When to replace timing belt on Volvo 850?
CAUTION: Failure to replace a faulty camshaft timing belt may result in serious engine damage. The condition of camshaft drive belts should always be checked on vehicles which have more than 50,000 miles. Although some manufacturers do not recommend belt replacement at a specified mileage, others require it at 60,000-100,000 miles.
When did the first Volvo 850 come out?
The 850 also introduced side impact airbags to the world. On top of all that, Volvo’s first dip into high performance vehicles came with the T-5R 850 in 1995, their turbo version of the 850.
What kind of maintenance does a Volvo 850 need?
1993-96 MAINTENANCE Volvo Maintenance Information 1993-96 850 Sedan 1994-96 850 Turbo Sedan 1995-96 850 T-5R Turbo Sedan 1994-96 850 Wagon 1994-96 850 Sportswagon 1995-96 850 T-5R Turbo Sportswagon * PLEASE READ THIS FIRST *
What kind of oil does a Volvo 850 use?
F (-20 C) Volvo oil (P/N1161001-1) (2) – DO NOT use Dexron fluid in manual transmissions. (3) – Use low pressure grease gun to prevent seal damage. (4) – Fill until lubricant squeezes out from the base of seals. (5) – Fill ball joint until seal starts to swell. FLUID CAPACITIES FLUID CAPACITIES TABLE
What do I need to know about my Volvo 850?
For specifications pertaining to fluid capacities for the entire vehicle, fuse and circuit breaker identification, wheel and tire size, battery type, warranty information, or model identification refer to the MAINTENANCE INFORMATION article in this section. NOTE: See the AIR BAGS article in the ACCESSORIES/SAFETY EQUIPMENT Section.
When does service interval change on Volvo 850?
These designs are often called “Free Wheeling”. Many manufacturers changed their maintenance and warranty schedules in the mid-1980’s to reflect timing belt inspection and/or replacement at 50,000-60,000 miles. Most service interval schedules in this manual reflect these changes.
What kind of Grease do you use on a Volvo 850?
Dielectric Silicone Grease (1) – At temperatures below -4 can be used. F (-20 C) Volvo oil (P/N1161001-1) (2) – DO NOT use Dexron fluid in manual transmissions. (3) – Use low pressure grease gun to prevent seal damage. (4) – Fill until lubricant squeezes out from the base of seals. (5) – Fill ball joint until seal starts to swell. FLUID CAPACITIES
How long does it take to replace timing belt?
Please try again later. Timing belt, tensioner, and rollers replacement: 3 to 5 hours, with water pump 4 to 7 hours. Vehicles with hydraulic tensioner. NOTE: New water pumps have a thinner casting than the old pumps. You should get new water pump bolts if replacing an original water pump.
What kind of car is a Volvo 850?
1995 Volvo 850 1993-96 MAINTENANCE Volvo Maintenance Information 1993-96 850 Sedan 1994-96 850 Turbo Sedan 1995-96 850 T-5R Turbo Sedan 1994-96 850 Wagon 1994-96 850 Sportswagon 1995-96 850 T-5R Turbo Sportswagon * PLEASE READ THIS FIRST *
What’s the problem with my 1993 Volvo 850?
Just the little annoying things that can drive you nuts trying to resolve if you don’t know the cause and where to begin fixing it. Beginning with the 1993 850 Volvo began using an upper engine mount (also called the upper engine stabilizer) that helped to control engine movement especially during acceleration.
What are the most common problems with 1993-2000 Volvos?
All 1993-2000 850, S70, C70 and V70 models (as well as most 2001 2007 S60, S80, V70 and XC 90 models) use a complicated crankcase vent system to prevent the build u of pressure inside the engine. Since the mid 70’s Volvo owners have had problems with this system clogging up with oil deposits.
What causes an ignition switch to fail in a Volvo?
Hall Switch Distributor Connector Distributor R&R and Shaft Seal Replacement Engine Hesitates When Humid Distributor Shaft Wear Ignition Amplifier (Power Stage) Failure Engine Cuts Out; Tach Drops Failure to Start; Flywheel Sensor Bad Timing Unstable; Harmonic Balancer Failing
How to change ignition system on Volvo B234?
B234 Engines [Jeff Saeger] Removing the cap and rotor with nearly zero clearance: Remove the wires from the cap; this gives more room and allows space for the screws to clear the head when the cap comes off. Make a drawing or mark so you get them back on correctly.
Where can I get an ignition system for a Volvo?
Go to your electronic junkbox, or the local electronics workshop, or to Radio Shack. Get: A neon bulb, NE-2 About 15′ of light-gauge stranded wire (insulated, of course) An alligator clip A collection of heat shrink tubin Connect a 3-4′ piece of wire to one lead of the neon bulb. Insulate the solder connection with heat shrink.
What happens if your timing belt is broken?
While a broken timing belt is bad and costs a lot more money than it would have cost to maintain the belt, it is by no means, a catastrophe or the end of the engine. The only thing that happens when a timing belt breaks is a few valves get bent.
Is there a valve cover on a Volvo 5 cylinder?
There is no such thing as a “valve cover” on a Volvo 5 cylinder engine. There is the spark plug cover and then there is – to steal from the Porsche vernacular – the Cam Tower which is the upper half of the casting that holds the cams.
What are the p80 and P2 timing belt intervals?
Late P80 and P2 official timing belt intervals from Volvo documents DID YOU KNOW? Volvo innovation is the reason kids get to ride in cars. That’s not to say that safety hasn’t served the brand well. Volvo was first to market with three-point seat belts, side-curtain airbags, and blind-spot monitoring.
Do you still have a timing belt on your car?
If you have an older car from the 90s and below, odds are you have a timing belt. Some new car manufacturers, such as Audi, still use timing belts in their engine designs, but for longevity, many manufacturers have switched to metal timing chains that in theory last for the life of the engine.
What happens when your timing belt gives up the ghost?
Your engine’s timing belt is the most important maintenance item in your car. What happens when this component gives up the ghost, and how hard is it to fix by yourself? What Is A Timing Belt? A timing belt is the ribbed belt that is placed in a specific configuration along one side of your engine to keep the crank and camshafts timed properly.
How does the knock sensor work on a Volvo 850?
Knock sensor detects knocking and sends signal to Motronic or ignition ECU. ECU is able to gradually retard ignition timing to each individual cylinder. If knocking does not stop, a signal is sent to fuel injection ECU to enrich air/fuel mixture.
When to open EGR valve on Volvo 850?
EGR Solenoid Valve When engine coolant temperature is less than 115 F (45 C), solenoid receives no current and EGR system is inactive. With engine at operating temperature, solenoid receives current from relay and opens vacuum line to EGR valve. EGR valve is opened completely by negative pressure.
What kind of engine does a Volvo 850 have?
850 non-turbo models use a Bosch LH 3.2 multiport fuel injection system with a EZ129K electronic ignition system with knock sensor, and with self-diagnostic capabilities. Vehicle uses an Electronic Control Unit (ECU) that receives input from engine monitoring sensors.