Why does my Polaris Sportsman 500 not turn on?

No Electrical Power when Key is turned. New Battery I recently had a battery die on my 2012 Polaris Sportsman 500 HO. When that dead/dying battery was in place, the lights would power on dimly while the key was on, and I would hear a clicking sound while trying to start it, but it would not turn over.

How do you change the key on a Polaris Sportsman?

See an authorized Polaris Dealer for assistance. For Outlaw 50, Outlaw 90, Outlaw 110, Sportsman 90, Sportsman 110, and Phoenix 200, the required key can be determined by the direction of the key groove. Groove is determined when holding the key, ready to put into the ignition.

What to do if you lose your Polaris key?

If your key has a groove on the right-hand side, use key blank 0453143. If your key has a groove on the left-hand side, use key blank 0453372. Polaris only offers key blanks that can be cut using an existing key. These key blanks will need to be cut to match an original key. If both keys have been lost, you will need to replace the ignition.

Where do I find the Polaris 4000 ignition key?

To identify which series the key is, locate the four digits on the original key as shown below. For 4000 series blanks, reference all four digits stamped on the original key. If both keys have been lost, you will need to replace the ignition. See an authorized Polaris Dealer for assistance.

Why does my ATV have no power when I turn the key?

When I installed the new battery, I didn’t noticed that there were two positive cables that need to be connected to the positive terminal. One of them had slipped back into the boot, and I only connected the other one. This is why the ATV had no power at all when I was turning the key.

Why does my Polaris ATV have no power?

One of them had slipped back into the boot, and I only connected the other one. This is why the ATV had no power at all when I was turning the key. Once I noticed this, I hooked up both positive cables to the terminal and everything works fine now.

How to start a Polaris Ranger 500 UTV?

• locate the starter relay, start by following the big cable from the + terminal of the battery as it always ends up tied to 1 of the 2 big terminals of the starter relay/solenoid; • jump the 2 big terminals of the starter relay using an old wrench or screwdriver.

Where is the Kill Switch on a Polaris?

The Kill switch is in the run position, the fuses in the fuse box under the front storage box look good. I’m not sure where to go next. I’m not all that mechanically or electrically inclined.

Where is the voltage regulator on a Polaris ATV?

I can’t seem to find any info on the voltage regulator in the shop manual. it is located under your pod behind front compartment behind that colored plastic cover it is a little silver rectangular box with two terminals with wires on them with a stud and nut. im pretty sure mine was mostly wrapped in black tape from factory

Start at the battery and work your way to the fuses with a volt meter when it reads no juice you back up one and this should be the issue. Main fuse blows=no power. I did something silly when I put my new battery in and did not get all of the pos wires connected to the battery. I had actually hooked on of them to the neg side.

Where are the electrical wires on a Polaris ATV?

I had actually hooked on of them to the neg side. Up front next to the computer are 2 black wires that are coming from the left side of the battery opening with a terminal connecting the 2 together and it has a red shrink wrap on the terminal make sure that you put it on the pos side.

The Kill switch is in the run position, the fuses in the fuse box under the front storage box look good. I’m not sure where to go next. I’m not all that mechanically or electrically inclined.

How to reset the service wrench on a Polaris Sportsman?

Select the service interval function by holding the “Mode/Reverse Override” button for three seconds until the service wrench icon begins to flash. Set the next service interval by holding the “Mode/Reverse Override” button to advance the next service interval in one-hour increments.

What to do if your Polaris has no power?

Check battery and selenoid connections, take cables off of selenoid and check nuts under them for tightness. Always check the kill switch first. It is easy to bump it over, and hard to think about checking it first. We’ve all done it. It totally kills ALL power to every system.

How do you reverse override a Polaris Sportsman?

Press and hold the “Mode/Reverse Override” button and turn the ignition switch on. Release the “Mode/Reverse Override” button once the speedometer display has fully activated. Press the “Mode/Reverse Override” button to scroll through the menu functions on the display until you have reached the service interval function.

Are there any problems with the Polaris Sportsman 450?

Polaris Sportsman 450 H.O Power Steering Problems. While heading down the trail, it’s possible to experience a complete loss of power steering. Don’t take our word for it; the company issued a recall. Recall number 17-740 discusses how the ATVs have malfunctioning electronic power steering systems. When this malfunctions, the crash risk increases.

What to do if your Polaris Ranger wont turn over?

Turn on key and ‘silence’. It will occasionally start, allow me to get a block or 2 from the house,then the gear selector lights go out, and the engine dies immediately. I’m tired of towing it back to the house.

What kind of power does a sportsman 500 have?

My 07 sportsman 500 has no electric at all.no lights, no winch no starting power, nothing. The Battery is new and in good shape.

What kind of engine does Polaris Sportsman 500 have?

