What does hard starting on a Harley Davidson mean?

If hard starting was engine barely or doesn’t turn over, it would mean two things, your battery should be back up to full and with surface charge reserve of 14V (2 volts over full charge 12.6 or so) so battery “should” not be an issue IF charging ckt and connections are sound.

What does it mean when your Harley won’t crank?

Harley Davidson Softail will not crank refers to when the crankshaft will not turn so as to start the engine. In other words, not only will the Softail engin… Harley Davidson Softail will not crank refers to when the crankshaft will not turn so as to start the engine. In other words, not only will the Softail engin…

What causes a Harley Davidson to not turn over?

If the bike does not turn over, the issue can be battery, starter, starter relay. If turns over, but no start, determine if the issue is electrical or fuel related. Check for spark.

What should I do if my motorcycle won’t start?

If the reading stays steady, your battery is good to go—and your motorcycle likely has another problem (or a few problems). Fortunately, there are other troubleshooting means that can help determine why your bike won’t start.

What to do if your Harley Davidson won’t start?

Harley Davidson Won’t Start But Cranks HELP! – YouTube Harley Davidson Won’t Start But Cranks HELP! If playback doesn’t begin shortly, try restarting your device.

If the bike does not turn over, the issue can be battery, starter, starter relay. If turns over, but no start, determine if the issue is electrical or fuel related. Check for spark.

What to do if your bike won’t start?

Your battery may have enough charge to run the electronics, the fuel pump even, but not enough to turn over the motor. With a digital multimeter, test the battery’s voltage. If is isn’t reading over 12V, you’re under charged and it’s a good place to start. Plug in your battery charger, and come back in an hour to try again.

What’s the voltage on a Harley Davidson starter?

I check the voltage at the kill switch and get 12.3 from the black and white wire that goes to the kill switch and the start button. But, I only get 9.2 volts from the black and red wire from the start switch to the start relay. All the fuses are good and there are 12 volts to the starter and the solenoid.

Why does my Dyna FXDC bike not start?

Alarm, clutch inhibit & neutral safety all come from the TSSM. The TSSM controls the start relay. 09 Dyna FXDC, got power everywhere. Lights,Horn,Turn`s,Fuel Pump,Dash, Turn the key on, hit the run/stop switch, push the start button and Nothing. Not even a click or a buzz. Bike has been sitting for about 2 weeks.

Can a cold engine start a Harley Davidson?

After waiting say 15 or 20 minutes, it starts fine. It doesnt do this all the time and never when I first start with a cold engine. Only after I have been riding awhile sometimes it will start right away but seems after the 4th or 5th stop nothing, it just cranks like it not getting any gas or not firing.

1) Place Bike in NEUTRAL. 2) Remove the fuse cover and locate the start Relay. It is the GRAY one. On the inside cover there is a label that will identify the START Relay. 4) Look at the bottom of the removed gray relay closely. You will see pin notation as follows. 87,,87A,,30,,85,,86. 5) Leave the relay REMOVED from the bike.

Are there any battery problems with a Harley Davidson?

With that can come some Harley Davidson charging problems. Bob shares some tips on battery replacement and upkeep. Batteries have come a long way since we shot this video.

What can I use to charge my Harley Davidson battery?

You can try using a good jumper wire from your battery positive post to your starter solenoid. Remove the (usually) green wire 1st. This eliminates the rest of your harness. If it still has trouble turning over, you need to address the starter, or you have created too much compression.

What is the life expectancy of a Harley Davidson battery?

Do not mess around with weaker, or cheaper batteries. Especially for a newer Touring Harley. A weaker battery will shorten the life expectancy of your starter & starter ring gear.

What are the problems with a Harley Davidson starter?

Harley Davidson Common Starter Problems Summary and Fixes – YouTube There are a few very common HD Starter problems. It starts with pushing the start button on only hearing a There are a few very common HD Starter problems. It starts with pushing the start button on only hearing a Skip navigation Sign in Search Loading…

Why does my Sportster bike hesitate to start?

Same results with either, indicators on charger show battery is charged but bike is slow and hesitates to crank. I just replaced my battery after 2.5 years of using. pretty much same issues as you are seeing – hesitation at start and it was getting worse.

How old is the battery on my Sportster?

All the battery cables are tight and the battery stays on a battery tender and is charged up. The battery is the original that came with the bike and is about 15 months old. Has anyone experienced this problem and what was your solution?

