How to replace rear axle seal on Jeep Grand Cherokee?

This video shows you how to go through the process of replacing a leaking rear axle seal on a WJ (1999-2004) Jeep Grand Cherokee. This procedure would be very similar for many other solid axle Jeeps as well as many other vehicle makes and models. Loading…

What does it mean when rear axle seal is leaking?

You probably have already ruined the parking brake shoes on that side and if the seal is leaking it may mean that your wheel bearing has some play in it and should be replaced too. Which of course you might as well do both of them as well as the bearings in the diff, since the axles have to be pulled anyway.

Where do wheel bearings come from and what do they do?

Most wheel bearings manufactured today are sealed. They come from the factory pressed together as an assembly: front race, bearing set, center race, bearing set, and outer race, with seals on both the front and rear. Seals protect bearings from the elements, water, and debris, and they also seal in the high-temperature grease the bearing needs.

How much does it cost to replace a rear axle seal?

Also for a diff overhaul (just replacing bearings) your looking at 1200 +/- dollars between the new seals required, 4 bearings, gear lube, and 8ish hours labor, that would make that a little overkill as far as preventative maintainence goes.

What to look for if your axle seal is leaking?

If you are concerned about a leaking axle seal, here are 2 things to look out for: Oil puddle under car. One of the more common signs the axle seal is leaking is oil below your vehicle after it has been parked. Your driveway is one of the spaces you will notice the oil leak.

What is the purpose of an axle seal?

An axle seal is the part of the vehicle that connects the axle to the rear differential, or the transmission. The purpose of the axle seal is to keep transmission fluid from leaking.

How much does it cost to replace an axle seal?

$107.33 – $1,033.10. Price range for all vehicles. Average rating from 65 customers who received a Axle Shaft Seal Replacement. An axle seal is the part of the vehicle that connects the axle to the rear differential, or the transmission. The purpose of the axle seal is to keep transmission fluid from leaking.

What’s the best way to remove a rear axle?

Pull Tip: Always remember that the front axle needs to have the exact same gearing ratio as the rear axle. Most of the time you can find the gear ratio on a tag on the axle diff cover. Remove the Wheels and Tires. TIP – Using Penetrating Oil on all the nuts and bolts first will really help the process.

How do you release the emergency brake on a jeep?

Release the emergency brake cables by turning the nut with a 13mm ratcheting wrench until it becomes loose. Then use a ½” drive ½” 12 point socket to release the tabs and free the E-brake cables.

How do you remove the rear axle from a jeep?

If you forgot your penetrating oil at home use anything handy like transmission fluid or brake fluid. Remove the shock bottoms with a ¾” socket. Remove the rear driveshaft end from the axle with an 8mm socket wrench and a screwdriver to hold the shaft from spinning.

What kind of rear axle does a jeep WK have?

I know that the rear axle in the standard WK is supposed to be a semi floating version of the Chry/Corp 8.25. But ive also heard that its an 8.75 rear end. But it does NOT share any parts with standard 8.25 parts from XJ Cherokees or Dakotas etc.

What’s the rear end of a jeep Dakota?

But ive also heard that its an 8.75 rear end. But it does NOT share any parts with standard 8.25 parts from XJ Cherokees or Dakotas etc. So what do i look for when looking for parts such as an off road differential cover/gasket set (lub locker re usable gaskets) etc?

Is the rear axle seal leaking on my Jeep?

I have Appt with Jeep monday!!!Getting Driveline service plus seal done for $447 But its leaking slow…..so i’m taking it tomorrow just 300 miles to Colorado!! Am I missing something or where are you getting that it’s leaking on the wheel?

Do you need to replace the rear main seal?

Rear main seal replacement requires a certain knowledge of engine construction as well as how it is attached to the transmission. There are different ways of installing the rear main seal as well as the transmission, so car shops have to charge a little more as each rear main seal will be a little different.

How much does it cost to replace an engine seal?

Mechanical parts are the smallest cost of the job but can add up to your bill quickly. You may choose to change other seals or gaskets or do any sort of engine rebuild, and then the costs of the parts can easily be accumulated up to a few hundred dollars more, in your replacement bill.

