What kind of climate control servo do I Need?
FITS THE FOLLOWING: 116, 107 and 123 Chassis up to 1980 ONLY with heater servo, including the 450SL 280SE 300SD 300D 240D. For use to convert 1977 to 1980 automatic climate control servo to a manual system.
How to connect a PIR sensor to a servo?
GND pin to the Negative railings of the Bread board. After implementing the connection of the PIR sensor let’s connect the servo motor.
When do you close the water valve on a Volvo?
[Response] Vacuum to close the water valve is only applied in max AC mode or when the MCC temperature selector is fully cold. This varies according to the type of control system in the car (MCC, ACC, ECC) and the Volvo OEM service manual should be consulted for details of vacuum signals.
Why is my air conditioner working backwards on my Volvo?
The heater water valvehas a blockage restricting flow and may be in need of replacement; You have a vacuum leak which causes the heat vent control to work improperly; Your firewall-side heater water valve was installed backwards; The arrow on the valve points to towards the firewall inlet, not back towards the engine.
[Response] Vacuum to close the water valve is only applied in max AC mode or when the MCC temperature selector is fully cold. This varies according to the type of control system in the car (MCC, ACC, ECC) and the Volvo OEM service manual should be consulted for details of vacuum signals.
Why does my Volvo Car leak when I use a / C?
There is a boot that seals the side that yellow hose applies vacuum to and when this boot goes bad it leaks when you use a/c or floor settings. It is a HARD job to replace this diaphragm unit. It requires removing a lot of under dash parts and ducts and then standing on your head to reach two extremely hard to get at nuts.
The heater water valvehas a blockage restricting flow and may be in need of replacement; You have a vacuum leak which causes the heat vent control to work improperly; Your firewall-side heater water valve was installed backwards; The arrow on the valve points to towards the firewall inlet, not back towards the engine.
Where is the defrost unit on a Volvo?
This rear connection has been known to leak. Leaking Sound from Under Dash. That vacuum leak is almost certainly your floor/defrost diaphragm. It is on the left side of case just above the accelerator pedal. This diaphragm unit is double acting, i.e. it has vacuum to pull it both ways, blue hose for defrost and yellow for floor.