What keeps the battery charged on a Polaris Ranger?
stator
The stator generates the electrical current your Polaris RZR relies on to charge the battery. Electricity is generated as AC voltage, and sent directly to the regulator/rectifier. There are two types of tests you should run to see if your electrical problems lie with the stator on your Polaris RZR 900S.
Can I put a car battery in my Polaris Ranger?
Get three battery cables from an electrical or aftermarket car part store so you can add a second battery to your Polaris Ranger. The third cable needs to have metal eyelets on each end.
What kind of battery does a Polaris Ranger take?
SLA / AGM spill proof battery has a characteristic of high discharge rate, wide operating temperatures, long service life and deep discharge recover. Dimensions: 6.60 inches x 4.96 inches x 6.88 inches….Specifications.
| Brand | Mighty Max Battery |
|---|---|
| Assembled Product Dimensions (L x W x H) | 6.60 x 4.96 x 6.88 Inches |
Why is the battery on my Polaris not charging?
My battery is not charging, i’ve tried some of the troubleshooting tips including checking the stator,loose connections and bad rectifier. The stator is fine since it will run without battery connected, no loose connections, and three of the four wires on the rectifier had fire (the fourth wire is a ground). Any ideas of what it might be.
How do I add a second battery to my Polaris Ranger?
Replace the bolt and tighten the nut. Reconnect the original red cable you removed from the existing battery onto the positive terminal of the original battery. The terminal is labeled “+.” Connect the opposite end of the cable you connected to the metal part of the Polaris to the negative terminal of the second battery using a wrench.
Can a Polaris stator run without a battery?
The stator is fine since it will run without battery connected, no loose connections, and three of the four wires on the rectifier had fire (the fourth wire is a ground). Any ideas of what it might be. Thanks for any help. Click to expand… May be a bad battery. I just had my sportsman in because everything went dead. Turned out to be a dead cell.
Why does my ATV battery keep going bad?
Red to the negative terminal and black to the negative.If you can’t reach above 12.4 volts by charging, your battery is likely too sulfated. If you can’t get it to charge over 10.5 volts you likely have a bad cell. Normal voltage reading with the engine turned off. Push the min/max button to start recording the voltage. Push the starter on the ATV.
Why is my Polaris Sportsman 500 not charging?
It’a a 2003 sportsman 500 h.o. I’v checked the battery while running with multimeter and the voltage doesn’t change. It has a brand new battery, i rode the other day and it cranked fine all day but when i got home i shut it off for about an hour and got back on it and it wouldn’t turn over, charged battery put it back in and it cranked fine.
The stator is fine since it will run without battery connected, no loose connections, and three of the four wires on the rectifier had fire (the fourth wire is a ground). Any ideas of what it might be. Thanks for any help. Click to expand… May be a bad battery. I just had my sportsman in because everything went dead. Turned out to be a dead cell.
Red to the negative terminal and black to the negative.If you can’t reach above 12.4 volts by charging, your battery is likely too sulfated. If you can’t get it to charge over 10.5 volts you likely have a bad cell. Normal voltage reading with the engine turned off. Push the min/max button to start recording the voltage. Push the starter on the ATV.
How can I tell if my ATV battery is fully charged?
Start by charging the battery. To perform this test you want to make sure the open circuit voltage available at the battery is above 12.4V (at least 75% charged). To check this you simply put your meter to DC voltage setting and connect the leads to the battery.