Where is the main seal on a jeep?

The rear main seal is located in the back-most bearing cap. It’ll probably take a large breaker bar or impact wrench to get the bolts loose. The bottom half of the seal is in the bearing cap, and if it’s old like the one we were replacing,…

How much does it cost to replace a rear seal on a jeep?

But be prepared, as my uncle so aptly put it, this is definitely “one of the oiliest jobs possible on a Jeep.” New rear main seals are usually in stock at most auto parts stores, and seem to range from $13 to $15. At that price, you might go ahead and pick up two of them, just in case you mess up one seal during the install like we did…

What kind of seals do I need for my Jeep CJ?

From the windshield, to the cowl, doors and tailgate, we carry all the seals you need for your Jeep Wrangler, CJ, Cherokee and more. We’ve got just the seal you need whether you’re just replacing a single damaged seal or doing a complete overhaul on your older Jeep.

When to know if your transmission seal is leaking?

If you start to notice oil drops on your driveway, it could be a sign of a leaking axle seal. Transmission slipping at highway speeds. While an oil spot on the driveway is a common sign, it does not always happen because the axle seal leaks more during highway driving. Instead, you may notice your transmission slipping at highway speeds.

Do you have to replace rear axle seal?

Bearings must be replaced with the seal as there is no way to remove the old bearing without cutting it off, not to mention even if there was it would be less than smart to not replace it for no additional labor since your in there.

Is the rear axle seal leaking in Colorado?

I don’t know how far Colorado is from where you are now, but with the axle seal leaking bad enough that you have it on the tires, it might be better to just take your other Jeep.

How many axle parts does Jeep Grand Cherokee have?

We carry the largest selection of Jeep Grand Cherokee WJ Series Axle & Differential Parts around!

I don’t know how far Colorado is from where you are now, but with the axle seal leaking bad enough that you have it on the tires, it might be better to just take your other Jeep.

Can a bad wheel bearing cause a Jeep Grand Cherokee to lock up?

It is not recommended to drive your Jeep Grand Cherokee on a bad wheel bearing. They are dangerous. As they go bad they create heat. This heat can eventually cause the tire to lock up while going down the road. Replacing a wheel bearing is not that expensive, even if you take it in to a shop. Good luck diagnosing your Grand Cherokee.

How much does a Jeep Grand Cherokee shaft replacement cost?

Jeep Grand Cherokee CV Axle / Shaft Assembly Replacement at your home or office. Jeep Grand Cherokee CV Axle / Shaft Assembly Replacement costs $284 on average. Following is a breakdown of the labor and parts estimates. What are CV Axles and how do they work? All front wheel drive and all wheel drive cars use CV axles.

How can I tell if my Jeep Grand Cherokee has bad bearing noise?

Test Drive – The best way to diagnose bearing noise in your Grand Cherokee is to take it for a drive. You’ll be looking to hear the hum increase as the speed picks up.

How much does it cost to remove rear axle bearing?

If you cannot do that, you’ll have to have a shop do it (they will usually remove the old bearing for free and replace the seal). When I replaced both axle seals I took both rear axles to the shop (just as they came out of the housing) and they removed and replaced the collars, bearings, seals, and plates for $30/axle.

Can a shop remove a bearing from a jeep?

The easiest advice is to take it to a shop. You’re going to have to press on the new bearing and collar. If you cannot do that, you’ll have to have a shop do it (they will usually remove the old bearing for free and replace the seal).

Why is my axle seal leaking on my Jeep Wrangler?

Took it to the dealer for some other maintenance at around 36K miles and they told me my inner axle seals are leaking since my axle tube is wet and recommended that I replace it there. I didn’t. And when I change my diff fluid last night, the fluid level is still right at the bottom of the fill hole.

How can I tell if my front axle seal is leaking?

Look at the axle tubes by the knuckles, the rim and tires for oil spots, runs. Also look the spot you normally park at. Pretty easy to tell if they are leaking. the axle seal is covered under your 5/100,000 drive train warranty. have them do it. One thing about leaks is they don’t go away on their own.

