Are there any problems with the Mercedes Vito?

Questions about Mercedes-Benz Vito Answered One of the common problems to occur with the Mercedes-Benz Vito is failure to start. This can be attributed to many reasons. It may take a fair amount of troubleshooting to arrive at the exact cause.

Why does the Mercedes Vito go into limp mode?

Why does the Mercedes Vito van (112 CDI 638 chassis) go into limp mode after climbing over a long hill or while under load? The vacuum transducer and turbo pressure sensor were changed. There are a variety of reasons which can result in the Mercedes Vito engine going into a limp mode.

What causes soot build up in Mercedes engine?

Wrong engine oil can cause excessive soot build up. Luckily, the regeneration process can be initiated manually, using an appropriate diagnostic tool. In most cases, this will purge a clogged DPF. Mercedes, like many diesel cars, uses a DPF Exhaust Pressure Sensor to determine how much does the DPF restrict the exhaust flow.

When did the Mercedes Benz BlueTec diesel come out?

Mercedes-Benz introduced the OM642 V6 BlueTec diesel in 2007. A few years later they introduced the OM651 4 cylinder BlueTec diesel. BlueTec refers to the type of diesel emission system.

Can you say 3 cold starts and 2 Hot starts?

After a cooling period of 30 minutes at rest another starting sequence of two (2) successive starts shall be permissible….. Can I say above clause means Three (3) Cold starts and Two (2) Hot Starts of motor?

What kind of heater does Bluetec diesel use?

DEF heater is another known weak points. All Bluetec vehicles use Diesel exhaust fluid, also known as AdBlue. It is stored in an external tank, and it would freeze in cold weather. To prevent this, DEF tank is equipped with an electric heater which can burn out.

Common Mercedes Vito ECU faults are. Start Error ( Immob Problem! ) If you need any help with these situations please contact me to save yourself alot of time and money! Sometimes you don’t need to change all of the ECU/WSP/Key if its only the ECU at fault!!:thumbsup:

Why does my Vito CDI 110 2000 shut off?

Hi My Vito CDI 110 2000 has Shut off Fault Code, Boost Pressure Code. 7.5a ECU Fuse causes grey smoke rough running when inserted. Merc Star Can not communicate with the CDI. Van starts and runs ok without the 7.5a fuse but in limp mode. Help.

Why is the EDC light always on in my Vito?

The wires in question run from a plug attached to something on the left had side of the engine (as you look at it) down by the alternator up to the wiring loom which runs across the rocker cover, not sure quite where they go to. Click to expand… Me too, i have same problem, EDC light always on.

Why do Mercedes W115s have different gear ratios?

This is because the yoke/flange are of a different size. You could also swap out the cardanshaft/driveshaft to one with the right size yoke, if you for example are building a tuned w115 and need something beefier than the stock flexdisc

In the following overview, you will find the most common problems for the Mercedes-Benz Vito / V-Class, for which Mercedes-Benz has announced a recall through the EU Rapex system. For recalls and faults found in the UK scroll down. If the problem is corrected in time, it may not affect the overall reliability of your Mercedes-Benz Vito / V-Class.

What are the symptoms of a Mercedes Vito gearbox repair?

The first warning symptoms of a potential Mercedes Vito gearbox repair being needed are a judder on a light throttle and judder or stalling when coming to a stop in the Mercedes Vito. Avoid expensive repair costs, does your Mercedes Vito judder on a light throttle or when coming to a stop?

Can a Mercedes van be repaired at Stephens?

In the Stephens Engineering workshop we have recently seen a number of Mercedes vans brought for gearbox repairs; we recently carried out a Mercedes Vito gearbox repair. As with the Mercedes Sprinter, the most common gearbox fault for the Mercedes Vito vans is torque converter failure.

What are the most common problems with Mercedes Benz cars?

8 Most Common Mercedes-Benz Problems 1 Rust. Rust behind license plate / trunk area. 2 Engine Mounts. Engine mounts on Mercedes-Benz cars are oil filled. 3 Suspension & Steering Components. Ball joint / front control arm. 4 Window Regulators. Broken window regulator on Mercedes C-Class. 5 AirMatic Components. …

Why is the gear box on my Vito so weak?

Ok so with out being so negative I found the gear box on the Vito to be a weak box. I changed the oil on the box and added a gear box treatment and this worked very well infact instant result.

How to remove the spare tire on a Mercedes-Benz Vito?

What is the procedure to remove the spare tire on the Mercedes-Benz Vito AA3CDI? To remove the spare tire on the Mercedes Benz Vito, first the retaining nut needs to be undone using a wheel nut spanner. Typically there are two nuts beside each other. One needs to be removed only a little while the other needs be undone completely.

Mercedes-Benz Vito Problems 1 Alternator difficulties with 2013 Vito. Show the dealer your record of reports and battery replacements to back up your claim and request a goodwill payment to cover the cost of 2 Valuation for 2004 Mercedes-Benz Vito van. 3 Save the heartache. 4 Disco dilemma. 5 A wheelchair conversion. …

Do you need a van for a Vito?

