Why does my Mercedes SLK roof not open?

Once the top is open, however, it will open and close that day with use of the button but it won’t open the next day after being closed all night. Detailed description of the problem: Press button, trunk opens, windows roll down, button stays lit (no flashing), hardtop will not unlatch from windshield.

When did the SLK convertible top stop working?

I have a 1999 SLK 230 with a non-working convertible top. It worked fine for a few years (I’ve had it since Jan 2000), then it got to the point where when car sat in sun all day, the hardtop wouldn’t open until it cooled off.

Why does my Mercedes convertible not go up or down?

Mercedes Convertible Top Won’t go up or down. Convertible top moves very slow. This can be caused by low fluid level or air in the hydraulic lines. Air in the hydrauilc lift cylinders. It can be caused by binding of mechanical arms. Weak convertible top lift cylinder. Weak battery or ground connection.

How to fix a leak in a Mercedes convertible?

Leak at the o-ring at any of the lift cylinders. Inspect in the trunk area for hydraulic fluid leak. Low fluid in the convertible top reservoir. Start by pressing the convertible switch. Do the windows go down? If the windows don’t go down, make sure the trunk compartment divider is pulled out. Next, check the fuse for the convertible top.

Mercedes are not helping on this… The SLK is no good to me if I cannot have the roof down during summer. I am really in a jam; I bought the car from auction and didnâ€™t know how important the alignment is due to some sensor.

Where is the microswitch on a Mercedes SLK?

The other thing to try is the microswitch on the right hand side of the boot. When you pull the screen over you will notice that where it clips into the rear of the boot, on the right hand side, it contacts a black lever. This in turn actuates a microswitch.

Why does my Mercedes sunroof not close properly?

Mercedes windows or sunroof does not close properly. MB window closes then drops an inch or a few centimeters. The express up or down (one-touch) feature does not work. Either the windows or the sunroof seems to require several clicks when closing or opening. How do you re-synchronize Mercedes windows? Close all the doors of your car.

Why is my passenger window on my Nissan 350Z not working?

I’ve read a few threads about the questionable window motors on the 350Z. I’m not sure if only certain model years fall victim to bad window motors, but I experienced my first issue in my 05 Z a few days ago. My passenger window simply stopped going up and down. It will not respond at all to either window control switch in the Z.

How do you close the windows on a Mercedes?

Close all the doors. With the key in position 1 or 2, push the window button until it is completely open. Hold the button for 5 seconds. Pull it up to close and hold again for another 5 seconds.

Why is my passenger window not opening or closing?

My passenger window simply stopped going up and down. It will not respond at all to either window control switch in the Z. However, I noticed that the “auto-seal” feature (slight lowering upon door opening, reseal window after closing door) still works.

What to do if your Mercedes Benz roof wont open?

Might not be something you wanna attempt on your own. But if you can pinpoint where the problem is, get a cheap shop to do just that part of the job. Tightening stuff won’t take them long and won’t cost you much. Basically the roof doesnt even sound like there is any current flowing through it.

Why is the roof not working on my SLK?

There is a black “pull-out” tray in the boot. It has a handle on it, and is on runners. You need to pull this towards the boot lid, as the roof sits on this when it goes down. It the tray is not in place then the roof won’t operate.

Why does my SLK boot not shut properly?

Same problem here on an R-Reg (98/99) SLK 230. Sounds very much like the striker depth needs to be adjusted – I will post progress to let you know… 1. Removed the pastic housing which restricts to the striker.

Why does my Mercedes Benz roof not open?

If so, a security feature is in place (i.e. the roof will not go down in order to break nothing, usually because a microswitch is broken). You’ll also need to check the oil level of the roof hydraulic mechanism, and that it itself is not damaged.

Why does my SLK 230 top not retract?

The most common failure is that the rear trunk lifts up and the top unlatches but it does not retract. The motor (pump) continues to run at this point. I would suspect the first switch that the rear lid hits because it is not saying “my trunk is out of the way, you can fold the top down”.

Where is the roof bar on a SLK 230?