Why is the front axle seal leaking on my Jeep Wrangler?

Since it was three years ago that you had the service done, it is doubtful that they screwed it up. The seal that is leaking is installed inside the banjo and the axel goes through it. If they screw it up, they usually pinch the seal lip and the leak is obvious from the get go. Hey’s your good luck wish.

How much does it cost to repair a front axle seal?

Only 43000 miles and never off road. Thought it should have last longer, but it still has to be repaired. The dealer said it is about a 3 & 1/2 hour job, and would cost $412 to repaired and that he would pay for the alignment which would have been another $59.

Where do I find the gear ratio on a jeep?

Most of the time you can find the gear ratio on a tag on the axle diff cover. Remove the Wheels and Tires. TIP – Using Penetrating Oil on all the nuts and bolts first will really help the process. If you forgot your penetrating oil at home use anything handy like transmission fluid or brake fluid.

What should it cost to repair right axle seal leaks?

Fixing an axle seal can cost anywhere from $150 to several hundred dollars, depending on the make and model of your car. If you detect a leak it’s better to fix it sooner rather than later, as ruining your transmission is an expensive repair.

What are front axle seals?

A front axle seal is a metal and rubber device used to not only prevent axle lube from seeping out of the axle housing, but it is also designed to prevent dirt, water and contamination from gaining access into the axle housing and contaminating the gear lube. Found in the front axle of a four-wheel drive vehicle,…

How does axle seal work?

Axle seals have two primary functions in the drive trains of cars and trucks. The first purpose of an axle seal is to keep gear oil from escaping. Without this sealing function, the gear oil would leak out and contaminate various components, such as brake shoes, and the transmission or differential could overheat.

What causes an oil leak in the rear differential?

This might be the effect but not might not necessarily be the cause of the problem. There are several quick checks you can do to see what the problem might be. For the rear differential pinion seal, which seals the input flange (connecting to the rear propshaft) from the diff internals, there is a possibility that the bearing is on its way out.

Where are the seals on a rear differential?

Some differentials put these seals just outside the bearings, while others have the seals all the way at the end of the axle tube. Due to different designs, your differential can leak from many different places making it difficult to determine the exact leak location. However, many people find that rear differential leaks are the most common.

What can I use to stop a rear main seal leak?

Whereas the Rear Main Sealer is less concentrated and specifically formulated exclusively for leaking rear main seals. If you are not 100% sure where the vehicle is leaking or there seem to be multiple leaks then we recommend using BlueDevil Oil Stop Leak.

Is it bad to add oil to rear main seal?

Many times the mechanics’ quotes for getting a rear main seal fixed are so high that it seems a better option to drive the vehicle and just add oil regularly to keep your car running. Here’s why that’s a bad Idea. While you are driving, the leaking oil will be distributed all over the bottom of your vehicle.

What kind of rear axle does a Jeep CJ have?

1976-1986 Jeep CJ with Model 20 Rear Axle. All Jeeps with T4 or T5 Manual Transmission. 1976-1986 Jeep CJ with Model 20 Rear Axle. 1976-1986 Jeep SJ & J-Series w/ Model 20 Rear Axle; 3.54 Ratio (39/11). 1976-1986 Jeep CJ with Model 20 Rear Axle.

What kind of steering shaft does a Jeep XJ have?

Jeep Cherokee (XJ) (1994-2001) with Power Steering; RHD. 1984-1993 Jeep Cherokee XJ without Power Steering. OEM Lower Steering Shaft Assembly for 87-95 Jeep?«

How much does it cost to replace a main seal on a jeep?

Replacing your rear main seal. Unfortunately, a leaky rear main seal is pretty common on the 4.0L motor found in most Jeeps. Getting it fixed at the dealership usually runs in the neighborhood of $500, however, if you’ve got a free afternoon, you can fix it yourself for under $50.

Why do I need new seals on my Jeep?