The Sportsman 500 was so well-loved, despite some minor flaws such as the lack of power steering, clutching, and power. Engine – The 2000 Polaris Sportsman 500 uses a four-stroke, liquid-cooled single-cylinder SOHC engine. It has a bore-stroke ratio of 92 x 75 mm (3.622 x 2.953 inches).

Why are the circuit breakers on my Polaris Sportsman not working?

The issue ended up being one of the electrical connectors going to the left handlebar assembly. The circuit breakers on this four-wheeler are used instead of fuses. It is common for moisture to corrode the circuit breakers and cause similar electrical problems on these Polaris ATVs.

What’s the price of a 2000 Polaris Sportsman?

These 2000 Polaris Sportsman 500 values do not include accessories outside of package inclusions. Average retail prices for both trims range from $1,445 to $1,710, with low retail value at $1,100. Customarily, auction listings and trader sites sell the ’00 models at $1,500.

What happens to the battery on a Polaris Sportsman 500?

No Electrical Power when Key is turned. New Battery | Polaris ATV Forum No Electrical Power when Key is turned. New Battery I recently had a battery die on my 2012 Polaris Sportsman 500 HO.

What happens when the lights go out on a sportsman?

Lost all electrical power no lights, no starter nothing ,battery has full charge on a 2003 500 sportsman machine was running when lights went out and lost all power . It will start and run manually. How do I trouble shoot ?

What are the codes on my sportsman 500?

Trying to find answers to codes on my 2008 Sportsman 500 EFI HUD and fuel gauge flash ; codes count as 1-3-6-1 . Trying to trade down an answer to the codes

Why does my sportsman 500 not start with a key?

I started it to plow the other day, drove around, turned the machine off for a couple of minutes, went to turn it back on and nothing. Not even a click at the solenoid. I pull started it and it worked fine. The interesting thing is the next day I tried using the key and it fired right up. But ever since that time, no luck with the key.

Can a DC ignition be added to a Polaris Sportsman?

But in doing a little research, we found an update from RM Stator that would convert our problematic 2003 Sportsman 600 to a much more reliable DC ignition at less than half of the price of the Polaris upgrade kit.

What is the RM stator Polaris Sportsman upgrade?

The RM Stator Polaris Sportsman upgrade consists of a new CDI and a remote coil, all required wiring, and installation instructions that allow pretty much anyone to get the job done without professional help. This kit uses the heavier windings of the lighting coil to power the ignition.

When to see a Polaris dealer for a problem?

If there are defective spark plugs or no spark is going to them, then the spark plugs should be inspected and replaced as necessary. For three other potential problems (a clogged fuel filter, water/fuel in the crankcase or mechanical failure), Polaris recommends that owners see a Polaris dealer.

When did the Polaris Sportsman 500 come out?

Founded in 1954, Polaris Industries first began manufacturing ATVs (all-terrain vehicles) in 1985. This gave the company over 25 years of ATV experience when it released a new model of the Sportsman 500 for 2011.

Why does my sportsman 90 starter not turn over?

The neutral/reverse lights come on and the brake light works. I’ve disconnected and reconnected most every electrical connector I can reach, but still no luck. Anyone have any idea what might be causing this problem? I’m thinking it’s got to be a loose connection or possibly the regulator, but I don’t know how to test the regulator.

What should I do if my sportsman 500 wont start?

Registration is fast and you can even login with social network accounts to sync your profiles and content. 2008 Sportsman 500 EFI w/ key on, no lights/ won’t start… has new battery? Need help start… Forward 4×4 works fine but only 2 wheel when shifted into reverse.

My 07 sportsman 500 has no electric at all.no lights, no winch no starting power, nothing. The Battery is new and in good shape.

Do you need to replace the ignition key on a Polaris Sportsman?

For 4000 series blanks, reference all four digits stamped on the original key. If both keys have been lost, you will need to replace the ignition. See an authorized Polaris Dealer for assistance.

What is the key blank on a Polaris ATV?

If your key has a groove on the left-hand side, use key blank 0453372 . Additionally, you can tell which key blank you need by checking the number on the key tag attached to the original key ring. If the first digit in that number is odd, you need key blank 0453143. If first digit of the number is even, you need key blank 0453372.

For 4000 series blanks, reference all four digits stamped on the original key. If both keys have been lost, you will need to replace the ignition. See an authorized Polaris Dealer for assistance.

What to do if your Polaris wont start?

Must see repair. – YouTube If playback doesn’t begin shortly, try restarting your device. Videos you watch may be added to the TV’s watch history and influence TV recommendations. To avoid this, cancel and sign in to YouTube on your computer. An error occurred while retrieving sharing information.

Where is the battery on a Polaris Sportsman?

Put the key in the “Off” position.” Locate your battery. It’s often located behind a plastic panel up high at the front of the ATV. But it may also be found in less ideal places, like on this Polaris Sportsman 570, where the battery sits exposed on the bottom of the frame. On some ATVs, it may even be at the rear of the bike.