SOUNDS like you need a van. The European vans are way ahead of the Japanese rivals in every aspect except price. They can be tricked up with all sorts of accessories that can look very cool. The Vito is worth considering, as are the VW Transporter and the Renault Trafic.

Is the Mercedes-Benz microbus witch the same as the Vito?

Mercedes-Benz Viano interior – Second generation. At first many Vito drivers who wanted a spacious, small van opted for the Vito microbus witch was extremely similar to the Viano, apart from its more van like and less luxurious features. The Viano was however a good, more car like option to the Vito microbus.

Is the starter on my Vito van working?

Starter Works Fine And When The Van Was Running It Was Running Fine .it Started To Take A While To Start And This Just Got Worse Over A Few Days Till It Would Not Start At All.

Can a Mercedes-Benz Vito CDI 110 start?

There is no way of priming the van and it is not self priming, as long as the diesel filter is full of fuel the van will start. Is the EDC light on ?. Is the battery good ?. Have you read the codes with a scanner? if so what are they. 1 x 190e, 2 x vito cdi 110 many spares…. still the vito wont start…..

Why is the EDC light still on in my Mercedes Vito?

The glow plugs have current for the heat up process and then there is no currnet to them after a couple of seconds so performing properly but the light remains on. Two of the injectors were “chuffing” so I recut the seats, new copper washers and bolts and that appears to have fixed that problem but the EDC light remains on.

Why does my Mercedes Benz Vito not start?

It turned out to be a broken wire to the injector. If the edc light is on then it will not start because it thinks there is a fault either with the wiring, air in the fuel, water in the fuel or lack of fuel pressure. Got my Vito back yesterday.

Are there any problems with the Mercedes Vito ECU?

Similar problem with the bas brake assist, had it diagnosed, replaced g force sensor and brake sensor, as that what fault codes came up, reset it, but light is back on!! Spent allot of money on original parts, and it is still the same, could it be the ECU it’s self?

What are the relays on a Mercedes Benz Vito?

CDI, oil sensor, fuel temp sensor,CMP sensor, water temp sensor,rail pressure sensor,Crank position sensor,4 injectors, high pressure pump shut off valve, rail pressure control valve, fuel shut off valve. The only other relays are to do with lights ect ect More Fuel Problems…

What to do if your Mercedes Sprinter has turbo blown?

If you suspect in any way that you may have turbo issues STOP the engine and check it out, as to continue running the power unit could easily cost you a complete engine and not just a turbo repair on the Mercedes Sprinter / Vito diesel engines (Including those derivatives utilised in Mercedes passenger cars.) You have been politely reminded!

How to fix a Mercedes diesel power loss problem?

For more info and related products: https://mercedessource.com/problems/f… Kent explains what he did to fix a persistent power loss problem on an old Mercedes Diesel. Once he took the fuel cap off the fuel tank he had a pretty good idea what the problem was. And this one happens more often than you would think.

What happens when Mercedes diesel engine is not running?

As Mercedes DPF traps and holds soot, with time it reaches a point when it needs to be ‘emptied out’. This is done by regeneration. During this automated process, engine computer rises exhaust gasses temperature over 630°C. This burns up soot particles. However, if the engine is not running correctly automatic regeneration will not be started.

What makes a Mercedes Sprinter van go wrong?

These complicated systems are largely what go wrong on a Mercedes-Benz Sprinter van. Sure, on the outside they look simple, tough, and low maintenance. But when you get to know them better, you find that they are needy and require a lot more attention than you thought.

Do you need special socket for Mercedes diesel?

A special 32 pt. Socket is REQUIRED but is NOT included – see description and related products below if you do not already own this tool. Only fits models listed. NEW! Kent’s 2019 video instructions included free of charge. Always check engine compression either BEFORE or RIGHT AFTER purchasing an older Mercedes diesel (before is better of course!)

How big is the Mercedes-Benz Vito panel van?

This second generation Vito panel van, with its wedge-shaped front, eye-shaped headlights and gently sloping roofline, is offered in three load lengths – compact, long and extra long. The first two sit on a standard wheelbase of 3,200mm but the largest model gets an extension between the wheels to 3,430mm.

What to do if your Mercedes Benz won’t start?

If these sensors are damaged or disconnected, the car will refuse to start. As noted above, a battery replacement will frequently solve this problem. To determine whether or not your problem is with the battery — without going to the expense of buying a brand new one — use another car to jump start your Mercedes.

Starter Works Fine And When The Van Was Running It Was Running Fine .it Started To Take A While To Start And This Just Got Worse Over A Few Days Till It Would Not Start At All.

What do you need to know about the new Mercedes Vito?

To view these, consent is required for cookies and data processing by YouTube, as well as for advertising purposes. Welcome to the team – the new Vito. With intelligent assistant systems, new connectivity services and powerful engines, it will make every ride safer, more efficient and more comfortable. Great job. The new Vito.

