What causes a fuse to blow on an ecompressor?

Most likely a bad coil on th ecompressor- the 10 amp fuse is the only fuse to feed the compressor coil- unplug compressor- see if fuse still blows- if not- replace compressor or compressor coil- if it does blow- then check wiring hasrnes to compressor- most likely pinched in behind compressor when compressor was replaced…..

What to do when your AC is blowing fuses?

One other thing, to try for ha-ha’s, is swap the compressor relay with another in the fuse block (same number), and see if that solves your problem…… And one more thing to try….with the A/C running, with the palm of your hand, give the whole Underhood Fuse block at hit with the palm of your hand to see if the fuse blows….

Why does my AC blower trip the breaker?

This causes the blower to draw more electricity and trip the breaker. Solution: Change the air filter. Your AC system has an inside unit and an outside unit. The inside unit absorbs heat from your air using refrigerant. That refrigerant flows to the outside unit to disperse the heat.

Why does my AC keep Tripping the circuit?

A “grounded compressor” or “compressor short to ground” means that an electrical winding inside the compressor has broken and hit the side of the compressor. This causes a direct short to ground, igniting the oil and causing a burnout. And, of course, the circuit breaker trips due to the sudden current surge.

Why does the fuse keep blowing on my air conditioner?

The most common cause of the problem you are having is a defective A/C clutch relay. Which is why the fuse keeps blowing. The relay is located in the auxiliary relay box #1 (see diagram below).

Why does the fuse keep blowing on my Ford F150?

The most common cause of the problem you are having is a defective A/C clutch relay. Which is why the fuse keeps blowing.

What to do if your AC clutch fuse fails?

Turn the key on, turn the AC on and see if the fuse still fails. leave it sit for about fifteen to twenty minutes. If it fails then you have a wiring issue to the compressor. If it does not, then the ac compressor clutch is causing the high current draw and the compressor needs to be replaced.

When do you turn off the a / C compressor?

The A/C cycling switch is used for A/C compressor cycling. The switch is used by the PCM to turn off the A/C compressor before the line pressures are low enough to drop the evaporator temperature too low and freeze the condensation. An open in circuit 441 (RD/YE), 348 (VT), 883 (PK/LB), 295 (LB/PK), 347 (BK/YE), 57 (BK) or 321 (GY/WH)

Where is the 10 Amp Fuse under the hood?

The A/C keeps blowing a 10 amp fuse in the fuse compartment under the hood. When I replace the fuse, it blows in about 5 Keeps blowing..the fuse compartment under the hood..gauge reads…

What kind of AC is blowing hot all the time?

2007 Chevy LTZ 2500HD 4×4. AC is blowing hot all the time, 2007 Chevy LTZ 2500HD 4×4. AC is blowing hot all the time, compressor does engage but still blows hot. both lines at the firewall are hot not one … read more Vocational, Technical or Tra…

What to do if your AC fuse keeps blowing?

If you need help troubleshooting AC short-cycling or AC breaker tripping and fuse blowing in Maryland or DC, call 240-342-6910. You can also contact us online to schedule AC repair Call us at 240-342-6910 for an AC inspection or repair in the DC or Maryland area! Can I DIY Fix a Blown AC Fuse or AC-Related Breaker Trip?

Why does the fuse keep blowing on my car?

The fault could just as equally be a part of the vehicle wire harness rubbing on a sharp metal edge causing an intermittent short to ground in the circuit protected by the A.C. fuse. If you have no experience in electrical diagnosis then the best you can do is use your immediate senses.

Why does the AC fuse keep blowing?

There are many possible reasons for AC fuses to blow, and sometimes they are connected. Here is a list of some of the most common reasons: Old or Blocked Motor . An old or blocked motor causes the capacitor to work over-time. The capacitor is important because it helps run the cooling system, known as the condenser.

Why your air conditioner is blowing a fuse?

Another cause of blown AC fuses could be a low refrigerant level. Without the proper amount of refrigerant, your AC has to work harder to maintain its performance. Much like having a dirty air filter, this could cause your air conditioner to blow a fuse simply from overworking.

Why does car air conditioning keep blowing fuses?

There could be several reasons why air conditioner keeps blowing fuse in circuit board. The most probable of these are – 1. Loose Electrical Cables – There could be loose electrical cables inside the circuit box or somewhere in your AC which could be causing a short circuit.

Where is the air conditioning fuse?

The fuse and transformer are in the air handler, usually located in your attic. Fuse will look like an automotive fuse and may be on a circuit board. Post the make and model of your air handler so the pros can give better info. That is called a disconnect and has no fuses.

Why does my AC clutch fuse keep blowing?

If it fails then you have a wiring issue to the compressor. If it does not, then the ac compressor clutch is causing the high current draw and the compressor needs to be replaced. helpful?

Why is my AC compressor not turning on?

If the compressor isn’t starting, check the wiring connecting the two units. If it’s a blown fuse or tripped circuit breaker, the search has come to an end.

What should I do if my Clutch fuse keeps failing?

If the fuse keeps failing, then there is too much current draw on the circuit. The first thing I would do is to remove the connector from the AC compressor and leave it disconnected. Turn the key on, turn the AC on and see if the fuse still fails. leave it sit for about fifteen to twenty minutes.

Navigation