It’s right above the roof motor, it’s a little peg a little over an inch long. When that is hit by the roof bar, it activates the next step. Second sequence, the roof detaches and moves into the trunk. This hits a sensor “somewhere” (bazzle?) and causes the trunk to lower again.

What is trunk open switch on Mercedes SLK 230?

The Trunk Open switch has a spring-actuated lever (arrow) that senses trunk position. Its housing can be opened with a flat blade screwdriver. The Trunk Open’s actual micro-switch (arrow) is either open or makes contact pending the lever’s position. The Trunk Lock Switch is part of the latch.

Why is the hood latch on my Mercedes stuck?

Your Mercedes-Benz hood latch may get stuck or sticks due to lack of lubrication. That is why it is important to keep the dirt off the hood latch and the hood release cable. The latch can get sticky due to dust, dirt and rust. The cable can also get sticky. There could be several reasons why the hood will not open.

What to do if you have a stuck hood latch?

In the video, 1A Auto shows how to open or release a stuck, jammed or rusted hood latch cable. While 1A Auto strives to make the information provided in this video as accurate as possible, it makes no claims, promises, or guarantees about the accuracy, completeness or applicability of the content.

Why is the lock on the hood not working?

Also at times, the lever might be working just fine but the cable that connects the lever to the lock of the hood could have gotten stretched, and the lack of tension in the cable prevents the release of the lock. » For both these problems, you would need to have a pair of pliers close by.

Why is the trunk latch on my SLK 230 not working?

Also, the pneumatic central locking system might have a glitch. If the key and lock button won’t open the trunk, the problem is likely mechanical. The connecting rod might not be seated correctly in the lock or latch, or maybe the latch mechanism itself is worn out. The latch is fairly easy to access and remove.

Why is the roof not opening on my SLK?

if the locks are unlocking but the roof does not lift when the boot is fully open then its most likely the switches in the roof. its really easy to take off the roof lining and remove ballows from switches giving full operation once again.

How can I open the hood with a broken latch?

Pull or press it and it should lift the hood 1 to 2 inches (2.5 to 5.1 cm) without completely disconnecting it from the latch. If you can’t find the hood release, look at the driver’s manual provided by your manufacturer. Either find the physical copy or look on their website for your car model’s manual in electronic format.

When did the Mercedes Benz SLK Class come out?

In this article, we consider the first-generation Mercedes-Benz SLK-Class (R170), produced from 1996 to 2004.

What kind of trim does a Mercedes SL have?

Filter Parts By Category Accessories & Styling Alloy Wheels, Bolts & Caps Audio/Telecommunications Body & Trim Mercedes 190 Series Mercedes A Class Mercedes B Class Mercedes C Class Mercedes CL Mercedes CLK Mercedes CLS Mercedes E Class (inc W123/W124) Mercedes G Class Mercedes ML Mercedes R Class Mercedes S Class Mercedes SL Mercedes SLK

Are there any problems with Mercedes SLK central locking?

Central locking problems in the R170 series of Mercedes Benz SLK are quite common. The issues are usually centred around the failure of the PSE (Pneumatic System Equipment) pump unit or its connecting air pipework. The pneumatic door lock actuators are simple by design and as a result are found reliable, even in older cars.

What kind of hardtop does Mercedes SLK have?

SLKs’ Vario retractable hardtops are probably their biggest single selling point. This impressive system coordinates switches, cables and hydraulics. However, the top can be a huge headache when it doesn’t work as intended.

Are there any problems with Mercedes SLK R170?

How much does a Mercedes Benz slk230 cost?

The average cost for a Mercedes-Benz SLK230 General Diagnosis is between $143 -$180. Learn More Went to put top up and the trunk partially opened and stopped in a frozen position. Tried switch again a few times, to no avail. Problem – how I going to drive home with a partially elevated trunk lid.

How to remove roof switch from Mercedes SLK 230 Vario?

It senses if the trunk lid is latched. The Trunk Closed switch bracket/cable release mechanism comes apart by using a T27 Torx bit. A small flat blade screwdriver can then be used to unclip the switch (arrow) from the rest of the assembly.

How to fix Mercedes SLK 230 Vario top manual closing proceedure?

