What does it mean when your Volvo transmission says service required?
If you drive a Volvo, don’t be surprised if you get a warning message such as “transmission service required,” “transmission service urgent,” or a gear symbol with a “Service Required” message. Along with this error, you may also experience harsh shifting between gears or transmission stuck in ” Limp Mode .”
What is the fault code for a Volvo transmission?
Common fault codes are TCM-002A, TCM-002B, P0733, P0734. If your Volvo transmission hesitates to shift gears, it bangs into gear; the problem could be the B4 servo.
Why is my Volvo transmission not working properly?
This was a new feature aiming to increase fuel economy. While it barely improved your fuel economy, it caused excessive wear in the first gear clutches. Volvo’s fix to this problem was to update the software for the Transmission Control Module (TCM). The update disabled the neutral feature.
How often should you change the transmission fluid in a Volvo?
Even if your Volvo owner’s manual states that the transmission fluid is sealed for life, our recommendation is to change the transmission fluid and filter every 60,000 miles. Volvos may develop hard shifting or slippage due to the Transmission Control Unit (TCU) software issues.
Can a transmission filter be changed on a Volvo?
Change transmission fluid and filter Even though Volvo may state transmission is sealed for life, you can extend the life of your transmission by doing a transmission filter and fluid change. Doing transmission service will often improve the shifting quality. Make sure to use the recommended Volvo transmission fluid.
Is it safe to drive a Volvo with an automatic transmission?
If you are experiencing problems with your Volvo transmission, take a minute to become familiar with these problems. Volvo makes some of the safest cars on the road, but on the other hand, Volvos are known to have problems with their automatic transmission.
How can I tell if my Volvo transmission is bad?
Volvo first starts to manifest transmission problems by hesitating to engage or take too long to change gear. As the problem gets worse, you will notice a bang or hard shifting between gear. If you ignore the problem for too long, the car will go into Limp Mode and get stuck in one gear.
How can I restore the transmission in my Volvo?
Unfortunately you need a special tool to operate the violet plastic sliding cal latched that retain the TCM in the box. If you remove the TCM and clean the terminals with electrical contact cleaner, and work the latch back and forth several times to scrape off the oxidation, function will be restored at least temporarily.
Can a low transmission fluid level cause a problem?
If your Volvo transmission fluid level is even slightly low, it can cause problems such as transmission slipping or engine revving up when you slow down, transmission banging into gear, etc. Here are instructions on how to check Volvo transmission fluid level.
How to check the transmission fluid in a Volvo?
Here are instructions on how to check Volvo transmission fluid level. Drive the car for at least 15 minutes. Manually shift the gears between 1, 2, 3, 4, 5 during your warm-up drive. Park the car on a level surface. Set the parking brakes and place the shifter in Park.
What to do if your transmission is bad?
If you remove the TCM and clean the terminals with electrical contact cleaner, and work the latch back and forth several times to scrape off the oxidation, function will be restored at least temporarily. Another possibility is a bad PNP switch on the trans.
What do the warning lights on a Volvo mean?
Description: This warning light comes on due to a fault in the emissions system. Often referred to as the ‘check engine’ warning light or the MIL (malfunction indicator light), it may come on constantly or flash. ▷ Constant: You can continue driving.
Why does my Volvo have a gear ratio problem?
TCM-002A Incorrect gear ratio in third gear. Volvo transmission issues date back to the early 2000s Volvo models. Transmission Control Unit (TCU) software is to blame in many cases, but problems with the valve body, shift solenoid, worn clutches, transmission overdrive relay can also be the culprit.
Is there an issue with my Volvo S60 T20 automatic?
Volvo S60 T20 automatic, 2002 with 115,000 miles covered. Service history unknown. I have an issue with the transmission, namely that I have an error message stating ‘Transmission service required’ with an accompanying orange engine service light.
What are the scheduled service plans for Volvo?
Volvo Scheduled Service / Maintenance Plans: Volvo S60, V60, XC60, S80, V70, XC40, XC70, S90, V90, XC90, V40 – 2013 on – Servicing D2, D3, D4, D5 2.0 Diesel Drive-E Engines – Scheduled Plan
Can a software update save a Volvo transmission?
If the software update were performed early on, it would save your Volvo transmission. If the update was not carried in time, internal transmission wear could have developed to the point that a complete transmission overhaul or replacement is necessary.
What is the maintenance plan for a Volvo D5 engine?
If your car is an older D5 engine (engine code D5244T and D5244T2) or a 4 cylinder Diesel engine, check our Volvo Maintenance Plans List for the correct plan. All the information in this article is in accordance with the Servicing Schedule Plan specified by Volvo.
How often should a Volvo d5244tx engine be replaced?
Additionally every ten years or 180.000 kms / 108.000 miles, schedule service interval: 1. If D5244Tx engine: Replace Outer Auxiliary belt and belt tensioner, Replace Inner Auxiliary belt and belt tensioner, Replace Timing belt, belt tensioner and idler pulley.
When does the transmission go to fourth gear?
The transmission is fine for about 10 or fifteen miles then reverts to a ‘dash’ instead of the gear reading ‘D’rive, ‘4’fourth, ‘N’eutral etc. If in ‘D’rive this generally leaves me in fourth gear as it seems to usually downshift to fourth from Drive, but not always.
What happens when you neglect a service light?
The driver must respond to the issue as soon as possible and resolve it. If the driver neglects a service light, such as the “BOOK TIME FOR MAINTENANCE” or “TIME FOR REGULAR SERVICE” light, he or she runs the risk of damaging the engine – or worse, ending up stranded on the side of the road or causing an accident.
What to do if your Volvo clutch is not working?
Volvo’s fix to this problem was to update the software for the Transmission Control Module (TCM). The update disabled the neutral feature. If the problem existed for a long time, the clutches might wear the point that a complete transmission overhaul is required. Replacing the valve body can sometimes fix the problem, but this not a guaranteed fix.
What to do if your Volvo has intermittent electrical problems?
Getting the CEM module replaced by the dealer costs $1000+. A cheaper solution would be to repair your existing module. Remove your existing module and send it for repair to a facility that offers Volvo CEM Module Repair on eBay. A CEM module (or corroded connections at CEM) trigger intermittent electrical problems.
Is there a fix for condensation in Volvo headlights?
Volvo Fixes & Advice since 2001. Condensation in Volvo Headlights? XC90 3.2 V8 Transmission Flush, Incremental, or Don’t Touch? Nothing left to load.
Where is the alarm system required on a Volvo S60?
When faced with the “Alarm System Service Required” message on the dashboard of a 2000+ Volvo S60, S80, or V70, the problem is almost always the siren module, a device located behind the front bumper cover on the on the passenger side of the vehicle, just behind the wheel well.
Do you know what transmission service actually mean?
Most of us are aware that our transmissions, like our vehicles as a whole, need regular service and maintenance. But we usually do not think about our transmissions unless there is a problem. And then, even when somebody does take the time to explain what transmission service entails, we may not be able to fully understand them.
What kind of Inspection does Mister Transmission do?
Any half decent garage will include an inspection as part of their regular transmission service. But at Mister Transmission, we pride ourselves on our multi-check inspection. We methodically check the different parts of your transmission to make sure everything is running at peak levels.
What does it mean when transmission fluid is clear?
The fluid check indicates the first sign of possible wear and tear. A clear red fluid shows that a transmission is in good working order. If the fluid is discolored or has unpleasant odour, this is usually an indication of internal wear and damage. If so, an internal inspection is required.