How is the throttle body tested on a Volvo?
Using our bespoke Hardware-In-the-Loop test rigs each Volvo throttle body is tested under real-world load and driving conditions. Once all internal faults have been identified our technicians will rebuild the throttle body using components higher rated than standard to ensure the faults do not return.
How long does it take to repair a Volvo ETM?
No software reload or calibration is required after installation. Quick Turnaround: Your module will be tested, repaired, tested again, and sent back to you in the same day (unless otherwise noted). Contact-less programmable dual-sensor TPS upgrade: Zero wear Hall-Effect dual Throttle Position Sensor, designed and manufactured by XeMODeX.
Is there a reload button on Volvo ETM?
ETM throttles with these modifications were marked with a yellow label instead of the original white. However, since that sensor has to be rolled into a perfect circle there are limits to how thick the carbon can be, otherwise, it will simply crack. Reload Required?
What’s the top rev limit on a Volvo?
This is a very common failure, that normally starts as an intermittent fault causing the engine to run in ‘limp home mode’ this restricts the vehicle to around 30 MPH and a top rev limit of no more than 3 thousand revs until the ignition is cycled again.
Why is the ETM on my Volvo Car yellow?
Over the years, the manufacturer tried to correct this problem with wider and thicker runs as well as softer metal wipers. ETM throttles with these modifications were marked with a yellow label instead of the original white.
How to replace the throttle body on a 2001 Volvo S60?
2001 Volvo S60 2.4 L5-2.4L VIN 61 B5244S Throttle body (electronic throttle module, ETM), replacing Replacing the electronic throttle module (ETM) Disconnect the battery negative lead. Remove the intake pipe between the front cover plate and the air cleaner (ACL).
When did Volvo switch to electronic throttle module?
Volvos affected by the electronic throttle module (“ETM”) are 1999-2002 models (US model years). Before 1999, Volvo used a good old mechanical set of parts to control the throttle. In 1999, they switched to a “fly-by-wire” module… this problematic ETM. This design affects almost a half-million Volvo gasoline cars.
Where can I buy a used Volvo V70?
Description: Used 2004 Volvo V70 2.4 with Rear Bench Seats, Audio and cruise controls on steering wheel, Fold Flat Rear Seats, Multi-Zone Climate Control, Alarm. This 2001 Volvo V70 is offered to you for sale by Kendall Toyota of Bend. How to protect your purchase? CARFAX BuyBack Guarantee got you covered.
Which is contact less TPS sensor does Volvo use?
Contact-less programmable dual-sensor TPS upgrade: Zero wear Hall-Effect dual Throttle Position Sensor, designed and manufactured by XeMODeX. This contact-less TPS design eliminates any friction related TPS failures. XeMODeX TPS sensors are fully programmable unlike the clones out there which are pre-set and locked.
How to repair an ETM in a Volvo?
Step 1: Purchase our repair service online or over the phone. Step 2: After processing your order, we will email you pre-paid shipping labels. Step 3: Send us your old defective unit by dropping off the package to any UPS location, or call UPS to schedule a pickup. Step 4: We will inspect and repair your old module.
Where can I get a new throttle body?
Throttle Housing by Professional Parts Sweden®. Bring your vehicle’s fuel system back to its top shape with this top-notch part. Designed as a direct-fit replacement of your worn-out or malfunctioning part, it will provide easy,… Fuel Injection Throttle Body by Vemo®.
What does the throttle body assembly consist of?
Throttle Body Assembly by Bosch®. The throttle body is an essential part of the inlet air stream of modern gasoline engines. It is designed to control the amount of fresh air entering the engine. The throttle body assembly consists of…
Can a Magneti Marelli throttle body be rebuilt?
We have been rebuilding these Magneti Marelli throttle bodies for many years and are extremely proud of our very high lifetime warranty standards, so you can be assured of our quality of work. How do I get my unit rebuilt?