Followup from the Pelican Staff: There is no single fix. You will have to confirm if voltage is OK to the module, if not, other erroneous fault codes may set. Start by checking power and grounds to the module, be sure to voltage drop test them.

Is the Mercedes-Benz SLK 230 Vario top an Achilles heel?

The SLK’s Vario power roof is probably its biggest selling point. This roof can also be the car’s Achilles heel. With its multitude of limit switches and hydraulics, one glitch in the system can cause the roof to park itself in an unfavorable position.

Why does my Mercedes slk230 not open the roof?

Main door windows will go down, mini side windows will go down and the trunk lid will open to accept the roof (and the internal lock turns to unlock the roof mechanism) but all it does from there is run the actuators and no roof retraction. It has not been fixed properly!

What’s the best way to close a Mercedes SLK top?

Then a person on each side of the roof can lift it up and push it forward until the roof contacts the windshield. A 5mm hex wrench (check the toolbag in the trunk panel for one) is used in the headliner screw to reel the latches into the windshield and lock the top in place.

What happens if you open the hardtop on a Mercedes SL500?

If either of these are open, the retractable hardtop cannot operate. Once the lid and cover are shut, the hardtop switch may be used. Start the vehicle’s engine, and let the car run while you open or close the hardtop. The hardtop does not operate if the car’s battery voltage is too low.

Is the convertible top on a 1999 SLK?

There are a bunch of DIY’s regarding the convertible roof in the “tech tips section” such as http://www.benzworld.org/forums/r170-slk-class/1292734-roof-switch-repair-rear-3.html I have a 1999 SLK 230 with a non-working convertible top.

Where do I get the roof switches on the SLK 230?

Money on the two roof switches on the front, you need to get the fault codes read, they come as part of the wiring loom, Click to expand… ummm okay part of the loom you say?? sounds expensive any solutions where do i get the switches?! Dont think its the dear, only from MB as far as i no!!!

What to do if your Mercedes roof won’t open?

If I release the button, get out of the car, firmly bump the hardtop near the glass on the passenger side, then press the button again, the lid retracts okay. One mechanic lubed the windshield latches several times, and it didn’t solve the problem.

Is there a problem with my SLK 230?

I have a 1998 SLK230 that has developed some top problems. The first and most common sign that I had was in putting the top down, the windodws go down, the back trunck raises, the top comes unlatched and then everything stops moving but the pump continues to run.

How many hydraulic rams are in Mercedes SLK roof?

This opens in a new window. I replaced the five Vario-Roof hydraulic rams and tried to shoot a video of the process at the same time. Looking for more video pros?

Where are the hydraulic cylinders on a SLK?

The Hydraulic Roof Actuating Cyliders (3) and the Hydraulic Cylinder for Lock Actuation (4) are located in the retractable top. The Hydraulic Roof Actuating Cylinder on the driver side was leaking hydraulic fluid; you can see the leak on the plastic panel in the SLK’s trunk. I would recommend rebuilding all five of the hydraulic cylinders.

Hello, have a look at this website, here is the link – SLK Home Page. It has a section on the roof mechanism, hope this helps, regards Damian. If the boot (trunk) lid’s not closed, the interior light will remain on. And I’m pretty sure that if the boot lid’s not closed, the top won’t operate either.

Why is the courtesy light not working on my slk200?

When you shut the boot you should now find that the courtesy light goes out and that the roof will now operate. It forms part of the vario roof control system in that it signals that the boot is shut since the vario roof can only operate when the boot is shut.

How does the sunroof close on a Mercedes?

How can I tell if my Mercedes SLK is reliable?

Check for any dampness in the footwells and carpets. Also, check in the boot underneath the spare wheel. It’s best to do it after rainfall. Open and close the roof a couple times to make sure that it works. The roof should take approximately 22 seconds to open or close. If it takes much longer than that, the pump may be on its way out.

Can a Mercedes Benz R171 roof lock cylinder fail?

If the car participated in a large crash, the roof may be out of alignment, which can be a nightmare to waterproof if the chassis of the car isn’t “straight” anymore. The hydraulic rams last only so long before the seals deteriorate and start leaking (15 years reliably at most as I see it). The roof lock cylinder is usually the first one to fail.

