When do Mercedes Benz Sprinters start to have problems?
The majority, but not all of the problems occurring with these vehicles occurred after the initial 100,000 miles. It is my belief that the problems I have experienced, will occur with a vast majority of every Sprinter as the mileage of each vehicle approaches 120,000 miles.
What causes a car starter to not turn over?
However, when powered, it should send a signal to the starter relay once the key is turned or the starter button is pressed. If you press this button or if you turn the key on a manual ignition switch and the vehicle does not turn over, it may be caused by a problem with the starter relay.
Can a bad ignition switch cause a starter relay to fail?
Although it’s unlikely that you’ll ever experience a problem with the starter relay, it is prone to mechanical failure and will need to be replaced by a professional mechanic if it wears out. Most of today’s modern cars and trucks have an electronic ignition switch that is activated by remote key.
Where are the sensors in a Mercedes Benz Sprinter?
The exhaust system is comprised of a CDI (control unit) which monitors and actuates the sensors and valves in the exhaust system; a DEF pump. A DEF tank, a DEF temp sensor, a DEF level sensor and an SCR control unit with actuators and sensors. These items a located under the hood.
Are there any records for Mercedes Benz Sprinters?
These records are available to Mercedes Benz if desired. This article is being written to warn potential buyers of this vehicle of the fatal flaw hidden in each of these vehicles.
What do the lights on the Mercedes dashboard mean?
Modern Mercedes-Benz cars are filled with lots of sensors that monitor how each system in the car is behaving. The lights on the dashboard display what systems are in use and they also highlight when one of those systems is not working as it should. But what do all those different symbols mean?
The majority, but not all of the problems occurring with these vehicles occurred after the initial 100,000 miles. It is my belief that the problems I have experienced, will occur with a vast majority of every Sprinter as the mileage of each vehicle approaches 120,000 miles.
What does the check engine warning light on a Mercedes Sprinter mean?
Description: The Mercedes Sprinter engine oil level light comes on in yellow and is typically associated with low engine oil level. Description: The Mercedes Sprinter check engine warning light has several potential faults associated with it. When the check engine warning light comes on, fault codes are stored and must be read by a diagnostic tool.
Modern Mercedes-Benz cars are filled with lots of sensors that monitor how each system in the car is behaving. The lights on the dashboard display what systems are in use and they also highlight when one of those systems is not working as it should. But what do all those different symbols mean?
What kind of dash kit does a Mercedes Benz have?
Mercedes S-Class 92-99 stainless steel door pillar, 6 Pcs. Mercedes S-Class 2000-2006 exterior kit, 6 Pcs. Mercedes Benz S-Class 2007-2013 exterior kit, 6 Pcs. Mercedes B-Class 2005-2011 full interior dash kit, Without Navigation System, 56 Pcs.
How much does a sprinter exhaust system cost?
When you couple the excessive charges for routine maintenance with the astronomical charges for repairs to the items associated with the EGR-DEF- Exhaust System, the cost of ownership is an expense that can greatly affect your bottom line. Our expenses for a fleet of 28 Sprinter vans (2012’s & 2013’s) in 2014 was a staggering $270,000!
Why is the Turbo not working on my sprinter?
Turbo Actuator: We don’t offer this item separately, but often times the turbo isn’t working correctly because the electronic actuator is broken. Pre 2007 turbochargers can have their actuators adjusted. Turbo Resonator: Common failure part on these vehicles. Can replace with a durable aluminum unit to fix the faulty factory part.
What causes boost to fail on Sprinter van?
Turbocharger Actuator On the modern diesel engine used in the Sprinter van, boost pressure is controller using a vane-system. The control valve for the vane system is electronically controlled and can fail. The turbocharger is still healthy, only the control valve has failed.
What kind of car won’t shift out of second gear?
If you own a Chrysler vehicle and it won’t shift out of second gear, read this post. If you own a Chrysler, Dodge, or Plymouth vehicle and discover that the transmission will shift from first to second gear but will not shift out of second gear, your vehicle has locked itself into “limp-in” mode.
Turbo Actuator: We don’t offer this item separately, but often times the turbo isn’t working correctly because the electronic actuator is broken. Pre 2007 turbochargers can have their actuators adjusted. Turbo Resonator: Common failure part on these vehicles. Can replace with a durable aluminum unit to fix the faulty factory part.
What should I do about my pre 2007 sprinter?
Pre 2007 turbochargers can have their actuators adjusted. Turbo Resonator: Common failure part on these vehicles. Can replace with a durable aluminum unit to fix the faulty factory part.
Turbocharger Actuator On the modern diesel engine used in the Sprinter van, boost pressure is controller using a vane-system. The control valve for the vane system is electronically controlled and can fail. The turbocharger is still healthy, only the control valve has failed.
Is there a problem with the sprint shift box?
I have a 316cdi with sprint shift, the problem is that occasionaly it will jump out of gear, this only happens when pulling away and therefore only when in first gear. The rest of the time the box behaves and has no other faults.
Is there a clutch pedal on the SprintShift box?
