soon. . Only 8 left in stock – order soon.

How do you clean a gas tank on a Honda?

I had a new gas line of 1/4″ hose and drilled out one end with a 5/16″ drill for the petcock side and blew it out w/ air hose. Installed the 1/4″ side of the hose to the filter. Other end went into existing hose for carb. Of which you will need a screw type hose clamp and maybe build it up a little with tephlon tape or something gas won’t eat.

What kind of car is a Honda ATV?

I just got my first ATV, a Honda Recon ES. It’s been sitting awhile, not sure how long. Don’t know the year even. I put a new battery in in, and it started right up. I drove it for about 1/4 mile, then it started to sputter, and backfired once or twice, and quit when I rolled up to the house.

What kind of truck won’t start or fire?

I have a 1997 Chevy Z71 just put new trans in drove for about 20 miles and the truck just died………Replaced fuel pump, Fuel relay and found that the fuel fuzz blows every time I turn key on ???? 24 people found this helpful. 22 people found this helpful.

What should I do if my engine won’t fire?

Check your CAS, i would say you have it one backwards if its been off, take it off spin the key 180* and bolt it back on to test that theory, sounds like its firing when the valves are open. Click to expand… Thanks for the ideas. Well, I will check that, but the CAS has not been off this car EVER.

What should I do if my ATV backfires?

If your ATV is backfiring, you should check a few of the common reasons: Depending on the cause, there are plentiful solutions to resolve this common occurrence. Again, it is important to recognize that this issue (backfiring) is relatively common with ATVs.

Navigation