What to do with a Mercedes Vito camshaft?

Try using easy start to start it one morning give it a spray and then turn it over. if it goes then it could be as simple as the fuel line seals but could also be the fuel pumps. If you need any other help check out Your one stop shop for all your mercedes vito New and Used parts and spares or give me a shout on the number on the site Mark

Why does my Vito 109 05 not start?

I have a vito 109 05 plate I. Went on a road trip ..starting running fine ..called at a friends ..about ten mins n then put key in all sounded good turn key engine trying to star but wont any idea’s please people as I have no idea Click to expand… So the starter motor is turning the engine but the engine not starting?

What should I do if my Mercedes Sprinter has no vacuum?

Once good vacuum supply has been determined, with the ignition off (no power to the valve and no vacuum present) the route of vacuum should be blocked by the valve to the turbo actuator.

Is there a problem with the key on a Vito 109cdi?

The only problem is that when I push the key into the barrel nothing happens it does not do it all the time though! I have to remove the key from the barrel and push it in the barrel hard, several times. On some occasions it has taken me 5-10 minutes before the key has worked.

What kind of torque does a Mercedes Vito have?

Most businesses though, will need a van more easily able to deliver both, so will be looking closely at the two more powerful four cylinder Vito diesel options, the 136bhp 113 CDI or the 163bhp 116 CDI, these variants offering either 310 or 360 Nm of torque respectively and able to sprint to sixty in as little as 11.1s.

How tall is the Mercedes Benz Vito roof?

Around town, it’s also helpful to note that with an overall height of just 1.90m, every version of the Vito with a standard roof should fit easily into a regular garage, limbo beneath the height restriction bar in multi-storey car parks and sail through car washes unscathed. And over bumps and around corners?

How old is a Mercedes Vito CDI Van?

Mine is just nearly 5 years old and although ive just had a full paint there was no rust under the paint only dents from the previous owner. Also as for the engine again treat it right and all modern engines should give a least 200k without much chew.

Are there Vito vans that are 100% the same?

Our company purchased circa 12 Vito vans from MB Brighton and ALL were to be 100% the same, specs, etc. to replace a fleet of Hyundai ILoads. When delivered, they were various years, some of which had a VIN # 2 years earlier than others. Some had rust, side windows, etc. They were ALL various configurations. Worst of all was the resale/trad…

Ok so with out being so negative I found the gear box on the Vito to be a weak box. I changed the oil on the box and added a gear box treatment and this worked very well infact instant result.

Who are the repeat buyers of my Vito?

My Vito is atypical of the reputation that MB Vans have in this country – and they’re regarded as now intruding right into the japanese/korean small van market. They have the highest repeat customer base and dominate fleet buyers such as Police, Ambulances etc…

Are there any mechanical problems with the Mercedes Vito?

No rust (and it’s been through the tropics). No mechanical problems. some dicky electronics (fog lamp switches and erratic alternator dashboard light after 8 years + an faded odometer light ). It’sbeen driven around australia and at one stage was doing round trips of 3600km every week. It never missed a beat.

Is the Vito a small van or a Big Van?

Sorry, buit I find throw away comments like that just don’t stand up to basic tests of rigour. My Vito is atypical of the reputation that MB Vans have in this country – and they’re regarded as now intruding right into the japanese/korean small van market.

Why are the indicators on my Mercedes not working?

My indicators stopped working today, hazard lights were OK. Checked fuse 5 (OK), changed it with new, rotated in fuseholder, still not working. Switched on hazard, switched on indicator, hazard off and indicators keept going. Indicators have been working since. Have anyone else had the same experience, explanation ? The wiring diagram is attached.

What are the fuses on a Mercedes Vito?

Registration plate illumination, day-driving light relay, headlamp cleaning system relay, passenger compartment illumination, radio (term. 58), all control switch illumination, tachograph (term. 58) M111 and OM601 (main wiring harness/taxi console II connector for term.

What kind of wiring does a Vito w638 have?

M111 and OM601 (main wiring harness/taxi console II connector for term. 58) Registration plate illumination, relay K71 (term. 58), trailer socket (term. 58L), left taillamp and side light Anti-theft alarm system (ATA), ATA control module (term. 30) Control module (term. 15) for ABS and pneumatic shock absorption, ASR, EBV

How long has the Vito 116 been on the road?

Six months and around 6,500 miles simply flew by, with never a hint of a problem. I haven’t even had to put any extra air in the tyres, or oil in the engine, although I did have to spend £9 on AdBlue when the rather diminutive tank ran low.

Is the Mercedes-Benz Vito 116 Sport Sat Nav?

It’s now month four of our six-month sojourn with the Vito Sport and, as with most of our long-termers, there are a couple of gripes we have found along the way, although they are small compared with our general admiration of this classy performer. First, I am not keen on the Becker sat-nav units that Mercedes-Benz puts in its vans.

Navigation