How can I get the SLK roof to open?
Please SLKer’s Does any one know who can help me overide the sensor so that the roof open or alligned all the joints and carnnies so that it autoamtically works, or is there another system i can install to open this roof. Mercedes are not helping on this… The SLK is no good to me if I cannot have the roof down during summer.
When did the SLK convertible top stop working?
I have a 1999 SLK 230 with a non-working convertible top. It worked fine for a few years (I’ve had it since Jan 2000), then it got to the point where when car sat in sun all day, the hardtop wouldn’t open until it cooled off.
Is the Mercedes slk250 glass on the roof?
I’ve just returned my 2012 SLK250 to Mercedes at the end of its lease and are looking to replace it with another one. I was lucky with the last one that I was able to factory order and decided to have the glass roof ( not the full colour changing one, but the cheaper glass roof panel).
Where is the microswitch on a Mercedes SLK?
The other thing to try is the microswitch on the right hand side of the boot. When you pull the screen over you will notice that where it clips into the rear of the boot, on the right hand side, it contacts a black lever. This in turn actuates a microswitch.
Why does my Mercedes Benz roof not open?
If so, a security feature is in place (i.e. the roof will not go down in order to break nothing, usually because a microswitch is broken). You’ll also need to check the oil level of the roof hydraulic mechanism, and that it itself is not damaged.
How to change the roof on a Mercedes?
Step 1: Locate access panel for the hydraulic convertible top cylinder (main). It will be on the passengerside corner in the trunk – next to the 6 disc CD Changer (which was taken out). Step 2: Lift the access…
What’s the best way to close a Mercedes SLK top?
Then a person on each side of the roof can lift it up and push it forward until the roof contacts the windshield. A 5mm hex wrench (check the toolbag in the trunk panel for one) is used in the headliner screw to reel the latches into the windshield and lock the top in place.
Why is my Mercedes SLK 230 roof not working?
With its multitude of limit switches and hydraulics, one glitch in the system can cause the roof to park itself in an unfavorable position. This presents problems, particularly if the roof is partially down. Vario troubleshooting can be challenging, due to the system’s pump, relay, and multiple switches.
What should I do if my SLK roof gets stuck?
The slk has a 30 second timeout that releases the hydraulic pressure allowing gravity to close the roof and trunk according to the manual if it gets stuck mid-cycle. Isnt that correct First thing you should do is hit the Wrench button and have someone walk you through the closing procedure with an assistant. The slk s roof should not be operated
How to replace trim plug in Mercedes SLK 230 Vario?
Pop the trim plug out of the headliner to reveal the manual latch screw. Turn the screw inPicture 6 with a 5mm hex wrench until the latches seat and the roof seals to the windshield (yellow arrow). Then replace the trim plug in the headliner.
What to do if your roof won’t open?
First make sure the roof hasn’t been ‘fixed’ into position. It might be locked in place by someone who screwed it into place using the method I explained above. So remove the tab on the top of the roof near the cabin light, and turn the screw around to see if you can free up the roof.
Is there a roof controller on a Merc SLK?
The merc slk has a roof controller that also runs the windows. When we repair these customers often have to reset windows simply by lowering windows right down and holding button down for 5 seconds or so then raising and doing the same. Basic I know but it usually works.
Why is the roof not working on my SLK?
There is a black “pull-out” tray in the boot. It has a handle on it, and is on runners. You need to pull this towards the boot lid, as the roof sits on this when it goes down. It the tray is not in place then the roof won’t operate.
Why does my Mercedes SLK window not go up?
If the window won’t go up and/or down during the adjustment session, the SLK’s Vario roof’s controller might be overriding the window switch. Try turning the key on and off. Also, check to make sure that the battery hasn’t drained.
What to use to fix SLK 230 window problem?
Need v strong epoxy glue – should be able to glue it back on with-out taking out the glass. Drop window down and remove speaker. I O, I O, its off to work I go!