Why is my Honda Foreman 500 not working?

How to fix your Honda Foreman 500 Electric Shift Problems. Neutral was blinking 13 times, which means there is a problem with the throttle position sensor. How to fix your Honda Foreman 500 Electric Shift Problems. Neutral was blinking 13 times, which means there is a problem with the throttle position sensor. Skip navigation Sign in Search

Why does my Honda Foreman die after 10 minutes?

See title: runs fine for about 10 minutes then starts cutting out, backfires, and dies. Let it sit a few minutes and it starts again…repeat. I think I’m narrowing it down to fuel delivery and/or exhaust leak.

What to do if a Honda Foreman backfires?

I have an 2006 honda for.man 500es it is back fireing thought carb cleaned carb several times it does not want to idle with haven to keep your finger on the throttle put an inline see thought filter on the bike so i can see if carb is getting the fuel it needs it is full of fuel i do not know were to go from here can anybody help me thanks

What causes idle surges on a car ECM?

Idle surging can be caused due to other issues in the car, but if it happens in conjunction with other throttle position sensor symptoms, the culprit is often the TPS. At idle, the ECM will not get the correct information and the throttle will variate randomly causing idle surges.

What causes reverse switch to break during idle?

Vibration induced by certain RPM’s can cause the reverse switch spring connection to break contact briefly, turning the limiter on intermittently – try grounding the wire and see if the problem goes away. (I’d guess, from info so far, that this is the most likely culprit)… I cleaned the carb after the problem started.

Why is my Honda trx500 Foreman Rubicon not starting?

If the Honda TRX500 Foreman Rubicon won’t start and being to work, or if the four-wheeler has a hard time starting up, use the following troubleshooting guide to pinpoint the cause of the starting problem. 1. Does fuel reach the carburetor?

What to do if your ATV wont go into gear?

Troubleshooting an ATV that won’t go into gear or won’t shift gears can be quite complicated, but not always. Whether you’ll be able to address the issue on your own depends on the severity of the problem as well as your mechanical skill level.

What to do if your Honda trx500 wont start?

Use the above mentioned troubleshooting guide if the TRX500 won’t start. These procedures are also outlined in the factory service manual. It’s recommended to download the factory service manual when performing service, repair and maintenance to the all-terrine vehicle. Repair manuals can be downloaded from this site.

https://www.youtube.com/watch?v=YQUqBBzStbA

What to do if your Honda trx500 Foreman wont start?

1. Does fuel reach the carburetor? If fuel is not reaching the carburetor, check for a clogged fuel line or strainer, faulty fuel valve or clogged fuel tank breather hose. If fuel is reaching the carburetor, check spark plugs. 2. Spark plug inspection. Remove the spark plug and to see if the spark plug is wet.

When did the Honda trx500 Foreman Rubicon start?

Repair manuals can be downloaded from this site. These troubleshooting procedures apply to: 2005 2006 2007 2008 2009 2010 2011 2012 Honda TRX500FA FourTrax Foreman Rubicon, TRX500FGA FourTrax Foreman Rubicon GPScape, TRX500FPA FourTrax Foreman Rubicon GPScape Power Steering, TRX500, TRX 500 models.

What to do if your Honda cooling fan is not working?

There is a box behind the front right tire on the frame with 2 single wires (White and ?) with a connector with several wires in it coming out the top of the box. Take the single white wire and a few inches out of the box is a bullet connector. Take it apart there and put a ground wire in there and plug it back together.

Is there a problem with Honda es shift?

Unfortunately, there has been one problem with ES shifting that has affected many ES owners at one time or another: The problem is that, at times, when you make a shift (up or down) on an ES machine, the shift is not complete.

Is the Honda foot shift electric or manual?

Many of us have Electric Shift (ES) models. In fact, Honda sells approximately EIGHT times as many ES models for every foot-shift model sold. The ES models are very reliable. But, because of the number of ES machines that are sold and owned, it sometimes seems that there are more difficulties with ES shifting than with manual shifting.

Why is my shift button not working on my Honda?

You can hear the shift motor trying to make the shift when you press a shift button <->, but no shift occurs and, at times, you receive a – – – display. The problem occurs even more often when it is cold outside. Fortunately, the answer/fix to the problem is really very easy!

Can a Honda Foreman 500 shift with a wrench?

Yup, the answer was to shift it with a wrench. I hate to tell you, but it is only your fault for buying an ES. I haven’t ever seen one that shifted as good as a manual. I never understood why people feel the need to have a 4 wheeler ride like a car.

Can you use a foreman 450 with a Rubicon 500?

I have a 03 Foreman 450 es and a 08 Rubicon 500 with es. no issues with the Rubicon mainly use it in auto. The Foreman only has shifting issues with it is cold once it warms up it shifts fine. I think we had this conversation a while back too. I have an uncle that lives on Wards Chapel does all the Christmas lights every year.

