What kind of oil goes in the rear end of a ezgo golf cart?
Ezgo recommends 30wt oil for the Dana rear end in your cart. You can use an equivalent synthetic oil too.
How do you replace an axle oil seal?
To replace the seal, take the following steps:
- Jack up one side of your truck to take the weight off the wheel.
- Remove the wheel.
- Remove the axle shaft.
- Remove the hub retaining hardware.
- Slide off the hub and drum as a unit.
- Replace the seal behind the hub.
- Put everything back together in the reverse order of removal.
How much does it cost to replace a shaft seal?
Axle Shaft Seal Replacement Cost – RepairPal Estimate. Labor costs are estimated between $196 and $247 while parts are priced at $40. This range does not include taxes and fees, and does not factor in your specific vehicle or unique location.
What is 30wt oil?
Lucas 30 WT Plus is designed to lower oil temperature and slow oil consumption. Lucas 30 WT extends the life of engines in race cars, lawn equipment, farm equipment or any other situation where a superior 30 WT oil is needed.
What type of gear oil goes in a golf cart?
Of the 3 major makers, EZGO, Club Car, & Yamaha, only CC gas carts use 80-90 gear oil. All the rest use 30wt motor oil in the differential.
How do you change a differential seal?
- Using fresh gear oil, place a thin film around the entire circle housing where the seal will be installed.
- Place the seal on the differential.
- Place the seal installation tool flush on the new seal.
- Using a hammer, hit the end of the installation tool straight until the seal has popped into place.
How much does it cost to replace a rear diff seal?
Rear Differential Repair Costs Most seals and bearings are relatively inexpensive on their own. Combined with the few hours of labor required for their replacement, the typical rear differential cost of repair is between $200 and $400.
How much does it cost to replace a rear main seal?
The rear main seal usually costs between $600-$900, with a service fee of around $550 to $820 out of the overall replacement charge.
How often do you change the differential oil on an E-Z GO?
The differential in an E-Z-GO golf cart is located on the rear axle and allows power to be distributed to both rear wheels. The company recommends changing the differential oil once every five years. When changing the oil, it is recommended to clean the differential with rags and check for leaks to make sure the gasket is still good.
What kind of oil do you put in an EZGO?
The service manual calls for 30 weight oil but a lot of guys use 90 weight gear lube. There’s a EZGO steering box diagram in the EZGO resource section of the forum.
How do you change the differential on a golf cart?
Park the golf cart on flat, stable ground. Apply the parking brake. Place wheel chocks in front of and behind the front wheels. Use a jack to lift the rear of the golf cart. Secure the rear end with jack stands. Place a pan under the differential.
Where is the differential located on an E-Z GO?
The differential in an E-Z-GO golf cart is located on the rear axle and allows power to be distributed to both rear wheels.