Why does my golf cart have no spark?

Why does my golf cart have no spark?

A golf cart spark plug may not be working due to a broken insulator, loose ground connection or a faulty RPM limiter in the golf cart. The insulator in the spark plug is broken causing an internal grounding. There is a loose ground connection from the battery to the frame or frame to the engine.

How do you test a golf cart Ignitor?

Testing Your Ignitor

1. Park your cart and put bricks behind the wheels to keep it from moving.
2. Open up your cart engine and attempt to identify the ignitor using your cart engine schematic.
3. Trace the ignitor back to the pulsar to see where they are connected together on your cart.

How do you test a club car coil?

Steps to test the ignition coil on a Club Car Golf Cart: Get the negative terminal of the golf cart batteries disconnected with the help of a wrench. Get the wires which lead to the ignition coil disconnected. Check to confirm if the thicker wire is attached to a wiring harness that can be unplugged.

What kind of motor is in a gas powered golf cart?

Gas powered golf carts use regular unleaded gasoline. The average gas powered carts have 10 to 12 horsepower. These engines operate similar to that of a car which means that their maintenance will be similar to that of a car.

How do you remove the rev limiter on a club car?

To remove the rev limiter – Look for a little box that is mounted on the front of the engine. In that area there is a black wire that is grounded by a screw to metal. Remove the screw holding the black wire and tie electrical tape around the black wire. *Max revolutions per minute on this engine is 4000RPM.

How do I know if my pickup coil is bad?

Signs of a Bad Pickup Coil

1. No Engine Spark. The pickup coil sends the signal from the ignition module to the spark plugs during the ignition process.
2. Rough Idle. Because the spark plugs are not communicating proper timing to the fuel injectors, a rough idle may occur.
3. Engine Stall/Failure to Accelerate.

How do you check a coil on a Yamaha golf cart?

The way to test a coil is go from the blue wire (coil kill lead) and ground you should get about 1.0 ohm, set ohm meter to K (1000) , test coil lead and coil kill lead (or blue wire you should get 9 to 12k ohms.

How do I get more power out of my gas golf cart?

Change the Speed ControllerThe Speed Controller regulates the electric output of the motor; a higher voltage equals more RPM, and the faster your cart will travel. When you change the speed controller, you can reduce the voltage and increase the amperage of the motor, resulting in increased torque.

Who makes the best golf cart engine?

Here are the top best 5 golf cart brands to choose from.

• Club Car. If you’re looking for a classic ride, look no further than the Club Car.
• E-Z-Go. If safety is your first priority, then the E-Z-Go brand is perfect for you.
• Yamaha. Chances are, you’re very familiar with the Yamaha brand.
• Polaris.
• Garia.

How to troubleshoot a club car with no spark?

Thanks to Wass for writing this Troubleshooting Guide for a Club Car with no spark. Here is a step by step guide to trouble shooting 92-96 Club Car with no spark. For 97-up, skip step 3. Step 1. Un plug the black/white wire from the limiter, down by the base of the dip stick, in this area. If it still does not spark, go to step 2.

What is the spark plug gap on a 1998 Club Car?

The spark plug gap of a 1998 Club Car DS and a 2006 Club Car DS range between 0.027 to 0.031 inches. The spark plug gap of a 1996 Club Car DS can be anywhere between 0.028 to 0.032 inches.

What should I do if my spark plug is not working on my golf cart?

Yamaha G16 Golf Cart Ground the threaded portion of the spark plug that is connected to the engine. Crank the engine and check for spark. If there is no spark, unplug the white plug with blue and black wires that are at the bottom of the engine under the valve cover.

What’s the spark plug gap on an EZGO golf cart?

EZGO TXT/RXV with NGK BP4HS spark plugs have a spark plug gap between 0.025 and 0.030 inches. EZGO golf carts with NGK BPR4ES spark plugs typically have a spark plug gap between 0.028 and 0.030 inches.