The seals on your Jeep help keep water, dust, dirt and more outside where it belongs, instead of getting into your Jeep where it can cause mold, rot and damage. Whether your Jeep is 5 years old or 50 years old, new seals can breath new life into your Jeep.

How do you replace the oil pan seal on a jeep?

Press the seal into the bearing cap to seat it firmly. Apply gasket maker to both angled edges of the bearing cap, then replace the bearing cap and torque the bolts to the specified torque. The oil pan is actually pretty clean in these photos, compared to what it looked like when we first pulled it out anyway.

How to fix and replace rear main seal and oil pan?

If playback doesn’t begin shortly, try restarting your device. Hello everyone I’m Mark. I make YouTube vehicle videos. A lot of cool and interesting material! Please check my channel out and subscribe!

What’s the best way to fix a jeep?

Please check my channel out and subscribe! Current Projects: Wrecked 2014 Ford F-150 SuperCrew 1966 Ford Mustang 2000 Jeep Cherokee XJ 2010 Ford Fusion Business Inquiries.. Don’t hesitate! [email protected] Find me on Instagram! @steadfast2277

What kind of rear axle does a Jeep SRT8 have?

Noone seems to have listings for parts for a WK rear axle when looking at web sites for these things. wkJeeps.com is not very helpful either. It only lists the name for the D44 in the SRT8. A couple people on JU have installed a locker in the rear diff. They bought a locker compatible with the 8.25 and it works.

What kind of rear axle does a jeep conquest have?

The only part that will work from a KJ/KK/XJ 8.25 that will fit a WK/XK 8.25 is the diff cover. Now I’m 99.9% sure that rear axle on WK is Corporate C213R, not conventional 8.25. Only diff cover from 8.25 will fit. Only one locker will fit to C213R axle. Also fits 8 3/8″ (8.375″) rear. I have been in this conquest as well.

Where can I buy 2006 Jeep Grand Cherokee parts?

MoparPartsGiant .com offers the lowest prices for genuine 2006 Jeep Grand Cherokee parts. Parts like Axle, Rear, With Differential, Housing And Axle Shafts are shipped directly from authorized Mopar dealers and backed by the manufacturer’s warranty.

Where can I get axle, rear and axle shafts?

Parts like Axle, Rear, With Differential, Housing And Axle Shafts are shipped directly from authorized Mopar dealers and backed by the manufacturer’s warranty. Parts fit for the following vehicle options. Engine: 6 Cyl 3.7L, 8 Cyl 4.7L, 8 Cyl 5.7L, 8 Cyl 6.1L.

We carry the largest selection of Jeep Grand Cherokee WJ Series Axle & Differential Parts around!

Which is the best shock absorber for a Jeep Grand Cherokee?

1. Bilstein B6 4600 2. Old Man Emu (OME) Nitrocharger 3. RANCHO RS7000MT 4. Opt for Rachno RS7000MT shocker 5. King Off-Road Racing Shocks 6. KYB Shocks 7. Rough Country N2.0 8. API shock absorber 9. Sachs Absorbers 10. Mopar shock absorber 11. Monroe Shock Absorber – Rear 12. Unity shock absorber 13. Detroit Axle – pair shock absorbers 14.

Is the rear axle the same as the front axle?

It is definitely not an 8.75. I think the key is to have either QT I or II. No electronics in the diff in those axles to mess with the operation of a locker. The actual diff in WK’s are all the same, it is just the diff in QDII equipped WK’s has an electronic locker.

When to change the axle on a jeep?

However, many jeep owners still believe swapping a new, beefier axle is more cost effective and better. As a general rule of thumb, most owners agree that once a jeep has been modified to run 32″ or 33″ tires, it is time to start thinking about upgrading the rear dana 35.

What kind of axle does a Jeep Wrangler have?

TJ Wrangler:1997-2006 Rear 3.73 ratio Dana 44 optional on Sport and Sahara models, also standard on X model Rocky Mountain Edition. 2003-2006 Rubicons also come with 44’s front and rear, and the rear Dana 44 has been an option for TJ’s for quite some time.

Navigation