Thanks rufus, the sprintshift box is a fully electronic controlled manual box, the gear lever can be used to change gear or placed in auto mode, there is no clutch pedal, the clutch is opporated by means of a hydraulic ram again all computer controlled.
Where do you put the regulator on a sprinter?
It makes it easier if you have the left hand threaded pin in place in the regulator flange mounting hole, before offering it into place. (left hand in fitting position, if standing at front of engine) Once the two pins are re-fitted the electrical connector can be attached and the intake manifold upper half rebuilt.
Where can I find a Mercedes Sprinter 316 CDI?
Located on Merseyside we have a stunning MWB Mercedes Sprinter 316 cdi which was coach built from new by Lancashire based coach builder NEW VENTURE. This conversion is second to none and though it looks great in the pictures and video, you really need to see it for yourself, it really is in incredible condition.
How can I tell if my Mercedes Sprinter has a problem?
A quick and dirty test to indicate any problems with the variable vanes is to remove the air box or air filter housing and listen as the engine is revved. Once the engine is started, the vac actuator rod should move down slowly as vac builds, this in turn should apply force to the lever moving the vanes into a fully charged position.
When did Dodge stop making the Dodge Sprinter?
Manufactured by Daimler AG under a few different brand names (Mercedes-Benz, Dodge, Freightliner, Volkswagen), the Sprinter could be considered a true “World Van.” Jan 1, 2010, Sprinter vans will no longer be sold under the Dodge nameplate in the USA.
I have a 316cdi with sprint shift, the problem is that occasionaly it will jump out of gear, this only happens when pulling away and therefore only when in first gear. The rest of the time the box behaves and has no other faults.
What’s the difference between service A and B on a sprinter?
There have been some changes in A’s and B’s for the Sprinter’s: For ’07-14, A’s are every 10k, B’s every 20k. For ’15+, Mercedes has extended the intervals (maybe in order to make it appear like the vehicles cost less to maintain?) to A’s every 20k, B’s every 40k.
What should fuel pressure be to start sprinter?
You must have at least 2500 PSI to start. 3. If no or low fuel pressure the nasty little culpret may be a 25 cent o-ring. The fuel pressure regulator is located at the rear of the fuel rail on 2002 to 2004 trucks. Its held in with two little torx head screws and can be a mother to get out. It’s not terrible you just have to work by feel mostly.
What should I do if my sprinter wont start?
Inspect the o-ring and back up washer on the end of the regulator. If you have a split or tear in this o-ring you just found your problem. Replace the o-ring and reinstall. Dont let your dealer try to sell you the whole regulator for $300 the o-ring only kit is part number is 05175439AA.
You must have at least 2500 PSI to start. 3. If no or low fuel pressure the nasty little culpret may be a 25 cent o-ring. The fuel pressure regulator is located at the rear of the fuel rail on 2002 to 2004 trucks. Its held in with two little torx head screws and can be a mother to get out. It’s not terrible you just have to work by feel mostly.
What kind of data card does sprinter have?
Help other T1N owners by posting your experience working on your Sprinter. Moog Control Arms Vs. OEM Data Card Datacard Revealed. I’ll show mine, you show yours.
Where can I buy a new Sprinter van?
Post Sprinter Vans for sale here. Vans must be driveable, otherwise, they go to the parts section here. Post Sprinter Parts for sale here, including vans that are not driveable. OMG!!! Can I get a decent price on a van already???
What’s the difference between a Mercedes and a Mercedes Sprinter?
The comparison is clear. While you will feel the Mercedes-Benz difference in the Sprinter’s handling––especially maneuvering on city streets––the other side of that coin is that maintenance costs tend to be higher for the Mercedes van. Because, according to Jalopnik, the only piece of a Mercedes-Benz Sprinter that is locally sourced is the battery.
Can a Mercedes Sprinter be turned into a camper?
These allow you to completely stand, which is great for cooking, getting dressed and hanging out. There are also several types of Mercedes vans you can turn into a Sprinter van conversion: Cargo, Crew and Passenger. Cargo vans are the most popular to turn into a camper as they’re a blank slate.
Are there Sprinter vans that can be converted?
All 2019 Sprinter vans and newer will be made in the U.S.A. Of all the larger panel vans, Sprinter vans are the most expensive vans to turn into a Sprinter conversion.
The comparison is clear. While you will feel the Mercedes-Benz difference in the Sprinter’s handling––especially maneuvering on city streets––the other side of that coin is that maintenance costs tend to be higher for the Mercedes van. Because, according to Jalopnik, the only piece of a Mercedes-Benz Sprinter that is locally sourced is the battery.
Is the Mercedes-Benz Sprinter a global player?
The new Sprinter – a Global Player. More than 3.4 million units delivered in 130 countries confirms: the Sprinter is a global player. The third generation of the large Mercedes-Benz van is now making history. The new Sprinter – a Global Player.
How long does it take to shift a Mercedes Benz?
These simple do it yourself instructions take less than 5 minutes. No tools are required to perform this procedure and make your Mercedes-Benz shift like new. Try this if your car has been shifting sluggish recently. This will make your car fun to drive again, it’s like getting a free tune-up.