How long does it take to open the roof on a Mercedes?

Open and close the roof a couple times to make sure that it works. The roof should take approximately 22 seconds to open or close. If it takes much longer than that, the pump may be on its way out.

What to do if your SLK roof won’t open?

For the record to remove these bellows, one must remove the headliner. This is done by manually opening the top. There are a bunch of DIY’s regarding the convertible roof in the “tech tips section” such as http://www.benzworld.org/forums/r170-slk-class/1292734-roof-switch-repair-rear-3.html

How do you open the roof on a Mercedes Benz?

its really easy to take off the roof lining and remove ballows from switches giving full operation once again. when you push the button towards the rear of the car you should be able to look at the roof and see the locks move and hear them unlock.

How do you open the trunk of a Mercedes?

Locate the button on your Mercedes key featuring a picture of the rear of the car with the trunk open. Hold the button until the trunk opens. Unlock all the car doors, if you wish to open the trunk manually, by pressing the unlock button on your key or by unlocking the doors from the inside of the car.

Why is my Mercedes SLK 230 not opening the trunk?

If the key fob won’t unlock the trunk, the fob might need fresh batteries, or possibly the receiver, wiring or microswitch are faulty. Also, the pneumatic central locking system might have a glitch. If the key and lock button won’t open the trunk, the problem is likely mechanical.

What happens if you cant open the trunk of a Mercedes Benz?

Here are a few similar scenarios. The car battery has died and the battery is in the trunk. You locked the keys in the trunk and the battery is dead. Or you tried to manually unlock the trunk but can’t turn the key manually. So what do you do? Luckily, there is another way to power up your Mercedes-Benz.

How do you open the trunk of a Mercedes Benz?

You will need to slide the locking tab with your thumb and pull out the metal key. Step 2. Insert the key into the trunk lock cylinder. Step 3. Turn the key until you hear the trunk pop open. Note: Avoid jump starting your Mercedes-Benz by connecting the jumper cables directly to the battery.

What to do if your trunk latch is not working?

A non-functioning trunk lock/latch often requires getting into the trunk to fix the problem. The first Vario roof cycle might need to be actuated to open the trunk from the front.

What makes a Mercedes convertible top not go down?

Mercedes convertible top won’t go down or raise 1 Convertible top pump / motor defective 2 Bad convertible top relay 3 Low fluid 4 Defective divider microswitch 5 Transmission not in Park / Neutral 6 Switch at center console is faulty 7 Convertible top fluid leak Inspect in the trunk area for hydraulic fluid leak.

Can a failed ABS sensor trigger the Bas light?

If you have an ABS sensor that has failed, it will also trigger the ABS, ESP, BAS light. Because the ESP system depends on the ABS system to function properly, the ESP system will also get disabled.

Why is my Mercedes SLK Class not working?

If one of your car’s electrical accessories isn’t working a bad relay may be the cause. Learn to replace it with this tech article. If your headlights aren’t working after replacing the bulbs and fuse, it may be time to replace the headlight switch.

What to do if your SLK Class R170 has a leak?

Changing the SLK230 MAF sensor is easy with our handy replacement guide. Got a leak in your exhaust manifold? Fix it with this tech article. ABS warning light blinking?

When to replace water pump on Mercedes R170 SLK?

It may be time to replace your water pump. If your R170 SLK sounds like you’re seated next to the jet engine on an airplane instead of in a Mercedes-Benz driver’s seat, your wheel bearings might be bad. Prolong bearing life and eliminate gear whine with a rear differential oil change. Over time the power steering pump tends to fail.

Why is my blinker not working on my Turn signal?

A direction signal system is designed to operate with a flasher or blinker unit which interrupts the signal which created the blinking action. Learn more – Locate turn signal flasher in Google Images. Step 4 – When a turn signal switch fails the system will short or go “open” causing the blinker not to operate.

What does it mean when a Mercedes is stuck in Park?

Mercedes stuck in Park (P)and refuse to go to D or N. Stuck in D, R, N and will not move back to Park (P). Can’t remove keys from the ignition. Mercedes transmission won’t go into drive. Mercedes E, S, C, ML Class gear shift stuck in park. Mercedes will start, but transmission won’t go into gear.