With that can come some Harley Davidson charging problems. Bob shares some tips on battery replacement and upkeep. Batteries have come a long way since we shot this video.

Can a non kick start motorcycle start without a battery?

A non-kick start motorcycle most likely will not be able to start without a battery, even after you rewire the ignition coil to the stator. Without adding the compression of the engine activated by the kick starter, there won’t be enough power to start it in the first place.

Can a starter wire be wrong on a Harley?

The starter relay wire itself can also be wired incorrectly. This can be checked by using a volt meter and a Harley wiring diagram. Terminal contacts inside the solenoid housing should also be checked to make sure they were not over-tightened and twisted during installation.

Can you change the front end of a Harley Davidson?

Harley-Davidson has designed and manufactured this custom front end according to our very stringent and well-tested standards. If you modify the FLSTS Springer front end in any way that changes our original design, Harley-Davidson cannot and does not assume responsibility for mishaps resulting from these changes. 1WARNING

When did Harley Davidson motorcycles switch from kick start?

The last year they offered kick-start bikes was on the 1986 Wide Glide which featured the Evolution (Evo) engine. Despite their discontinuation, a number of third party providers continued to sell kick-start conversion kits well after 1986. Have you been hacked? 80% of emails online have been exposed in data leaks. Tap to check for your leaks.

What happens when you hard start a Harley Davidson?

Get back and more will depend on your findings.. I would NOT throw Major parts at it unless necessary…. You can spend a ton of money to only find the Least expensive things are the problems.. Hard starting when HOT, but the engine spins up fine, means either lack of fuel or weak, no spark.

When did the Harley Davidson FXEF Fat Bob come out?

The base, kickstart-only FX was discontinued in 1979. In that same year, the FXEF Fat Bob was introduced, offered with either cast or spoked wheels, and with either the 74 or 80ci motor. A 1979 Low Rider in metalflake silver with black trim was a sharp-looking bike. The Harley FXWG Wide Glide, based on the Low Rider, first appeared in 1980.

When is the Electric Harley Davidson coming out?

So far no pictures of a production electric Harley-Davidson have been released. But the Motor Company has told their dealers that the electric bike will be rolled out in late 2019 model year (Subject to change of course). They have purchased an electric dirt bike company to help them along. Personally: I liked the design of the Livewire prototype.

What should I do if my motorcycle battery wont start?

If the reading says anything close to or slightly below 12 volts, charge your battery and try starting your motorcycle again. If it has a really low number, such as 9 volts or below, then you battery is pretty much toast and you’ll need to purchase a new one.

What kind of bike won’t start when hot?

The bike now starts on the first kick nearly every time. Bike is a CB100 1972 with 2700 on the clock. My 81 cb650c don’t start when hot either. I thought it was a dead battery as the cranking was very weak and seemed to not have enough power to crank it over.. 30 minutes later, started right up.

Why is my starter so hard to start?

BUT, more compression and starting load means more strain and stalled current draw on the starter….all things being equal. “Usually hard starting is a tossup between aged battery or bad starter depending on duty of service time and stress wise.

What are the symptoms of hard starting a motorcycle?

Stumped to date. Symptoms: Hard Starting when engine cold. Outside temperatures in the 50s and higher, normally starts with a SINGLE blip of the starter, with NO throttle applied.

Where can I buy a 1975 Harley Davidson?

And check out the bike’s reliability, repair costs, etc. Show any 1975 Harley-Davidson FXE 1200 Super Glide for sale on our Bikez.biz Motorcycle Classifieds. You can also sign up for e-mail notification when such bikes are advertised in the future.

When does idle come back to normal on a Harley Davidson?

Just seems to happen when I’ve been running at a fairly wide open throttle maintaining higher speeds for a while (fwy) or longer stints (catching all green lights) on the streets at a speed of about 45 or more. It always seems to come back to a normal idle after getting back into first gear when stopped, or when I start going again in 1st.

Why does my Dyna hard start when hot?

You can spend a ton of money to only find the Least expensive things are the problems.. Hard starting when HOT, but the engine spins up fine, means either lack of fuel or weak, no spark. If your Dyna is EFI, your fuel pump is losing prime/pressure due to fuel line leak…look here:

Why is my starter not working on my Harley Davidson?