Why are there no lights on my Polaris ATV?

I did have lights, but no power to the pod. The issue ended up being one of the electrical connectors going to the left handlebar assembly. The circuit breakers on this four-wheeler are used instead of fuses. It is common for moisture to corrode the circuit breakers and cause similar electrical problems on these Polaris ATVs.

How to test circuit breakers on a Polaris Sportsman ATV?

It is common for moisture to corrode the circuit breakers and cause similar electrical problems on these Polaris ATVs. I’ve seen quite a few people in the forums asking where these circuit breaker bags are located as well as how to test them. Click here to subscribe http://bit.ly/ngdysub1 and don’t forget to select the notification bell!

Are there too many problems with Polaris machines?

Way too large of a percentage of the problems people have with Polaris machines are electrical failures of one kind or another.

What to do when the gauges on your Polaris ATV stop working?

Simply put a splice wire between the brown wire at the high beam connector (just shove a bared end of a splice wire into the back of the connector) and to ground and you will be amazed, everything will work. Then just tie in a section of wire from the headlight connector to ground, and it will be fixed.

Where is the brown wire on a Polaris ATV?

The wire on the Cluster your looking for is a brown wire, not the black (black is power), it is at one of the ends of the rows of wires and of course was the very last wire I tested. This seems to be a common problem, I already fixed a few of my friends bikes, this fix was good all the way through 2007 sportsmans.

What are the components of a Polaris Sportsman 500?

The most common components are capacitor, resistor, and battery. Additionally, there are other components like floor, switch, motor, and inductor. All of it depends on circuit that is being assembled. According to previous, the traces at a Polaris Sportsman 500 Wiring Diagram Pdf represents wires. Occasionally, the wires will cross.

Why does my sportsman 500 have no power?

I have a 2007 Sportsman 500 EFI with under 100 hours of use. I am now having a random electrical problem. I have no power when I key up the quad. The kill switch is in run, turn the key on and most of the time nothing happens (Like a dead battery).

What should I know about the Polaris Sportsman ignition?

The problematic section of the stator is no longer used, and the new secondary ignition coil is isolated from the CDI in contrast to the integral coil/CDI that comes from the factory. The result is more reliability, better spark, and easier diagnosis should you have another problem in the future.

Why is my Polaris Sportsman 500 not starting?

First, there may be low battery voltage, and owners should try to recharge the battery to 12.8 VDC. Two other problems may be that there are loose connections on the battery or on the solenoid. In either case, owners should check and tighten all connections. If the engine turns over but will not start, it is possible that the ATV is out of fuel.

What should battery voltage be on Polaris Sportsman 500?

If the engine runs irregularly, stalls or misfires, it is possible that there are dirty or defective spark plugs, which must be inspected, cleaned or replaced accordingly. It is also possible that there is low battery voltage. The 2011 Scrambler 500 battery must be charged to 12.8 VDC.

When did the Polaris Sportsman 500 Ho start?

I keep a 2009 Polaris Sportsman 500 HO up at the farm. Since there was very little snow this winter, I used it on every visit up until January. I tried to start the machine the first week of February and she wouldn’t start.

Why does my Polaris engine not turn over?

Not Turning Over If the engine does not turn over, Polaris suggests three potential problems and solutions. First, there may be low battery voltage, and owners should try to recharge the battery to 12.8 VDC. Two other problems may be that there are loose connections on the battery or on the solenoid.

How do you finish a Polaris Ranger bar?

You can finish out the bar by adding battery power and a ground to the remaining terminals with at least a minimum of 8ga wire. Put a circuit breaker in the positive wire as close to the battery as possible. Then you can start hooking your accessories directly to the bar. 😀

When do you crank, sparks when START button released?

Pickup coil. Cranks and cranks then sparks 1 light spart when starter button is released. Did you replace the pickup coil? If not, do so. If yes, did the old one and the new one look exactly the same?

How did I get a spark on my sportsman 500?

By some miraculous happening i had a spark one day after it had sat in my garage for a week or more & i was able to start it on the pull as we had burnt the starter out but it was missing & back firing a lot. All of a sudden it cleared & revved like a good un but what had i done?

What’s the price of a 2005 Polaris Sportsman 600?

2005 Polaris Sportsman 600 Twin pictures, prices, information, and specifications. Below is the information on the 2005 Polaris Sportsman 600 Twin. If you would like to get a quote on a new 2005 Polaris Sportsman 600 Twin use our Build Your Own tool, or Compare this ATV to other Utility ATVs.

Are there any Polaris Sportsman lights left in stock?

Only 3 left in stock – order soon. . . Only 1 left in stock – order soon. . Only 10 left in stock – order soon. . . Only 9 left in stock – order soon. . Only 17 left in stock – order soon.

Navigation