Why does my Mercedes trunk not open by key fob?

Mercedes trunk will not open by key fob or interior swith 3rd brake light not working. EASY FIX!! – YouTube If playback doesn’t begin shortly, try restarting your device.

Can a trunk latch be removed from a Mercedes?

Once the latch is unbolted from the trunk, the wiring plug (blue arrow) can be uncoupled. The connecting rod slips out of the socket (red arrow). New replacement latch assemblies are available. If the mechanical mechanism works (actuated by the key in the lock cylinder), the latch’s microswitch might be bad.

In this article, we consider the first-generation Mercedes-Benz SLK-Class (R170), produced from 1996 to 2004.

Where is the fuse box on a Mercedes Benz SLK?

The fuse box is located on the side of the instrument panel, behind the cover (on the left in the LHD, on the right in the RHD)

How can I get the SLK roof to open?

Please SLKer’s Does any one know who can help me overide the sensor so that the roof open or alligned all the joints and carnnies so that it autoamtically works, or is there another system i can install to open this roof. Mercedes are not helping on this… The SLK is no good to me if I cannot have the roof down during summer.

What should I do if my Mercedes key fob is not working?

If you need a replacement battery note that Mercedes-Benz uses CR2025 battery type. Ensure you have new batteries in your key fob. Next, look carefully at your Mercedes-Benz key. When you press the button on your key you should see a small RED led light. The light should light up every time you press any of the buttons (Lock, Unlock, Panic, Trunk).

What causes a Mercedes convertible top to leak?

The majority of Mercedes convertible problems are caused by a bad relay, weak lift cylinder or lift cylinder leaking by the o-ring. If you find out that the convertible top reservoir is low in fluid that means that you have a leak most likely at one of the convertible lift cylinders.

This opens in a new window. I replaced the five Vario-Roof hydraulic rams and tried to shoot a video of the process at the same time. Looking for more video pros?

Where are the roof switches on a Mercedes Benz SLK 230?

Roof Locked Limit S69/2 Right Upper Windshield 170-820-09-10-MBZ $29.25 Roof Locked Limit S69/3 Left Upper Windshield 170-820-09-10-MBZ $29.25 Open/Lowered Limit S69/11 Next To Right Rollbar 170-820-12-10-MBZ $29.25

How is the Mercedes SLK 230 headliner held in place?

Regardless of the motivation for removal, the headliner is held in place by nine Phillips screws: three on the leading edge and three on each side. They’re all accessible by opening the top halfway. Once the top is partially retracted, remember to turn the key to its OFF position to depressurize the hydraulic system.

Where are the Phillips screws on a Mercedes SLK 230?

Three Phillips screws (arrows) retain the headliner’s front edge to the roof. Each side rail has three star screws (arrows). The rear-most screws are above the top’s cables. Once all nine screws are removed, the headliner can be lifted out.

What to do if your Mercedes key won’t turn?

If you have this problem you will have to install a new / virgin EIS. You can not install a used unit because the EIS has to be paired / married to the car using Mercedes-Benz Star Diagnostic Software. They key itself may be the reason why the car doesn’t start. The key may open the doors, but it will not start the car.

What are the common problems with Mercedes key fobs?

Common Mercedes Key Fob Problems Go to top 1 Mercedes key fob not working after battery change 2 Mercedes remote doesn’t work anymore 3 Keyless remote doesn’t lock/unlock the car 4 Mercedes key fob won’t unlock doors 5 Panic button doesn’t work 6 Trunk unlock doesn’t work

What kind of car is the Mercedes SLC 200?

The SLC 200 version of Mercedes’ baby roadster piles on the tech and cuts a more masculine dash. Jonathan Crouch checks it out. The Mercedes SLC is a useful development of the SLK model it replaces. Like that car, this one is an everyday-usable sports roadster that, like its arch-rival, BMW’s Z4, has a neat folding metal roof.

What should I do if my SLK roof wont open?