The starter did push through it but after about 1/2 of a revolution, the engine kicked back as if the timing was too advanced. That caused the starter pinion to kick out of the ring gear which resulted in the starter grinding. I then released my finger from the start button. Pushed it again and it started correctly.

Why does my Harley Davidson 09 Ultra not start?

31,000 miles on my 09 Ultra. When the bike is HOT some times the engin will not crank. It sounds like gears grinding. When it does try to start it will hesitate as if the battery is weak. When it is at ambient temp it will crank right up.

Why does my Harley Davidson hesitate to start?

It sounds like gears grinding. When it does try to start it will hesitate as if the battery is weak. When it is at ambient temp it will crank right up. You sound convinced it is the compensator. Gears grinding=bad compensator. ?? How do you figure that. If you let off start button for even a nano second, it will grind pinion gear.

What are the symptoms of a bad starter?

Symptoms: When starter button is pressed there is a click and nothing happens or the starter drive tries to engage and then does not stay engaged. There is a lot of racket and noise like gears grinding.

Can a bad igniter cause a car to not start?

A malfunctioning main relay will give you the same symptoms as a bad coil or a bad igniter. But the main relay most often fails when the weather is really hot, while the other possible causes will exhibit the symptom nearly all the time.

Are there any problems with the HD starter?

There are a few very common HD Starter problems. It starts with pushing the start button on only hearing a “click”. It’s a quick summary of these problems and the fixes for them Category Autos & Vehicles Show moreShow less Loading… AutoplayWhen autoplay is enabled, a suggested video will automatically play next. Up next

Why is my Harley Davidson Ultra Classic not starting?

I have a 2010 ultra classic with ABS. It is not starting. The battery voltage is 12.75 off the battery. When I turn the main switch on, I get a drop to 12.5, and when the kill switch is turned on, I get a drop to 12.38. The self test goes out and hit the start switch with nothing – no volt drop, no starter engage, no nothing. DEAD.

Can you start a Harley Davidson HD without a fob?

Starting your HD without a Fob! Your HD has the ability to be started without a Fob present jus in case the Fob is lost or the battery goes dead! Your Pin# to over-ride the security system is usually loaded up with the last 5 numbers of your Harley’s serial # backwards! (EX: serial # last 5 is 1 2 3 4 5……….it was entered as 5 4 3 2 1).

What to do when your Harley Davidson won’t start?

Try neutral with clutch pulled in. Also battery connections , solenoid wire. The security system lights only flash after I turn off the bike. I have the bike in neutral and I even tried pulling in the clutch a couple of times. I checked the wire to the solenoid and it had power.

Why is my Harley Davidson battery not charging?

If the stator fails, your battery will no longer be charging when you’re riding your motorcycle. Often times, a short can happen in the windings around the stator. The insulation on the wires can wear down over time or a wire can break.

What should I do if my battery charger is not working?

Almost certainly it’s a battery problem, either low charge or bad cable connection. Charge the battery on a good bench charger, not a Tender, but a real charger. Remove and reconnect both battery cables making sure they are tight and connections are clean. This sounds like a discharged battery to me just saying.

What was the model number of a 1977 Sportster?

1977 Sportster Model Code Model Number Model Year XLH 3A 7 (1977) XLCH 4A 7 (1977) XLCR 7F 7 (1977) XLT 2G 7 (1977)

Why do I have a hard time shifting my Harley?

If you are experiencing Harley neutral issues, “hard neutral”, or having a tough time shifting your Harley, you may need to address your Harley-Davidson gear shift linkage as an assembly. Sometimes, a misaligned shifter linkage splines will be obvious to diagnose.

Is the Harley Sportster a good motorcycle to buy?

I like the Harley Sportster. It’s relatively inexpensive and it has all of the Harley good stuff. Power, hot looks and the Harley sound. Potato, Potato, Po-ta-to, I can hear it now, I love it!

Is there a 1977 Harley Davidson Sportster XLH?

1977 Harley Sportster #2283 This 1977 Harley Davidson Sportster XLH (3A code) has been nicely restored and may well be better than the original product. It is a great looking bike with a tank and instrumentation that appears to be from a ’90s Dyna. In 2015, the bodywork has been refinished in Ebony Black and the seat was reupholstered in leather.

I like the Harley Sportster. It’s relatively inexpensive and it has all of the Harley good stuff. Power, hot looks and the Harley sound. Potato, Potato, Po-ta-to, I can hear it now, I love it!

Navigation