When to replace timing chain on 04 Touareg?
I have a 04 Touareg V6 with about 110,000 miles on it. The check engine light came on about 8 months ago and at that time the deal recommended replacing the timing chain for $7,100. the car ran great so we ignored the light.
Where is the upper tensioner on a Touareg V6?
Not uncommon to hear some rattle at initial start up until the oil pressure picks up. The chain tensioners operate by hydraulic pressure. The upper tensioner is on the outside of the back of block on the passenger side. Behind and below the throttle body. It looks like a bolt, think 22mm.
How do you replace a timing chain on a V6?
You can unscrew the tensioner, clean, re-prime the cylinder and reinstall. The tensioner is essentially a bolt with a hollow cylinder and piston and spring. It has a very small hole for oil to enter the cylinder and push out the piston against the chain guide to tension. Just bought a new one because mine was out of plumb with the cylinder.
Why does my V6 engine management light keep coming on?
I too had a 2006 3.2 V6, and the engine management light kept coming on after a day or two, and my garage were of the opinion that the timing chain had stretched, and that this was causing the problem.
Do you need a timing chain in a VW?
Some cars do not have a timing belt, though. Some Volkswagens, for example, have a timing chain instead. So what then is the distinction between timing belts and timing chains?
What should I do if my timing chain goes bad?
Keep your engine well-oiled, and your timing chain can last up to 300,000 miles. If you suspect your timing chain may be going bad, come see our expert European Auto technicians at A&M Auto Service, convenient to Pineville, Charlotte, and Greensboro, NC.
What kind of timing belt does a Mazda 3 have?
Here is a list of timing belts and timing chains for a Mazda 3. Reference the model year with the corresponding engine to see if your car has a belt or a chain. .
Is there a timing belt on a Saab 9-3?
Here is a list of timing belts and timing chains for a Saab 9-3. Reference the model year with the corresponding engine to see if your car has a belt or a chain.
When to replace the timing chain in a VW?
If your car is making rattling, whirring, whining, or buzzing noises, your timing chain may be coming loose. You may notice a lack of power in the engine and trouble starting your Volkswagen. These noises are all signs that you should replace your timing chain.
Is there a timing belt on a V6?
There is no timing belt in these engines. There is NO specified interval for replacing the chain / no prevenative replacement required V6 TDI – are driven by timing CHAINS. There is no timing belt in these engines. There is NO specified interval for replacing the chain / no prevenative replacement required
Is the timing chain on the Volkswagen EA888 defective?
Settlement for Defective Timing Chains and Engine Failure. Volkswagen’s EA888 2.0-liter engine has a history of tensioner problems that can lead to a loose timing chain and catastrophic engine failure. A series of lawsuits eventually led to a settlement that offers an extended warranty and potential reimbursements for owners.
What are the new features of the Volkswagen Touareg?
The updated Touareg has more than 2300 redesigned parts and boasts some new technological features: Side Scan, a blind-spot monitor : it uses radar at the rear of the car to sense another car’s presence, and causes light-emitting diodes (LEDs) built into the wing mirrors to flash.
How often does a Volkswagen Touareg need to be replenished?
The Touareg contains a 4.5 US gallons (17 l; 3.7 imp gal) tank in the rear of the vehicle underneath the spare tyre which stores the AdBlue solution. It is estimated that this tank will need to be replenished every 6,000–10,000 miles (9,700–16,100 km).
How long does it take to replace a timing chain?
The timing chain replacement cost is higher than many other auto repair jobs in large part because of how long it takes to put a new timing chain into place. Oftentimes, it’s going to take a mechanic between 4 and 6 hours to complete a timing chain replacement job from start to finish.
Can you drive a car with a bad timing chain?
Bad timing chains have been known to cause clattering sounds that can get to be worse over time. Rather than turning up your car radio and ignoring the sounds, you should seek the services of a mechanic right away and pay the timing chain replacement cost if need be. Can You Drive a Car With a Bad Timing Chain?