Where can I get a Honda foreman for free?

You can contact them at [email protected] or call Tyler @ 601-616-3299. Also i purchased for $50.00 with free shipping. Hope you find your answers. Crystal Did you find the recommended reading relevant to this discussion?

What’s the price of a 2005 Honda FourTrax Foreman?

2005 Honda FourTrax Foreman® 4×4 ES pictures, prices, information, and specifications. Below is the information on the 2005 Honda FourTrax Foreman® 4×4 ES. If you would like to get a quote on a new 2005 Honda FourTrax Foreman® 4×4 ES use our Build Your Own tool, or Compare this ATV to other Utility ATVs.

What kind of engine does a foreman 500 have?

Honda Foreman 500 Specs and Features (2005 TRX500TM) Engine – Uses a longitudinally-mounted four-stroke, air-cooled single-cylinder OHV engine. It has a bore-stroke ratio of 92 mm x 71.5 mm.

What to do with a foreman 500 ESP?

Some Honda enthusiasts stay away from ESP-equipped Foreman 500s because of this problem and advise owners to keep a shifter wrench with them at all times. A band-aid fix for this would be to stop the bike and turn off the engine, then turn it back on, down-shift to neutral, and crank and shift to your desired gear in the shortest time possible.

Honda Foreman 500 Specs and Features (2005 TRX500TM) Engine – Uses a longitudinally-mounted four-stroke, air-cooled single-cylinder OHV engine. It has a bore-stroke ratio of 92 mm x 71.5 mm.

How big is the Honda Foreman 500 battery?

Its charging system is a triple-phase output alternator powered by a 12V, 200-CCA (Cold Crank Amp) Honda Foreman 500 battery with a dimension of 5.8 x 3.26 x 5.71 inches (L x W x H). Lubrication – Oil capacity differs with and without an oil filter change. At draining, it is 2.5 US quarts.

Which is better Honda Foreman 450 or 500?

It had a broader front and rear track and was longer than the Honda Foreman 450. It also had better-revving than its precursor – thanks to its 15-percent power gain and its throttle position sensor. The Honda Foreman 500 also had the convenience of electric starting and a beefier clutch to handle the increased power output.

What to do if your Honda Foreman won’t shift?

Put a socket on it and see if the bike will shift manually. If not then it’s either the section with the 2 sensors on it or the mechanism inteernally itself. You can’t post conmments that contain an email address. I have a 2003 Foreman ES and the engine and transmission share the same oil on mine.

What to know when your Honda transmission fails?

What you may notice when Honda transmission fails: Car jerks when accelerating. Car refuses to move when in gear. Transmission slips when changing gears. Transmission is noisy in neutral. Transmission pops in and out of gear. Transmission slips or won’t engage. The engine revs up before the car starts moving.

What happens when you change gears in a Honda?

Once the coolant mixes with the transmission fluid, it destroys the transmission bands and requires a complete transmission rebuild. What you may notice when Honda transmission fails: Car jerks when accelerating. Car refuses to move when in gear. Transmission slips when changing gears. Transmission is noisy in neutral.

Is there a Honda Foreman es that won’t shift?

I have a 450 Honda Foreman ES that won’t shift down from 2 to neutral it will shift up but won’t go down below 2 Have replaced the motor and the angle sensor with no change. Any suggestions Clicking this will make more experts see the question and we will remind you when it gets answered.

How many miles does a Honda Foreman have?

Not to hijack, but a local 2000 foreman has under 2000 miles, which seems odd but it looks good. Even with regular service, would just the corrosion and deterioration over time make this a worthwhile machine? I don’t want to jump into a money pit. Click to expand…

Is there anything wrong with a foreman 450?

They say nothing is wrong with it at all. I’m selling my rancher that’s in my signature for 1400 and also getting a Yamaha big bear 350 that doesn’t run with the 1400. Using the 1400 as the down payment and going to sell the big bear to make up the rest.

Is the Honda Foreman 650 Rincon stuck in gear?

I know that the 2003 650 Rincon will not start in gear unless in neutral..unless you pull the front brake lever.. then it will start.. Im also having problems with my honda foreman 450es shifting lower then 2nd gear but when it does shift to 1st ,reverse and neutral then it will not shift to 2nd 3rd 4th 5th

Can a Honda Foreman 400 start in gear?

I heard of a Foreman 450 and a Foreman 500.. But not a Foreman 400 thanks for the info,how will i start it now since its in gear, is it a hard job to get to the clutch?? Some bikes will start in gear if you pull the front brake and try to start. This may be a mod that only the newer bikes come with.

Is it a rancher 400 or a foreman 450?

Is it a Rancher 400.. or a Foreman 450..I didn’t think they made a Foreman 400. I heard of a Foreman 450 and a Foreman 500..

Navigation