How much gear oil is in a VW Jetta?
1.8 liters (1.9 quarts) of gear oil (the transmission and differential share the same oil in the manual transmission) G52 VW gear oil (22 or 23 mm deep socket for the reverse sensor) VW G52 gear oil has been shown to be thinner than most 75-90w oils.
Can you change the transmission on a VW Jetta?
Volkswagen changed the transmission angle so the fill hole on your 5 speed mk5 Volkswagen Jetta TDI 2005.5-2006 is too low to allow all the fluid back in the normal way. For this reason, measure the amount drained to confirm that you drained 1.8 liters. This way you can add the fluid back to the correct.
How to check and fill VW Jetta transmission fluid?
Once the VW Jetta automatic transmission fluid service is finished, the transmission fluid level need to be confirmed and possibly topped off. Checking the transmission level is done with diagnostic software and through a level insert tube a few inches long mounted into the fill plug / port.
Where are the Torx on a VW Jetta?
There are 8x T25 torx on the sides and 3x T30 torx on the rear. There are some bumps along the front that will catch when you put it back. Note the angle during removal because this is the angle it wants to go back in. Clean the area around the fill and drain holes. This will prevent dirt from getting into the transmission.
What kind of oil does a VW Golf use?
1999-2004 Golf 1.9L TDI models with ALH Engine Code use VW 505 00 oil spec. 2004-2006 Golf 1.9L TDI models with BEW Engine Code use VW 505 01 oil spec.
What kind of oil does a VW Passat use?
2008-2010 Passat 2.0T models with CBFA or CCTA Engine Codes use VW 502 00 oil spec. VW Passat 1.8 Turbo Oil Specs 1998-1999 Passat 1.8T models use VW 502 00 oil spec. 2000 Passat 1.8T models use VW 502 00 oil spec. Owners will need to confirm their VIN.
Where is the transmission fluid in a Volkswagen Jetta?
The Jetta’s manual transmission has two plugs for filling and emptying the transmission fluid, located on the side and bottom of the transmission case. If you are simply checking the level of oil in your transmission, start by removing the top filler plug on the side of the transmission.
Is the Jetta 5 speed a manual transmission?
The early 2005.5-2007 Bentley service manual doesn’t mention this but it’s in a TSB for 2005-2006 New Jetta 5 speed 0a4 : gqq manual transmission (the one on your TDI). This procedure was corrected for the 2005-2010 edition Bentley service manual.
What kind of oil does a VW Beetle use?
1998-2004 Beetle 1.9L TDI models with ALH Engine Code use VW 505 00 oil spec. 2004-2008 Beetle 1.9L TDI models with BEW Engine Code use VW 505 01 oil spec. 2013-2014 Beetle 2.0L TDI models use VW 507 00 oil spec. 2015 Beetle 2.0L TDI models use VW 507 00 oil spec.