Tightening stuff won’t take them long and won’t cost you much. Basically the roof doesnt even sound like there is any current flowing through it. The light flashes when am driving the car and a beeping sound. When i press the button, notghing happens absoultely nothing. Click to expand…

Where are the hydraulic cylinders on a Mercedes SLK 230?

Its two-solenoid valves (the visible one is indicated by the arrow) distribute the fluid to the cylinders in a specified sequence to lower and raise the roof and trunk lid. The trunk cylinders (left side indicated by arrow) are in the rear corners, behind the side panels.

Why is my Mercedes SLK 230 roof not working?

With its multitude of limit switches and hydraulics, one glitch in the system can cause the roof to park itself in an unfavorable position. This presents problems, particularly if the roof is partially down. Vario troubleshooting can be challenging, due to the system’s pump, relay, and multiple switches.

Why is my convertible top not working on my Mercedes SL500?

Start the vehicle’s engine, and let the car run while you open or close the hardtop. The hardtop does not operate if the car’s battery voltage is too low. Wait 10 minutes before trying to operate the hardtop again.

What causes a Mercedes convertible to not move?

Mercedes convertible deck doesn’t move 1 Low fluid in the convertible top reservoir. 2 Deck lid lift solenoid defective 3 Deck lid micro-switch defective 4 Hydraulic pump not working 5 Soft top bow open/closed switch broken 6 Frozen or stuck mechanical arms or broken cable

What to do if roof wont close CLK 209?

Right now for the fun part, using the straps, wrap them round the hinges on the apron cover and back through them self’s. Lay them on the apron cover and close the boot.

Why is the roof on my Mercedes 209 stuck open?

209 ROOF STUCK OPEN/CLOSED. The main cause of this on the 209 is the window screen top micro-switch! On the driver’s side on top of the screen you will find where the roof latches down.

What kind of roof does a 2003 Mercedes CLK430 have?

MY2003 and earlier cabriolets are W208s, MY2004-MY2009 is a W209. One certain way to determine the problem is to have the diagnostic codes pulled on the soft top control module. This can only be done with SDS (official MBZ diagnostics). Click to expand… Thank you for your reply Rodney, its a 2003 Mercedes CLK430.

Are there any problems with my Mercedes CLK?

Just had my CLK towed away. Had the roof down today. No problems at all. Went to put it back up. Dead, just a warning message “Visit Workshop”. No noise no nothing. Just dead. Checked the fuses nothing wrong there.

What kind of fog light does a Mercedes Benz have?

Gl63 amg. Gl350 bluetec. Black housing. Daytime running lamp. Without amg styling package. Description: 1994 e500. 1994-95 e320, e420, e300 diesel. 1994-95, head, parking & fog lamps.

Why are the running lights always on in a Mercedes?

Daytime running lights, on the other hand, are typically always on for the sake of visibility of other drivers. When either of these lights are dim or out entirely, visibility on your end and for other drivers is lessened, and your safety is at risk.

Why does my Mercedes-Benz SLK 230 open backwards?

The trunk latch and trunk cover switches are the obvious ones, if they’re not engaged nothing will work, but you knew that, so skipping on… First sequence is the trunk opens backwards. This hits a sensor located on the passenger (US, so… right side).

Is the Mercedes SLK 230 Kompressor a good car?

For the current price, the Mercedes SLK 230 Kompressor is a great value, but before you buy, here is everything you need to know about the Mercedes-Benz roadster. The Mercedes SLK Roadster had its start as a two-seater roadster concept car that was based on the W202 C-Class.

How to open the roof in a Mercedes SLK R170?

➤Don’t forget to subscribe ! http://bit.ly/SubscribeJMSpeedshop➤Website: http://jmspeedshop.com➤instagram: https://www.instagram.com/johanmuter/this the firs… AboutPressCopyrightContact usCreatorsAdvertiseDevelopersTermsPrivacyPolicy & SafetyHow YouTube worksTest new features

Where are the switches on the R170 vario roof?

Other articles show how to operate the roof manually when necessary. Here, we reveal the locations of the nine switches in the R170’s Vario roof system. The actual switches are often part of larger housing assemblies. This permits the switches to be replaced independently, avoiding the higher cost of replacing the whole shebang.

Navigation